加盐蒸馏回收盐酸和混凝剂制备技术资源化利用盐酸酸洗废液

为了实现钢材酸洗废液的资源化,能够同时回收盐酸和铁盐,提出了加盐蒸馏回收盐酸与蒸馏母液制备聚铁混凝剂两段组合工艺相结合的技术。实验对质量浓度为9.28%的实际盐酸废液进行了研究,考察了添加盐的种类、盐的投加量和蒸馏量等因素对再生盐酸回收效果和聚铁混凝剂溶液混凝效果的影响。研究表明,氯盐可以明显改变氯化氢、水的相对挥发度,当CaCl2投加量为1 mol/L,体积蒸馏量在30%时,为此工艺的最佳条件。在此工艺条件下,再生盐酸质量浓度约22.3%;蒸馏母液制备得到的聚铁混凝剂溶液应用实验表明,对印染废水脱色效果良好。此工艺不仅实现了酸洗废液中残酸和铁离子的资源化利用,而且达到酸洗废液的零排放。     

Isolation and characterization of dissolved organic matter fractions from antialgal products of Microcystis aeruginosa

An antialgal bacterium, Streptomyces sp. HJC-D1, was applied for the biodegradation of cyanobacterium Microcystis aeruginosa, and the isolation and characterization of dissolved organic matter (DOM) fractions in antialgal products were studied. Results showed the the growth of M. aeruginosa was significantly inhibited by the cell-free filtrate of Streptomyces sp. HJC-D1 with the growth inhibition of 86?±?7 %. The antialgal products were divided using resin adsorbents into the hydrophilic fraction (HPI), hydrophobic acid (HPO-A), transphilic acid (TPI-A), hydrophobic neutral and transphilic neutral, and then the five fractions were analyzed by the 3-D fluorescence spectroscopy, gel permeation chromatography, and Fourier transform infrared spectroscopy. The results indicated that the HPI component was the most abundant DOM fraction in the antialgal products, and its concentration was increased with the increase of cell-free filtrate concentration. The fluorescence peak location and intensity analysis showed that the protein-, fulvic-, and humic-like substances were dominant in the HPI, HPO-A, and TPI-A fractions, and intensities of the relevant fluorescence peaks were stronger in the experimental groups than those of the control groups. It was also found that the number-average molecular weight of DOM fractions ranged from 245 to 1,452 g mol^?1, and thereinto organic acids such as HPO-A and TPI-A exhibited lower molecular weights.     

Isolation and characterization of a newly isolated pyrene-degrading Acinetobacter strain USTB-X

The pryene-degradation bacterium strain USTB-X was newly isolated from the polycyclic aromatic hydrocarbon (PAH)-contaminated soil in Beijing Coking Plant, China. The strain was identified as Acinetobacter with respect to its 16S rDNA and morphological and physiological characteristics. The strain was Gram-negative, non-mobile, non-acid-fast, and non-spore-forming, short rods in young culture and 0.8–1.6 μm in diameter and 1.2–2.5 μm long in the stationary phase of growth. Strain USTB-X could utilize pyrene, naphthalene, fluorene, phenanthrene, benzene, toluene, ethylbenzene, ethanol, methanol, and Tween 80 as sole source of carbon and energy. The strain could produce biosurfactants which enhanced the removal of pyrene and could remove 63 % of pyrene with an initial concentration of 100 mg·L^?1 in 16 days without other substrates. Based on the intermediates analyzed by gas chromatography-mass spectrometry, we also deduced the possible metabolic pathway of strain USTB-X for pyrene biodegradation. Results indicated that the strain USTB-X had high potential to enhance the removal of PAHs in contaminated sites.     

城市污水二级出水中溶解性有机物特性分析

分别采用凝胶色谱、亲疏水性组分分离、荧光色谱等方法,研究了城市污水处理厂二级出水中溶解性有机物的分子量分布、亲疏水组分含量以及荧光光谱特性。结果表明,二级出水中疏水性组分较亲水性组分多,疏水性组分约占总有机物的64.3%,而亲水性组分占35.7%左右;二级出水及其不同亲/疏水组分中溶解性有机物分子量分布基本集中在4.5 kDa以下,其中弱疏水性组分和亲水性组分中主要为分子量小于1.5 kDa的有机物;二级出水溶解性有机物中含有腐殖酸类、富里酸类以及蛋白质类物质,其中含量以腐殖酸类为主。     

曝气对潜流人工湿地污染物沿程降解规律的影响

通过构建曝气及未曝气潜流人工湿地小试实验系统,研究曝气对人工湿地床体中污染物沿程变化规律的影响。实验结果表明,曝气对污染物沿程降解规律的影响与污染物种类有关,在净化COD和氨氮时,曝气人工湿地污染物主要以水平推流式降解为主,未曝气系统床体中则出现分层现象,深度为40 cm以上的床体区域中污染物以水平推流式降解为主,40 cm以下区域则以垂直梯度降解方式为主。对于磷来说,两对比系统均以水平推流降解方式为主,但不同深度上的降解速率有所差异,曝气系统30~50 cm的床体中间层降解速率较快,而未曝气系统50 cm以下的床体底层降解速率较快。将对比系统总体净化效果进一步比较发现,对于COD的去除来说,温度的影响大些,而对于氨氮和TP的去除来说,曝气的影响则更为显著。     

固体缓释碳源处理低碳氮比污水的脱氮及机理

通过投加PHB(聚-β-羟丁酸)和改性天然缓释碳源,在填料高度0.6 m处的实验表明,投加PHB后反应体系保持着对NH3-N较好的去除效果,去除率为13.04%~94.56%(均值67.45%)。而投加改性天然缓释碳源后,出水NH3-N浓度高于原水;待改性天然缓释碳源完全消耗后,出水NH3-N浓度低于原水。投加改性天然缓释碳源比投加PHB对去除NO-3-N和TN的效果更好,在投加改性天然缓释碳源33 d左右内,系统保持着对NO-3-N和TN很高的去除效果,去除率分别达到17.31%~97.37%(均值77.18%)和33.69%~88.16%(均值74.06%)。在实验参数的基础上,投加改性天然缓释碳源后,系统对高效脱氮的时间可维持33 d左右,反应体系对TN的去除主要依赖于反硝化细菌的异化作用。     

NiOγ／-Al2O3反应吸附苯并噻吩

以等体积浸渍法制备了负载型NiOγ／-Al2O3吸附剂,在固定床反应装置上对含苯并噻吩的模型化合物进行反应吸附脱硫实验,考察了NiO负载量、模型化合物硫含量及活性组分的形态对吸附剂脱硫性能的影响,并用XRD、SEM—EDS分析、XPS分析对载体和吸附剂进行了表征。实验结果表明：NiOγ／-Al2O3吸附剂具有较高的穿透硫容,能有效脱除模型化合物中的苯并噻吩;反应过程中生成了NiS;C的沉积以及Ni的硫化物的生成导致了吸附剂的失活。     

纳米聚硅酸铝锌絮凝剂的制备及应用

将制备出的聚硅酸铝锌絮凝剂纳米化,在正交实验和单因素优化的基础上,研究了表面活性剂硬脂酸钠的加入量、超声频率、超声时间及投加量对絮凝剂絮凝效果的影响,并且考察了pH、投加量对印染废水的处理效果的影响。结果表明,超声时间对絮凝效果影响最大,超声频率次之,硬脂酸钠含量影响最小。纳米聚硅酸铝锌絮凝剂的最佳制备条件为：表面活性剂硬脂酸钠加入量为0．1％、超声频率为40Hz、超声时间为60min;考虑处理费用,处理印染废水时pH=6～9、投加量为5mL／250mL时效果较好,浊度去除率可达98．5％,色度去除率可达97．4％。     

电极面积对无质子交换膜微生物燃料电池协同去污能力的影响

以间距是180μm的不锈钢网为电极,构建了单室型无质子交换膜微生物燃料电池(MFC)污水处理系统。分别驯化、培养厌氧消化菌和反硝化菌,厌氧消化菌在阳极附着成膜组成生物阳极氧化去除有机污染物,反硝化菌在阴极附着成膜组成生物阴极反硝化去除含氮污染物,研究了电极面积对污染物协同去除能力的影响。当电极面积为45 mm×100mm和45 mm×50 mm时,两系统的开路电压最大值分别为(182.8±6.2)mV和(161.8±5.4)mV,COD、NH4+-N和NO3--N最大去除率分别为96.5%、99.7%、99.7%和85.4%、92.2%、97.9%;出水中NO2--N的含量分别低于(0.072±0.006)mg/L和(0.084±0.008)mg/L。这表明电极面积大的系统具有较好的有机污染物和含氮污染物协同去除能力。     

滤筒除尘器脉冲清灰动态分析

对常用规格φ325 mm×660 mm滤筒采用普通喷吹孔和诱导喷嘴进行脉冲清灰实验研究,测试滤筒侧壁压力峰值和压力上升速度,并使用高速动态分析仪拍摄清灰时粉尘从滤筒壁面脱落的动态过程。实验证明了滤筒脉冲清灰时,粉尘的脱落是从滤筒上部到下部依次进行,滤筒侧壁第一个压力峰值、最大压力峰值和压力上升速度对清灰效果均有影响,且脉冲气流形成的第一个侧壁压力峰值对滤筒的第一次冲击对清灰来说起着决定性的作用,回流气流形成的侧壁压力峰值作用较弱。而压力上升速度不能完全作为评价清灰效果好坏的指标。实验证明,采用诱导喷嘴可以改善滤筒内部流场,提高清灰效率。