Influence of coagulation mechanisms and floc formation on filterability

Minimizing particles in water is a key goal for improving drinking water quality and safety.The media filtration process,as the last step of the solid–liquid separation process,is largely influenced by the characteristics of flocs,which are formed and controlled within the coagulation process.In a laboratory-based study,the impacts of the physical characteristics of flocs formed using aluminum sulfate on the filtration treatment of two comparative water samples were investigated using a photometric dispersion analyzer and a filterability apparatus.In general,the optimum dosage for maximizing filterability was higher than that for minimizing turbidity under neutral p H conditions.For a monomeric aluminum-based coagulant,the charge neutralization mechanism produced better floc characteristics,including floc growth speed and size,than the sweep flocculation mechanism.In addition,the charge neutralization mechanism showed better performance compared to sweep flocculation in terms of DOC removal and floc filterability improvement for both waters,and showed superiority in turbidity removal only when the raw water had high turbidity.For the different mechanisms,the ways that floc characteristics impacted on floc filterability also differed.The low variation in floc size distribution obtained under the charge neutralization mechanism resulted in the flocs being amenable to removal by filtration processes.For the sweep flocculation mechanism,increasing the floc size improved the settling ability of flocs,resulting in higher filter efficiency.     

LNG储罐安全阀泄漏分析与故障排查

针对16×10~4m~3LNG储罐安全阀泄漏问题,从阀门结构角度对泄漏原因进行了详细的分析,认为主要有三种可能:(1)导阀失效;(2)上阀腔漏气;(3)阀座密封不严。根据分析结论,提出了故障排查的方法以及操作步骤;结合阀门解体检查情况,建立了阀门失效的故障树,从投产、阀门运行维护角度提出了相关建议。     

酸性水储罐安全性研究

为预防酸性水储罐气相空间闪爆事故的发生,取样分析了某炼厂酸性水罐气相空间组成,根据气相组成配制了3种混合可燃气体,利用5 L爆炸极限测试仪测定了混合可燃气体在不同氧含量条件下的爆炸极限,根据爆炸极限数据计算出3种混合可燃气体的极限氧含量。结果表明:随着体系中氧含量增加,爆炸上限明显升高,爆炸下限无明显变化;烃类物质含量高时,混合可燃气体的爆炸上下限均降低,爆炸极限宽度变小;硫化氢和氢气含量高时,混合可燃气体爆炸上下限均升高,爆炸极限宽度变大;3种气相组成的极限氧含量分别为:8.1%、9.9%和10.3%,为防止罐顶气相组成发生闪爆,建议氧含量浓度控制在4%以内,当氧含量浓度到达5%时建议启动氮气联锁进行惰化和稀释。     

一种生物除臭方法及装置的研究

文章介绍了一种生物除臭的方法,这种方法是将装有碳质填料的反应包悬挂于好氧池中,反应包在好氧池中,历经曝气挂膜20~30天;就可以将装有碳质填料的反应包/或碳质填料放于生物除臭装置内;然后向生物除臭装置通入湿润的臭气,就可以将其生成水、二氧化碳、硫酸、硝酸和亚硝酸.使臭气被氧化,转化成无污染的物质,由于它的转化效率高,符合现代生产的高效性,因此一定会在生产实际中受到欢迎.     

复合膜生物反应器处理环氧氯丙烷废水

实验利用复合膜生物反应器处理以甘油为原料制备环氧氯丙烷产生的废水,考察了不同进水COD、水力停留时间以及盐度对处理能力的影响,并进行盐度冲击实验。生物处理后出水进行了深度处理的研究。结果表明:进水COD对处理能力影响较小;适当延长水力停留时间能优化出水水质;废水盐度高于22g/L时会对微生物产生抑制作用;深度处理能进一步降低出水COD;微生物通过一定时间的驯化期能适应并处理高盐度废水。     

微电解-生化法处理大蒜废水工程实例

针对大蒜废水特点,采用了铁屑微电解-UASB-接触氧化工艺进行处理.运行结果表明:在设计进水水质、水量范围内,COD、BOD5、氨氮和ss去除率分别为98%、99%、70%和98%,出水各项指标均达到GB 8978--1996<污水综合排放标准>中的一级排放标准,系统运行费用为1.19元/m3.     

Community structure and elevational diversity patterns of soil Acidobacteria

Acidobacteria is one of the most dominant and abundant phyla in soil,and was believed to have a wide range of metabolic and genetic functions. Relatively little is known about its community structure and elevational diversity patterns. We selected four elevation gradients from 1000 to 2800 m with typical vegetation types of the northern slope of Shennongjia Mountain in central China. The vegetation types were evergreen broadleaved forest,deciduous broadleaved forest,coniferous forest and sub-alpine shrubs. We analyzed the soil acidobacterial community composition,elevational patterns and the relationship between Acidobacteria subdivisions and soil enzyme activities by using the 16 S rRNA meta-sequencing technique and multivariate statistical analysis. The result found that 19 known subdivisions as well as an unclassified phylotype were presented in these forest sites,and Subdivision 6 has the highest number of detectable operational taxonomic units(OTUs). A significant single peak distribution pattern(P 0.05) between the OTU number and the elevation was observed. The Jaccard and Bray–Curtis index analysis showed that the soil Acidobacteria compositional similarity significantly decreased(P 0.01) with the increase in elevation distance. Mantel test analysis showed the most of the soil Acidobacteria subdivisions had the significant relationship(P 0.01) with different soil enzymes. Therefore,soil Acidobacteria may be involved in different ecosystem functions in global elemental cycles. Partial Mantel tests and CCA analysis showed that soil pH,soil temperature and plant diversity may be the key factors in shaping the soil Acidobacterial community structure.     

可再生胺类脱硫剂的选择研究

采用哌嗪等二元胺和二乙醇胺为吸收剂,对模拟烟气进行SO2的吸收解吸实验研究,筛选出性能优异的吸收剂,并考察添加剂H2 S O 4对其性能的影响。实验表明:可再生胺类吸收剂脱硫率可接近100%,二元胺吸收剂较醇胺的SO 2吸收量大、pH值随时间变化慢、首次解吸率高;羟乙基支链对胺类吸收剂的抗氧化能力、SO2吸收量和首次解吸率均有影响,环状二元胺比链状二元胺的抗氧化能力好、首次解吸率高;在N-(2-羟乙基)哌嗪溶液中添加硫酸构成N-(2-羟乙基)哌嗪/H 2S O 4脱硫体系后,脱硫率未受影响、SO2吸收量变小、首次解吸率显著提高,具有更好的循环使用性能。     

危化品企业安全生产标准化与其他管理体系的对比研究

分析了安全生产标准化与其他管理体系的关系,并结合当前推进安全生产标准化工作的具体要求,阐述了安全生产标准化的作用。     

PH3液相催化氧化净化研究

以Mn2 和Pd2 为催化剂的吸收液对含低浓度PH3的混合气进行了液相催化氧化净化研究.考察了催化剂配比、混合气中O2浓度、PH3初始浓度、反应温度、气体流量和吸收液pH与PH3净化效率的关系.结果表明,催化剂中Pd2 与Mn2 的质量比为1:4时可获得较佳的净化效果;随着混合气中O2浓度的增加,吸收液对PH3的净化效率有所提高;在20～75℃内,低温对PH3净化有利,较适宜的反应温度为20℃;较低的PH3初始浓度和低气体流量均有利于PH3的净化;较高的pH有利于吸收液中催化剂催化效能的发挥.吸收液对PH3的净化效率可达100%,但因吸收液中的金属离子易与催化氧化PH3产生的PO3-4形成沉淀,使金属离子脱离液相催化氧化系统,吸收液失效较快.