Study of Hg and SO3 behavior in flue gas of oxy-fuel combustion system

Oxy-fuel combustion systems have been under development to reduce CO₂ emissions from coal-fired power plants. In oxy-fuel combustion system, Hg in the flue gas causes corrosion in CO₂ purification and compression units. Also, SO₃ in the flue gas corrodes the equipment and ducts of oxy-fuel combustion system. Therefore, Hg and SO₃ need to be removed.Babcock-Hitachi conducted tests using a 1.5 MWth Combustion & Air Quality Control System (AQCS) test facility which consists of oxygen supply unit, furnace, Selective Catalytic Reduction (SCR) catalyst, Clean Energy Recuperator (CER), Dry Electrostatic Precipitator (DESP), flue gas recirculation system, Wet Flue Gas Desulfurization (WFGD), and CO₂ Compression and Purification Unit (CPU). In both cases of air and oxy-fuel combustion, the Hg removal across the DESP could be improved, and SO₃ concentration at the DESP outlet could be reduced to less than 1 ppm by installing a CER upstream of the DESP and reducing the gas temperature at the DESP inlet. Hg was not dissolved in the drain recovered from CO₂ compressor, and may be adsorbed at an inner part of CO₂ compressor. This indicated that Hg needs to be removed at a location upstream of the CO₂ compressor to prevent corrosion of the compressor.     

Natural purification effects in the river in consideration with domestic wastewater pollutant discharge reduction effects

The first social experiment program in Japan to reduce domestic wastewater pollutant discharge by “soft interventions” in households has been conducted in the Yamato-gawa River drainage area since 2005. The Yamato-gawa River has been listed as one of the worst water quality rivers in Japan because of the larger annual average BOD. “Hard interventions” including deployment of wastewater treatment facilities and artificial installation of natural purification facilities in the river has been conducted in these years to improve river water quality. At the first Yamato-gawa River social experiment program (YR-SEP) in March 2005, BOD at the monitoring point near the river mouth decreased about 6% during the Program. Natural purification e ect along the river was evaluated in this article with one-dimensional water quality model for the six river sections. Larger biological oxygen consumption rate, kb, was estimated in the sections with artificially installed natural purification facilities. The e ect of “soft interventions” in households in the YR-SEP was estimated as 25% BOD decrease in the nearest monitoring point to the river mouth, when all the households participate in the Program and BOD discharge reduction rate with “soft interventions” in households was 40%.     

Levels and regional trends of persistent organochlorines and polybrominated diphenyl ethers in Asian breast milk demonstrate POPs signatures unique to individual countries

Human breast milk samples collected in 2007–2008 from four countries, Vietnam (Hanoi), China (Beijing), Korea (Seoul) and Japan (Sendai, Kyoto and Takayama), were analyzed for persistent organic pollutants (POPs) such as dichlorodiphenyltrichloroethane and its metabolites (DDTs), chlordane-related compounds (CHLs), hexachlorocyclohexanes (HCHs), hexachlorobenzene (HCB), polychlorinated biphenyls (PCBs) and polybrominated diphenyl ethers (PBDEs). Comparing with previous surveys, the present study indicates that the DDTs in breast milk from China and Vietnam had gradually decreased during the last decade, but were still 5–10 times higher than those in other nations. The ratios of p,p′-DDE/p,p′-DDT and o,p′-DDT/p,p′-DDT were higher in Beijing than in the other countries, suggesting that there is less fresh intake of commercial DDT products and a possible exposure to dicofol in China. CHL and PCB levels were relatively higher in mothers from Japan, whereas β-HCH and HCB were more common in Chinese women. In Japan, it is suspected that mothers in the urban/coastal area (Sendai) were more continuously exposed to organochlorine pesticides (OCPs) than mothers in the rural/inland area (Takayama). In addition, OCP levels in primiparae were significantly higher than those in multiparae from Japan and Korea. These indicate that both parity and regional factors are major determinants of the levels of OCPs and PCBs in human milk. On the other hand, higher concentrations of PBDEs were observed in mothers' milk from Korea. The congener was dominated by BDE-47 (43–54%), followed by BDE-153 (23–33%) in all regions except for Beijing where BDE-28 (23%) was relatively abundant. In Japanese breast milk, regional and parity-dependent distributions were not observed for PBDEs. Among PBDE congeners, age-dependency was observed for BDE-153, which was negatively correlated (p < 0.05) to the age of mothers in Kyoto (17 participants were housewives), while it increased with age in Sendai (10 participants were clerks). No such correlation was seen for BDE-47, indicating that BDE-47 was ingested and assimilated via different kinetics or routes from BDE-153 in Japan.     

Carbonization of johkasou sludge using batch-type equipment

The carbonization of dehydrated johkasou sludge was examined using batch-type equipment. Based on the temperature changes in the carbonization room and the gas combustion room, the carbonization process was divided into three phases: phase I, drying the sludge; phase II, thermal decomposition of the dried sludge; phase III, after phase II. The times required for phases I and II were strongly correlated with the amounts of water and solid matter, respectively, in dehydrated sludge. The reduction rate of the sludge on completion of phase I was about 90% on average, and the decomposition rate of solid matter increased with time during phase II or phase II plus phase III until it reached about 50%. TOC concentration of the eluate from the carbonized sludge was used as an index to evaluate the progress of the carbonization process, and the highest temperature in the carbonization room was recognized as an important operational factor. The specific surface area and pore volume of carbonized sludge were smaller than those of charcoals and activated carbons by 1–3 orders of magnitude and 1–2 orders of magnitude, respectively. No elution of heavy metals was observed from any of the carbonized sludges examined. The reduced amount of carbon in dehydrated johkasou sludge was estimated to be about 25% of the decomposed organic matter.     

Ultra-High Efficiency Photovoltaic Cells for Large Scale Solar Power Generation

The primary targets of our project are to drastically improve the photovoltaic conversion efficiency and to develop new energy storage and delivery technologies. Our approach to obtain an efficiency over 40% starts from the improvement of III–V multi-junction solar cells by introducing a novel material for each cell realizing an ideal combination of bandgaps and lattice-matching. Further improvement incorporates quantum structures such as stacked quantum wells and quantum dots, which allow higher degree of freedom in the design of the bandgap and the lattice strain. Highly controlled arrangement of either quantum dots or quantum wells permits the coupling of the wavefunctions, and thus forms intermediate bands in the bandgap of a host material, which allows multiple photon absorption theoretically leading to a conversion efficiency exceeding 50%. In addition to such improvements, microfabrication technology for the integrated high-efficiency cells and the development of novel material systems that realizes high efficiency and low cost at the same time are investigated.     

The origin of extensive colour polymorphism in Plateumaris sericea (Chrysomelidae,Coleoptera)

Evidence is presented to demonstrate that colour polymorphism in a beetle arises from structural colours produced by a five-layered reflector in the elytron. The colour of leaf beetles, Plateumaris sericea, ranges across the visible spectrum from blackish-blue to red. The elytra have two distinct layers: epicuticle and exocuticle. Morphological observations reveal that the multilayer structure within the exocuticle differs little among the different colour morphs but the layers within the epicuticle have characteristic thicknesses corresponding to the observed colour. The reflectors, consisting of five layers within the epicuticle, are responsible for all the different colours observed in P. sericea, as shown by theoretical analyses for a multilayer stack, and by showing that removal of the elytral surface, including epicuticle, results in the disappearance of the iridescent colour.     

Visual determination of nitrite and nitrate in waters by color band formation method

A spot test for aqueous nitrate and nitrite for controlling nitrogen removal performance in small-scale wastewater treatment facilities is proposed. In this method, NO(2)(-) ion in water samples was allowed to react with sulfanilic acid and 1-naphthol to form an anionic azo dye. The resulting colored solution was introduced onto a mini column (similar to a gas detecting tube) packed with PVC particles coated with benzyl cetyl dimethyl ammonium chloride (BCDMA) and biphenyl. The NO(2)(-)-N concentration was determined visually by measuring the color band length (CBL) in the column. The CBL correlates linearly with nitrite concentration in the 4-20 mg-N l(-1) range. The concentration of nitrite+nitrate was determined after reduction to nitrite with zinc. The concentration of NO(3)(-)-N species was calculated by difference. This method was used to visually determine the concentrations of NO(2)(-)-N and (NO(2)(-)+NO(3)(-))-N in domestic wastewater samples with maximum suspended solid (SS) and chemical oxygen demand (COD) concentrations of 114 mg l(-1) and 73.9 mg l(-1), respectively.     

Effects of amine, amine salt and amide on the behaviour of carbon dioxide absorption into calcium hydroxide suspension to precipitate calcium carbonate

The amount of carbon dioxide （CO2） absorption and calcium ion （Ca^2＋） concentration besides the pH of aqueous solution were observed during the COz absorption to precipitate calcium carbonate （CaCO3） from calcium hydroxide （Ca（OH）2）. A reaction rate-limiting effect of an amount of CO2 absorption without any organic additives in the early stage of the precipitation was observed, which was attributed to an interruption effect of bicarbonate ion （HCO3） on the precipitation of CaCO3. The improvement for the reaction rate was achieved not only by amine additives but also by neutral additives such as ε-caprolactam or amine salt. When the hexamethylene diamine was dissolved in the solution, successive change of crystal forms of CaCO3 aragonite to calcite in aqueous suspensions, confirmed by Ca^2＋ concentration change and X-ray diffraction, was concluded that a local environment around the amine group in aqueous solution and an interaction of the diamine with precipitated CaCO3 particles were important factors for these reactions.     

CWO技术处理高浓度焦化废水的工业应用研究

采用 2 0 0 L/ d CWO小型工业试验装置对高浓度焦化废水进行处理试验研究 ,结果表明 CWO技术装置对处理高浓度焦化废水 (CODCr,10 0 0 0～ 130 0 0 mg/ L、NH3- N12 0 0～ 2 10 0 mg/ L)具有良好的技术可行性 ,废水经处理后 (催化反应时间 30～ 4 5 min) ,废水中 CODCr、NH3- N的去除率即可达到 99%以上 ,处理水中的 CODCr、NH3- N浓度均可达到国家排放标准 (CODCr<10 0 mg/ L、NH3- N<15 mg/ L ) ,且废水的脱色、除臭效果明显。对于不同浓度焦化废水的处理 ,CWO技术及装置表现出了很好的适应性。国产化 2 0 m3/ d CWO工业装置对焦化废水的连续处理运行表明 ,CWO技术在国内已达到工业化应用水平 ,并具有较好的经济性。     

Clonal structure affects the assembling behavior in the Japanese queenless ant <Emphasis Type="Italic">Pristomyrmex punctatus</Emphasis>

The queenless ant Pristomyrmex punctatus (Hymenoptera: Myrmicinae) has a unique society that differs from those of other typical ants. This species does not have a queen, and the workers lay eggs and produce their clones parthenogenetically. However, a colony of these ants does not always comprise members derived from a single clonal line. In this study, we examined whether P. punctatus changes its “assembling behavior” based on colony genetic structure. We prepared two subcolonies—a larger one comprising 200 individuals and a smaller one comprising 100 individuals; these subcolonies were established from a single stock colony. We investigated whether these subcolonies assemble into a single nest. The genetically monomorphic subcolonies (single clonal line) always fused into a single nest; however, the genetically polymorphic subcolonies (multiple clonal lines) did not tend to form a single colony. The present study is the first to demonstrate that the colony genetic structure significantly affects social viscosity in social insects.