发酵类抗生素废水处理工艺及运行效果

介绍了内蒙古某抗生素废水处理厂的处理工艺流程、处理单元类型及其详细设计参数,通过对该污水处理厂半年内运行效果的调研,分析评价该污水处理系统的处理效果及出水指标;该水厂工艺流程对COD、TOC、氨氮、总氮、总磷、BOD和急性毒性的平均去除率分别为96.52%、95.83%、50.24%、55.20%、62.05%、98.52%和99.14%,COD、氨氮、总氮、总磷出水水质分别为477、438、556.7和7.69 mg/L,达到排放到城区下水道要求,园区内所有废水汇集到园区污水处理厂进行集中深度处理达标后排放水体。通过对该水厂工艺的介绍和水质分析,为我国抗生素生产企业面临的废水处理工艺类型选择及工程改造升级提供一定参考。     

MFC-MBR耦合系统运行效果及产电性能

为了解决膜生物反应器(MBR)运行成本高、膜污染的问题,本研究建立了一个微生物燃料电池(MFC)-MBR耦合系统,通过MFC回收污水中的能量,同时控制膜污染。研究结果表明,耦合系统对COD和NH3-N的去除率分别为(94.6±3.0)%和(90.9±6.9)%,出水水质稳定。由于MFC的耦合作用,使MBR的运行周期由18 d延长至36 d,膜污染得到了明显的减缓。耦合系统中MFC产电性能稳定,电流密度稳定在5.7 A/m3,最大功率密度达到了928.0 mW/m3,循环伏安法(CV)表明,阴极附着的微生物具有良好的电化学催化作用。MFC-MBR耦合系统将污水中的化学能转化为电能从而实现了膜污染的减缓及能量的回收,显示出巨大的发展前景。     

Speciation distribution and mass balance of copper and zinc in urban rain, sediments, and road runoff

Heavy metal pollution in road runoff had caused widespread concern since the last century. However, there are little references on metal speciation in multiple environmental media (e.g., rain, road sediments, and road runoff). Our research targeted the investigation of metal speciation in rain, road sediments, and runoff; the analysis of speciation variation and mass balance of metals among rain, road sediments, and runoff; the selection of main factors by principal component analysis (PCA); and the establishment of equation to evaluate the impact of rain and road sediments to metals in road runoff. Sequential extraction procedure contains five steps for the chemical fractionation of metals. Flame atomic absorption spectrometry (Shimadzu, AA-6800) was used to determine metal speciation concentration, as well as the total and dissolved fractions. The dissolved fractions for both Cu and Zn were dominant in rain. The speciation distribution of Zn was different from that of Cu in road sediments, while speciation distribution of Zn is similar to that of Cu in runoff. The bound to carbonates for both Cu and Zn in road sediments were prone to be dissolved by rain. The levels of Cu and Zn in runoff were not obviously influenced by rain, but significantly influenced by road sediments. The masses for both Cu and Zn among rain, road sediments, and road runoff approximately meet the mass balance equation for all rainfall patterns. Five principal factors were selected for metal regression equation based on PCA, including rainfall, average rainfall intensity, antecedent dry periods, total suspended particles, and temperature. The established regression equations could be used to predict the effect of road runoff on receiving environments.     

不同粒径零价铁（ZVI）对污水污泥H_2S和CH_4释放速率的影响

考察了不同粒径零价铁（ZVI）,包括200目普通铁粉（200m-ZVI）、800目超细铁粉（800m-ZVI）和纳米铁粉（nZVI,粒径=20 nm）,对污水污泥的硫化氢和甲烷释放速率的影响。研究发现：（1）在22 d内,添加0.1%的200m-ZVI使污泥的硫化氢释放速率提高48.0%,而添加0.1%的800-ZVI和nZVI,则使污泥的硫化氢释放速率分别降低33.1%和77.1%;（2）不同粒径ZVI均可以提高污泥沼气中的甲烷浓度,且依次为nZVI〉800m-ZVI〉200m-ZVI;（3）在23 d内,添加0.1%的200m-ZVI和nZVI使污泥的甲烷累计产生量分别提高了15.5%和40.6%,而添加0.1%800m-ZVI则使甲烷产生量降低了12.5%。nZVI可以有效控制污泥的硫化氢释放,并显著提升污泥在厌氧发酵过程的产甲烷速率。     

水解酸化-A2O污泥减量工艺的运行性能研究

生物处理单元采用水解酸化、多级串联接触曝气、连续流的除磷脱氮A2／O工艺,并辅以外排厌氧富磷污水侧流除磷,开发了一个新型的具有强化除磷脱氮功能的污泥减量HA—A／A—MCO工艺。用该工艺处理校园生活污水发现,在SRT60d、进水COD316～407mg／L、NH4＋-N30～40mg／L、TN35～53mg／L、TP8—12mg／L的条件下,出水COD≤18mg／L、NH4＋-N≤2．1mg／L、TN≤10．3mg／L、TP≤0．44mg／L。研究还发现,水解酸化池处理产生的VFA能有效促进生物除磷脱氮,导致厌氧释磷量达57mg／L,进入化学除磷池的侧流液量仅相当于进水量的13％;系统最主要的脱氮形式是SND和缺氧反硝化,SND脱氮占脱氮总量的50％,缺氧反硝化占26％;HA-A／A—MCO系统有效实现了生物相分离,并利用生物捕食作用获得较低的污泥产率,0．1gMLSS／gCOD。     

牛粪堆肥升温菌剂的筛选及其作用机制

以糖、淀粉、蛋白质、纤维素培养基及菌株增殖倍数、菌株性能等为筛选方法,从牛粪低温堆肥中筛选不同原料重要功能菌并组成功能菌剂;以不同类别原料菌及单菌株发酵实验对升温机制进行研究。结果表明,芽孢杆菌、假单胞菌、纤维单胞菌及小孢霉菌等为重要功能菌;菌剂起温快,升温效果好,48 h堆体即由低温进入中温,5 d达到高温,腐熟时间可缩短至约17~18 d;糖功能菌升温效果最为显著,淀粉及蛋白质功能菌次之,纤维素功能菌升温能力较弱;菌株利用各种原料能力越强,增殖速度越快,对升温作用越大。各菌株充分利用基质各成分,紧密协同和促进,是低温堆体发酵升温的主要作用机制。     

Fenton氧化法深度处理抗生素废水二级出水

采用Fenton氧化法对青霉素和土霉素混合废水二级处理出水进行深度处理,通过正交和单因素实验研究了废水初始反应pH值、H2O2投加量、Fe2+/H2O2摩尔比及反应时间等因素对废水处理效果的影响。实验结果表明,Fenton氧化法处理的最佳反应条件为:初始pH值4、H2O2(30%)投加量50 mL/L、Fe2+/H2O2摩尔比1/20和反应时间60 min,处理后出水COD小于120 mg/L,COD去除率在75%以上,急性毒性(HgCl2毒性当量)小于0.07 mg/L,满足《发酵类制药工业水污染物排放标准》(GB21903-2008)表2标准要求。     

可旋转径向式微粒捕集器消声特性影响因素灰色关联分析

为降低可旋转径向式微粒捕集器中的排气噪声,采用有限元法建立可旋转径向式微粒捕集器声学特性模型,分析得到了其消声特性和传递损失曲线,并采用灰色关联分析方法研究可旋转径向式微粒捕集器结构参数对消声特性的影响程度。结果表明,可旋转径向式微粒捕集器具有降噪能力,且对高频噪声消声效果明显好于低频噪声,平均消声量为20 dB左右;直径比和扩张管锥角是影响可旋转径向式微粒捕集器消声特性的2个主要因素,适当选用小的直径比和扩张管锥角,有利于提高可旋转径向式微粒捕集器的消声性能。     

Determination of o-phthalic acid in snow and its photochemical degradation by capillary gas chromatography coupled with flame ionization and mass spectrometric detection

Phthalic acid and its photochemical degradation has been determined in snow and rainwater samples collected during winters (2003-2010) in the Southeast of Massachusetts using capillary gas chromatography (GC) with flame ionization and mass spectrometric detection. Water samples were dried using a rotary evaporator and derivatized with a 14% BF₃/methanol reagent before GC analysis. The developed method proved simple and accurate. Phthalic acid was found in snow samples collected in a concentration range of 7.22-76.5 nM. The photodegradation of phthalate was carried out under 300 nm UV light. The direct photodecomposition of the acid is slow (5% h⁻¹). However, the addition of dissolved Fe(III) species at 2.0 μM accelerated the light-induced degradation of phthalic acid by 3.5 times in the atmospheric water samples. Photodegradation rates of phthalic acid increases with decreasing pH value of water samples in the range of pH 2.8-4.5.     

日本污水脱氮除磷深度处理工艺分析

为提高进入琵琶湖水体水质和有效恢复并保持琵琶湖流域水生态环境,日本滋贺县10家下水道污水处理厂全部采用脱氮除磷深度处理工艺。湖南中部净化中心目前规模为26.85万t/d,采用缺氧-好氧循环硝化/反硝化(AO)、厌氧-缺氧-好氧(AAO)和多段进水多级缺氧-好氧硝化/反硝化(SMAO)3种深度处理工艺。AAO工艺是国内城镇污水处理厂广泛采用的二级生化工艺,AO、SMAO工艺在国内还没有应用实例。AO、AAO工艺采用内循环硝化/反硝化反应脱氮,SMAO工艺采用无内循环的多段进水多级硝化/反硝化反应脱氮。AO、SMAO工艺采用化学方式除磷,PAC添加浓度约50mg/L。AAO工艺采用化学和生物组合方式除磷,PAC添加浓度降低到约30 mg/L。AO、AAO工艺出水BOD、CODMn、SS、TN和TP均值分别约为0.9 mg/L、5.2 mg/L、1 mg/L、6.5 mg/L和0.06 mg/L,相应的去除率约为99.5%、94.2%、99.5%、78.0%和98.1%。SMAO工艺出水TN约为2.5 mg/L,TN去除率提高到91.6%,其他指标和AO、AAO工艺基本相同。