Product Guide/1982

Abstract

An efficient venturi scrubber system making use of heterogeneous nucleation and condensational growth of particles was designed and tested to remove fine particles from the exhaust of a local scrubber where residual SiH₄ gas was abated and lots of fine SiO₂ particles were generated. In front of the venturi scrubber, normal-temperature fine-water mist mixes with high-temperature exhaust gas to cool it to the saturation temperature, allowing submicron particles to grow into micron sizes. The grown particles are then scrubbed efficiently in the venturi scrubber. Test results show that the present venturi scrubber system is effective for removing submicron particles. For SiO₂ particles greater than 0.1 μm, the removal efficiency is greater than 80–90%, depending on particle concentration. The corresponding pressure drop is relatively low. For example, the pressure drop of the venturi scrubber is ～15.4 ± 2.4 cm H₂O when the liquid-to-gas ratio is 1.50 L/m³. A theoretical calculation has been conducted to simulate particle growth process and the removal efficiency of the venturi scrubber. The theoretical results agree with the experimental data reasonably well when SiO₂ particle diameter is greater than 0.1 μm.     

微电解预处理靛蓝牛仔布印染废水

靛蓝牛仔布印染废水组分复杂,浓度高、水量大,属于难处理的工业废水,为了有效降低后续生物处理单元的负荷,采用铁炭微电解工艺对该废水进行预处理;通过正交实验考察pH、反应时间及铁炭比处理效果的影响规律及COD去除反应动力学,并对各因素作了单因素影响实验,确定了最佳工艺条件.结果表明,铁炭微电解法是预处理靛蓝牛仔布印染废水的一种有效方法,在Fe/C为2:1、pH为3的条件下反应90 min,铁炭微电解出水COD的去除率在49.2％,色度去除率达到80％,该印染废水经微电解处理后,BOD5/COD比值可从原来的0.248上升至0.436,可生化性明显提高.此外,微电解预处理靛蓝牛仔布印染废水中COD的去除反应符合二级反应动力学规律.     

油田水反硝化技术抑制硫酸还原菌

利用反硝化技术对江苏油田5个联合站的采出水,进行了添加不同抑制剂的浓度、种类、不同配比和接种DNB菌对SRB、DNB的菌落数量、硫化氢的产生量和氧化还原电位的影响的静态实验。研究结果表明:投加一定浓度的硝酸盐、亚硝酸盐和钼酸盐,对油田采出水SRB的生长都有不同程度的抑制作用,而同等浓度的抑制效果表现为亚硝酸盐>硝酸盐>钼酸盐,同时投加DNB和0.3～0.5 g/L(比例为1∶1)的亚硝酸盐/硝酸盐可较好地抑制油田采出水中的SRB和硫化氢的产生,其中0.5 g/L抑制效果最明显,可抑制硫化氢的产生10 d以上,SRB和硫化氢抑制率分别可达87%和98%。以不同药剂的常压静态腐蚀实验结果表明,抑制剂的腐蚀速率比杀菌剂和缓蚀剂略高,但低于石油天然气行业中标准规定的0.0076 mm/a,也远低于对照样的0.152 mm/a。     

高气速间歇式生物过滤去除高负荷H2S

采用生物过滤法,以鸡粪堆肥和PE混合物为填料,在高气速条件下间歇式处理高负荷H2S废气。空床停留时间为20、15、10、6.7和5 s时,入口浓度3 000 mg/m3下的平均去除率分别为100%、100%、96.5%、89.2%和90.5%。高气速EBRT为5 s时,高入口负荷2 147 g/(m3.h)时的去除负荷为2 023 g/(m3.h),去除率达94%。采用Michaelis-Ment-en模型进行生物降解宏观动力学研究,其中Ks为550 mg/m3,Vm为6.8×104g/(m3.d)。结果表明,在实验温度17～24℃,湿度30%～50%下,生物过滤法间歇式处理高气速高负荷H2S的去除性能好。     

两相分配式生物反应器处理高盐废水中的苯酚

采用新型两相分配式生物反应器(TPPB)和前期研究得到的高效苯酚降解菌对高盐废水中苯酚的降解进行研究,研究中确定煤油为反应系统的最佳有机溶剂,并考察了废水苯酚含量、废水盐度以及搅拌器搅拌速度对苯酚降解的影响。结果表明,反应系统能正常降解苯酚含量为1 000～2 500 mg/L的高盐苯酚废水;反应系统在含盐量为100 g NaCl/L、搅拌速度为50 r/min的运行工况条件下,降解时间缩短为52 h,总酚去除率为20.58 mg/(L.h)。     

高速公路路面沉积物的污染特性

对湖南省长潭西高速公路不同采样点的路面沉积物进行取样分析,并检测了样品的颗粒级配、COD、重金属(Cu、Zn、Pb和Cd)和有机质。结果表明,路面沉积物主要以粒径<0.15 mm的颗粒为主;较小颗粒物中的COD含量高于较大颗粒中的COD含量;粒径在0.15 mm以下的颗粒物所含重金属Cu、Zn、Pb和Cd的浓度普遍高于所选的土壤标准值,降雨一旦形成径流将会产生严重的污染危害;沉积物中的有机质含量对重金属的吸附有一定的影响,有机质含量越高,沉积物中重金属含量相对也高。     

树脂法去除并回收富营养化河涌水中的磷

磷作为一种重要的元素而被广泛应用于农业与工业中,然而磷的过量排放已成为许多封闭半封闭水体富营养化和沿海赤潮频繁发生的原因之一.去除水体中的营养盐特别是磷酸盐,是有效控制水体富营养化的关键.广州市某河涌水含总磷2.6 mg/L,采用并选择DS离子交换树脂对水中磷进行动态吸附和去除,可使水中的磷降至排放标准以内,解决河涌水含磷高的富营养化问题.由DS树脂所吸附的磷,通过淋洗可得到含磷富集液,使磷从水体中完全分离出来并获得回收.DS树脂的再生能力强,经6次吸附-解吸-再生后,树脂对河涌水中磷的去除率仍可达到90％以上.     

铁炭微电解法降解TAIC废水

TAIC（三烯丙基异氰脲酸酯）作为过氧化物交联或自由基反应交联的助交联剂被广泛应用。由于TAIC性质稳定难于生物降解,采用铁炭微电解法处理TAIC生产废水,并考察了铁炭比、进水pH值、反应时间对处理效果的影响,以及TAIC降解机理和反应动力学过程。结果表明,影响微电解工艺的因素主次关系为：pH>Fe/C质量比>反应时间;在最佳条件进水pH值为5,铁炭质量比为2：1,反应时间为135 min时,COD的去除率达到46%以上,TAIC的去除率达到48%以上。TAIC去除机理研究表明,微电解对TAIC废水的作用主要通过·H的还原和铁离子的絮凝作用,其中·H的还原作用是TAIC降解的主要原因。反应动力学分析表明,铁炭微电解法处理TAIC的降解过程基本符合二级反应动力学规律,通过建立模型并拟合出了TAIC降解的二级反应动力学方程。     

臭氧-BAF组合工艺对石化行业废水深度处理的中试研究

采用臭氧-曝气生物滤池（BAF）组合工艺对中石化九江分公司二级生化出水进行深度处理中试实验。探讨了臭氧投加量、进水水质冲击负荷等因素对该组合工艺出水COD、NH₄⁺-N的影响。中试结果表明,在该水质条件下,臭氧最佳投加量为20~25 mg/L;组合工艺处理后出水COD低于40 mg/L,NH₄⁺-N低于5 mg/L,达到中水回用设计标准;该组合工艺能够经受一定冲击负荷。     

Phthalate exposure in pregnant women and their children in central Taiwan

Phthalate exposure was found to be associated with endocrine disruption, respiratory effects, reproductive and developmental toxicity. The intensive use of plastics may be increasing the exposure to phthalates in Taiwanese population, particularly for young children.We studied phthalate metabolites in pregnant women and their newborns in a prospective cohort from a medical center in Central Taiwan. One hundred maternal urine samples and 30 paired cord blood and milk samples were randomly selected from all of participants (430 pregnant women). Eleven phthalate metabolites (MEHP, 5OH-MEHP, 2cx-MEHP, 5cx-MEPP, 5oxo-MEHP, MiBP, MnBP, MBzP, OH-MiNP, oxo-MiNP, and cx-MiNP) representing the exposure to five commonly used phthalates (DEHP, di-isobutyl phthalate (DiBP), DnBP, BBP, DiNP) were measured in urine of pregnant women, cord serum and breast milk after delivery, and in urine of their children. Exposure was estimated with excretion factors and correlation among metabolites of the same parent compound. Thirty and 59 urinary samples from 2 and 5 years-old children were randomly selected from 185 children successfully followed.Total urinary phthalate metabolite concentration (geometric mean, μg L⁻¹) was found to be higher in 2-years-olds (398.6) and 5-years-olds (333.7) than pregnant women (205.2). Metabolites in urine are mainly from DEHP. The proportion of DiNP metabolites was higher in children urine (4.39 and 8.31%, ages 2 and 5) than in adults (0.83%) (p < 0.01). Compared to urinary levels, phthalate metabolite levels are low in cord blood (37.45) and milk (14.90). DEHP metabolite levels in women’s urine and their corresponding cord blood are significantly correlated. Compared to other populations in the world, DEHP derived metabolites in maternal urine were higher, while phthalate metabolite levels in milk and cord blood were similar. The level of phthalate metabolites in milk and cord blood were comparable to those found in other populations. Further studies of health effects related to DEHP and DiNP exposure are necessary for the children.