An experimental investigation into micro ball end-milling of silicon

Silicon is a representative operational material for semiconductor and micro-electronics. In certain MEMS applications, it is required to fabricate three dimensional channels and complex pattern on silicon substrate. Such features are typically fabricated by photolithography and chemical etching. These processes have low productivity and have certain other limitations. Therefore, a viable switch-over from non-traditional fabrication processes to traditional machining is highly desired for improved productivity in high-mix low-volume production. However, machining of silicon by traditional process is extremely difficult due to its high brittleness. Even very small forces produced during machining can cause brittle fracture on silicon surface resulting in deteriorated surface quality. The fundamental principle in machining of a brittle material such as silicon is to achieve material removal through plastic deformation rather than crack propagation. This paper presents the experimental results of ductile-mode machining of silicon by micro ball end-milling. The workpiece surface was inclined to the rotational axes of the cutter to improve the surface finish. It was established experimentally that 15-μm deep, fracture-free slots can be machined on silicon wafer by micro ball end-milling if the feed rate is below a certain threshold. The influence of several machining parameters on the roughness of machined-surface was also investigated. Cubic boron nitride (CBN) is presented as much economical alternative tool-material to single-crystal diamond for machining silicon in ductile-mode.     

Fragmented forest in tropical landscape--the case of the state of Selangor,Malaysia

This paper presents the pattern and changes of fragmented forest in relation with changes of total forest cover in the state of Selangor in three decades.In this study,inventoried forest cover maps of Selangor in 1971/1972,1981/1982 and 1991/1992 produced by the Forestry Department of Peninsular Malaysia were digitized to examine the changes in area and number of fragmented forest.Results showed that in 1971/1972,16 fragmented forests were identified in Selangor.All fragmented forests were identified as diptercoarp forest.A decade later the number of fragmented forests increased by approximately 44%(23).Of the 23 fragmented forests,two were peat swamp forests whereas the remaining were dipterocarp forests.In 1991/1992 the number of fragmented forests(12)was reduced by 47.8%.Two of the fragmented forests were Fragmentation of both dipterocrp and peat swamp forests occurred profoundly during the period between 1971/1972and 1981/1982,which consequently increased the number of fragmented forests compared with before the period of 1971/1972 where fragmentation happened only at dipterocarp forests.However,many fragmented forests vanished between the 1981/1982 and 1991/1992 periods.     

Studies on the toxicity, metabolism, and anticholinesterase properties of acephate and methamidophos

The toxicity of acephate to four species of aquatic insects, as well as the metabolism and cholinesterase-inhibiting properties of the chemical in the rat were studied. The results indicated that mayfly larvae were very sensitive to the toxic effects of acephate, whereas larvae of the stonefly, damselfly and mosquito were much less sensitive. In the rat, orally-administered acephate was rapidly absorbed from the intestines and severely inhibited the cholinesterases in the blood and brain. The enzymes began to recover after 24 hours, while the chemical was completely eliminated within three days. The amount of methamidophos observed in the liver was extremely low. The cholinesterase-inhibiting properties of acephate and methamidophos were compared in vitro to that of paraoxon, a known strong anticholinesterase. Enzymes from four vertebrates were used. In all cases, except one, acephate was found to be six orders of magnitude weaker than paraoxon, whereas methamidophos was three orders weaker. Trout brain cholinesterase was the exception; it was as sensitive to paraoxon as it was to methamidophos. Finally, four cholinesterases were inhibited with methamidophos, and their ability to reactivate spontaneously or to recover by induction with pyridine aldoxime methiodide (PAM) in vitro were determined. The results suggested that methamidophos-inhibited cholinesterases did not reactivate spontaneously; instead the enzymes remained inhibited either in a phosphorylated or an aged state. The significance of these results are discussed in relation to the use of acephate for forest insect pests.     

Random binary matrices in biogeographical ecology—Instituting a good neighbor policy

Binary matrices originating from presence/absence data on species (rows) distributed over sites (columns) have been a subject of much controversy in ecological biogeography. Under the null hypothesis that every matrix is equally likely, the distributions of some test statistics measuring co-occurrences between species are sought, conditional on the row and column totals being fixed at the values observed for some particular matrix. Many ad hoc methods have been proposed in the literature, but at least some of them do not provide uniform random samples of matrices. In particular, some swap algorithms have not accounted for the number of neighbors each matrix has in the universe of matrices with a set of fixed row and column sums. We provide a Monte-Carlo method using random walks on graphs that gives correct estimates for the distributions of statistics. We exemplify its use with one statistic.     

Ca and OH release of ceramsites containing anorthite and gehlenite prepared from waste lime mud

Lime mud is a kind of solid waste in the papermaking industry, which has been a source of serious environmental pollution. Ceramsites containing anorthite and gehlenite were prepared from lime mud and fly ash through the solid state reaction method at 1050°C. The objective of this study was to explore the efficiency of Ca^2 + and OH⁻ release and assess the phosphorus and copper ion removal performance of the ceramsites via batch experiments, X-ray diffraction (XRD) and scanning electron microscopy (SEM). The results show that Ca^2 + and OH⁻ were released from the ceramsites due to the dissolution of anorthite, gehlenite and available lime. It is also concluded that gehlenite had stronger capacity for Ca^2 + and OH⁻ release compared with anorthite. The Ca^2 + release could be fit well by the Avrami kinetic model. Increases of porosity, dosage and temperature were associated with increases in the concentrations of Ca^2 + and OH⁻ released. Under different conditions, the ceramsites could maintain aqueous solutions in alkaline conditions (pH = 9.3–10.9) and the release of Ca^2 + was not affected. The removal rates of phosphorus and copper ions were as high as 96.88% and 96.81%, respectively. The final pH values of both phosphorus and copper ions solutions changed slightly. The reuse of lime mud in the form of ceramsites is an effective strategy.     

Pretreatment of cyanided tailings by catalytic ozonation with Mn2+/O3

The increasing amount of cyanided tailings produced as a by-product has gained significant attention in recent years because of the rapid development of the gold industry and extensive exploitation of gold mineral resources. The effective use of these secondary resources is becoming an important and urgent problem for all environmental protection staff. Manganese-catalyzed ozonation for the pre-oxidation of cyanided tailings was studied and the effects of Mn²⁺ dosage, initial sulfuric acid concentration, ozone volume flow, temperature and agitation speed on pretreatment were examined. The optimum reaction conditions were observed to be: ore pulp density 2.5%, agitation speed 700 r/min, temperature 60 ℃, Mn²⁺ dosage 40 g/L, ozone volume flow 80 L/hr, initial sulfuric acid concentration 1 mol/L, and reaction time 6 hr. Under these conditions, the leaching rate of Fe and weight loss could reach 94.85% and 48.89% respectively. The leaching process of cyanided tailings by Mn²⁺/O³ was analyzed, and it was found that the leaching of pyrite depends on synergetic oxidation by high-valent manganese and O³, in which the former played an important part.     

Planetary Stewardship in an Urbanizing World: Beyond City Limits

Cities are rapidly increasing in importance as a major factor shaping the Earth system, and therefore, must take corresponding responsibility. With currently over half the world’s population, cities are supported by resources originating from primarily rural regions often located around the world far distant from the urban loci of use. The sustainability of a city can no longer be considered in isolation from the sustainability of human and natural resources it uses from proximal or distant regions, or the combined resource use and impacts of cities globally. The world’s multiple and complex environmental and social challenges require interconnected solutions and coordinated governance approaches to planetary stewardship. We suggest that a key component of planetary stewardship is a global system of cities that develop sustainable processes and policies in concert with its non-urban areas. The potential for cities to cooperate as a system and with rural connectivity could increase their capacity to effect change and foster stewardship at the planetary scale and also increase their resource security.     

Concentration of some heavy metals in organically grown primitive, old and modern wheat genotypes: implications for human health

The concentration of six HMs (Cd, Cr, Co, Pb, Hg and Ni) was analysed in 321 organically grown winter and spring wheat genotypes from six genotype groups, i.e. selections, old landraces, primitive wheat, spelt, old cultivars and cultivars. Also the potential risk of individual toxic HM to human health was estimated by using the Hazard Quotient (HQ). Significantly the lowest grain concentration of Cd was found in primitive wheat as compared to all other investigated genotype groups. Intake of HM by consumption of whole wheat grain was not found to pose a health risk to human for any of the investigated genotype groups. The bio-concentration factor of Cd for the different genotype groups indicated a lower ability to accumulate Cd for primitive wheat as compared to other genotype groups. The primitive wheat was found the most promising and might be of interest in future wheat breeding programs to develop wheat genotypes with low HMs concentration in the grain.     

Conceptualizing and incorporating social sustainability in the business world

One of the most important challenges faced by business managers today is the integration of sustainability into their core functions. The contemporary enterprise is forced to leap forward from the mere adoption of green practices toward rethinking, redesigning, and redeveloping business practices in a more sustainable way. Most of the initiatives in this attempt have so far emphasized primarily the economic and environmental aspects of sustainable development and overlooked the social dimension of sustainability. As more organizations commit to sustainability, there is an increasing concern to incorporate social sustainability throughout their business operations. To conceptualize and integrate the notion, some organizations use preexisting indicators to demonstrate the value and impact of sustainability, while others look beyond the measurement of impacts by constructing their own system of indicators. This paper draws on a comprehensive literature review to determine a broadly acceptable framework of social sustainability indicators to be conceptualized and integrated into the business world. Findings suggest that economic and environmental sustainability can be driven together with core social factors including fairness and equality, poverty, health, education, delinquencies, demography, culture, and employee engagement within an organization. These results offer insight into the emerging phenomenon of formulating sustainable business strategies for organizations based on social indicators to attain the ultimate sustainable outcomes. This study is among the first to identify social sustainability indicators from societal and corporate perspectives. It offers a comprehensive social sustainability framework that may be adopted by organizations in the business world.     

Habitat preference and population estimates of Indian pangolin (Manis crassicaudata) in district Chakwal of Potohar Plateau,Pakistan

Indian pangolin (Manis crassicaudata) is a fossorial, “Near threatened” mammalian species occurring in Pakistan and facing a risk of endangerment in its wild habitat. Being nocturnal, ecological data of the species is lacking in the country and in south Asia as well. The current study investigated some ecological parameters of the species like, distribution, habitat analysis, population and food habits in district Chakwal of Potohar Plateau. Illegal trapping and killing by professional nomads for its scales is the main threat to the species in the study area.