页岩气压裂高压管汇失效风险分析及防控措施

针对大排量、高压力页岩气压裂施工作业中存在的高压管汇失效风险,分析了某公司近年来的高压管汇失效事故事件,识别出了常见的失效形式及部位,构建了基于计算流体力学的固液两相流射流模型,模拟计算了失效的破坏力和伤害范围。研究结果表明:刺漏是高压管汇最常见失效形式,弯头、三通等应力集中区是刺漏失效的高危部位; 100 MPa工况时刺漏影响范围可达100 m,离刺漏点1 m处,流体流速为260 m/s,打击压力达3.5 GPa,远超防护钢板抗剪切强度。根据风险分析及事故模拟结果,从本质安全、工艺改进、管理、信息化提升4个维度提出了防控措施,为页岩气压裂施工作业安全防控措施的制定提供了参考。     

Instantaneous char reaction of biomass particles in a hot gas flow with fluctuating temperature

Char reaction is an important stage of the combustion processes of biomass particles. It dominates the burnout of biomass particles. The instantaneous char reaction processes of biomass particles in a hot gas with temperature fluctuation are studied. Two types of biomass fuels, i.e. pine and thistle, are chosen for the present investigation. The instantaneous mass variations of biomass particles with initial diameters of 100, 200, and 300 μm are calculated under different conditions. The gas temperature fluctuation leads to faster mass loss for both pine and thistle particles. The char reaction of biomass particles is further enhanced by increase in the fluctuation amplitude of gas temperature.     

Effect of ultraviolet irradiation and chlorination on ampicillin-resistant <Emphasis Type="Italic">Escherichia coli</Emphasis> and its ampicillin resistance gene

Antibiotic resistance is a serious public health risk that may spread via potable and reclaimed water. Effective disinfection is important for inactivation of antibiotic-resistant bacteria and disruption of antibiotic resistance genes. Ampicillin is a widely prescribed antibiotic but its effectiveness is increasingly undermined by resistance. In this study, changes in ampicillin resistance for Escherichia coli (E. coli) CGMCC 1.1595 were analyzed after exposure to different doses of ultraviolet (UV) or chlorine, and damage incurred by the plasmid encoding ampicillin resistance gene bla _TEM-1 was assessed. We reported a greater stability in ampicillinresistant E. coli CGMCC 1.1595 after UV irradiation or chlorination when compared with previously published data for other E. coli strains. UV irradiation and chlorination led to a shift in the mortality frequency distributions of ampicillin-resistant E. coli when subsequently exposed to ampicillin. The ampicillin hemiinhibitory concentration (IC₅₀) without disinfection was 3800 mg·L^–1, and an increment was observed after UV irradiation or chlorination. The IC₅₀ of ampicillin-resistant E. coli was 1.5-fold higher at a UV dose of 40 mJ·cm^–2, and was 1.4-fold higher when exposed to 2.0 mg·L^–1 chlorine. These results indicate that UV irradiation and chlorination can potentially increase the risk of selection for E. coli strains with high ampicillin resistance. There was no evident damage to bla _TEM-1 after 1–10 mg Cl₂·L^–1 chlorination, while a UV dose of 80 mJ·cm^–2 yielded a damage ratio for bla _TEM-1 of approximately 1.2-log. Therefore, high UV doses are required for effective disruption of antibiotic resistance genes in bacteria.     

冶金焦化废水治理新技术工业实践

焦化废水是最难处理的高浓度、难降解的有机工业废水之一。经传统方法处理后的废水,各项指标难以达标。以新兴铸管股份有限公司焦化废水工艺改造为例,用烧结带冷高温废气处理焦化废水,降低水中各种污染物的浓度,同时对烧结废气中二氧化硫、氮氧化物、粉尘等也进行了去除,实现“以废治废”。     

我国水泥行业大气污染物排放特征

水泥行业是环境污染最严重的行业之一,对其排放的大气污染物的来源和计算方法进行了综述与分析,并通过在时间尺度与空间尺度上的对比,发现近十年水泥行业粉尘、SO2和NOx的排放量随着水泥产量的增加而增大,华东地区水泥行业的粉尘、SO2和NOx排放量分别占全国总量的31.8%、31.0%和31.8%,是我国7个区域中大气污染物排放量最高的区域。     

Distribution,fractionation and risk assessment of mercury in surficial sediments of Nansi Lake,China

Nansi Lake is composed of four sub-lakes from north to south: Nanyang Lake, Dushan Lake, Zhaoyang Lake and Weishan Lake. An environmental pollution investigation was carried out to determine the fractionation, and pollution assessments of mercury (Hg) in surficial sediments from Nansi Lake. Results showed that the mean concentration of Hg was 3.1 times higher than its background value (0.015 mg kg^?1), and the high concentration of Hg which even reached up to five times than the background value in the part of Dushan Lake and Weishan Lake, which indicated that there are obvious spatial differences. The content of Hg was positively correlated with that of total organic carbon, and negatively correlated with that of pH and SiO₂ in surface sediments. An improved Tessier sequential extraction procedure was used to study the fractions of Hg in sediments. The results indicated that Hg existed primarily in the fraction of residual, which accounts for 58.4% of total mercury (THg), and the percentage of extractable Hg was only 1.93% of total mercury. High concentrations of mercury of non-residual phase were found in part lake area from the Nanyang Lake and the Weishan Lake, which indicating a higher potential ecological risk relative to the other lake areas. Based on the values of enrichment factor and geo-accumulation index, most part of Dushan Lake and Nanyang Lake and Weishan Lake were in a moderate pollution. And based on the fractionation of mercury, risk assessment code of Hg exhibited low risks to the environment in Nansi Lake.     

Aggravation of membrane fouling and methane leakage by a three-phase separator in an external anaerobic ceramic membrane bioreactor

The existence of three-phase separator did not affect COD removal in the EAnCMBR. The existence of three-phase separator aggravated methane leakage of EAnCMBR. The existence of three-phase separator aggravated membrane fouling rate of EAnCMBR. Start-up of EAnCMBR equipped three-phase separator was slightly delayed. The three-phase separator is a critical component of high-rate anaerobic bioreactors due to its significant contribution in separation of biomass, wastewater, and biogas. However, its role in an anaerobic membrane bioreactor is still not clear. In this study, the distinction between an external anaerobic ceramic membrane bioreactor (EAnCMBR) unequipped (R1) and equipped (R2) with a three-phase separator was investigated in terms of treatment performance, membrane fouling, extracellular polymers of sludge, and microbial community structure. The results indicate that the COD removal efficiencies of R1 and R2 were 98.2%±0.4% and 98.1%±0.4%, respectively, but the start-up period of R2 was slightly delayed. Moreover, the membrane fouling rate of R2 (0.4 kPa/d) was higher than that of R1 (0.2 kPa/d). Interestingly, the methane leakage from R2 (0.1 L/d) was 20 times higher than that from R1 (0.005 L/d). The results demonstrate that the three-phase separator aggravated the membrane fouling rate and methane leakage in the EAnCMBR. Therefore, this study provides a novel perspective on the effects of a three-phase separator in an EAnCMBR.     

Effect of La3+ on the activities of antioxidant enzymes in wheat seedlings under lead stress in solution culture

In order to improve the plant ability to resist lead stress, effect of 0.05 mg/l La(NO₃)₃ on the activities of catalase (CAT), superoxide dismutase (SOD), the level of malondialdehyde (MDA) in wheat seedlings under lead stress was studied. The effect of La³⁺ on plant growth, chlorophyll content in wheat seedlings after adding 0, 50, 100 mg/l Pb(NO₃)₃ to the nutrient solution for 12 days was observed. The plants were grown in nutrient solution in a strictly controlled climate growth room. Effects of La³⁺ (with La treatment) compared with check groups was evidently observed. The activities of SOD and CAT in root were enhanced 0.45–1.69 times and 33.20–77.77% respectively and MDA content was reduced 11.05–27.49% in root after treatments from the second day till the end of the experiment. The activities of SOD and CAT was found to be increased slightly (P<0.05) and MDA content decreased in shoot and root of wheat seedlings by La³⁺ under lead stress within five days after treatments compared with Pb1 and Pb2 groups. It was assumed that antioxidant enzymes was found to be increased by La(NO₃)₃, the antioxidant potential of the wheat seedlings to resist lead stress enhanced. It is suggested that La³⁺ could be used to resist lead stress at the beginning under stress while the stress was not so serious.     

A laboratory study of bacteria-facilitated cadmium transport in alluvial gravel aquifer media

Colloids, including bacteria, can dramatically accelerate the transport of heavy metals in ground water. Batch and column experiments were conducted to investigate adsorption of cadmium (Cd) onto Bacillus subtilis spores or Escherichia coli vegetative cells and Cd transport in alluvial gravel aquifer media in the presence of these bacteria. Results of the batch experiments showed that adsorption of Cd onto the bacteria was (i) positively related to solution pH, bacterial concentration, and negative surface charge, but inversely related to Cd concentration and (ii) a rate-limited nonlinear process, but adsorption onto E. coli was much less. For column influent Cd concentrations of about 4 mg/L and bacterial concentrations of > or = 10(5) colony-forming units (cfu)/mL, there was a significant increase in total Cd effluent concentrations. In comparison with controls that did not have bacteria-facilitated transport, Cd traveled 17 to 20 times faster when it traveled with mobile bacteria. However, Cd traveled mostly 2 to 3 times slower during the desorption phase under the influence of bacteria retained in the column. The difference between total and dissolved Cd concentrations was significant during Cd cotransport with B. subtilis spores, but this concentration difference was very small during Cd cotransport with E. coli, suggesting an adsorption-dominant mechanism during Cd cotransport with the spores and the possibility of Cd chelation by the dissolved membrane vesicles secreted from E. coli cell walls. Bacteria-facilitated transport of heavy metals may pose a threat to ground water quality in sites such as landfills and following land disposal of industrial and domestic effluent and sludge.     

机械故障诱发的轧机着火原因分析与预防

结合生产系统的防火状况，利用科学的统计归类分析方法，系统地分析机械故障诱发轧机着火的原因，同时寻找出合理的预防措施，减少火灾的危害。