A pilot-scale study of cryolite precipitation from high fluoride-containing wastewater in a reaction-separation integrated reactor

Fluoride removal by traditional precipitation generates huge amounts of a water-rich sludge with low quality, which has no commercial or industrial value. The present study evaluated the feasibility of recovering fluoride as low water content cryolite from industrial fluoride-containing wastewater. A novel pilot-scale reaction-separation integrated reactor was designed. The results showed that the seed retention time in the reactor was prolonged to strengthen the induced crystallization process. The particle size of cryolite increased with increasing seed retention time, which decreased the water content. The recovery rate of cryolite was above 75% under an influent fluoride concentration of 3500 mg/L, a reaction temperature of 50℃, and an influent flow of 40 L/hr. The cryolite products that precipitated from the reactor were small in volume, large in particle size, low in water content, high in crystal purity, and recyclable.     

基于层次分析法（AHP）的环境绩效审计评价体系构建研究——以丽水市为例

文章构建了环境绩效审计综合评价指标体系,运用层次分析法确定指标体系的权重,对于提高环境绩效审计工作质量和效率具有重要意义。丽水市生态资金绩效审计的实证研究结果表明,指标体系评价结果能客观反映市县行政区实际,指明影响环境管理绩效的消极因素,能有效提高财政经费使用效益,充分发挥审计服务科学发展的作用。     

HHT方法在山丹地电场数据处理中的应用

详细介绍了一种新的时频分析方法——HHT(Hilbert-Huang Transform)方法,应用该方法处理了山丹台地电场观测数据,通过对各模态分量进行频谱分析以及与原始观测数据进行对比,结果表明:(1)山丹地电场日变化以8 h周期成分最强,这与地电场日变化呈"双峰单谷"形态一致;(2)山丹台地电场日变化主要以半日波、全日波和8 h周期成分为主,还存在许多短周期成分,其中12 h的半日波成分最强。该结果与前人研究结果一致,验证了该方法处理地电场数据是有效的。     

酞菁-二氧化钛光催化剂的制备及其光催化降解效果

采用溶胶-凝胶法制备酞菁-TiO2光催化剂,并分别掺杂铁、铜、钴、镍元素。酞菁作为光敏化剂,提高TiO2在可见光下对有机染料的降解效果。采用SEM对催化剂进行表征,研究在可见光下酞菁-TiO2光催化剂对5种有机染料(甲基橙、甲基红、甲酚紫、亚甲基蓝和孔雀石绿)的降解效果,结果表明,酞菁铁-TiO2,酞菁钴-TiO2,酞菁铜-TiO2,酞菁镍-TiO2均能有效降解这几种有机染料,光催化反应300 min后降解率达92%。比较4种催化剂对甲基橙的降解率,酞菁钴-TiO2催化剂降解效果最明显,以下是酞菁铁、酞菁镍和酞菁铜-TiO2催化剂。     

站控、通信及网络系统的防雷措施

论述了输油泵站控制系统及微波通信系统遭受雷击的危害及原因,有针对性地采取了各种防雷的有效措施,完善微波通讯和站控及网络防雷保护系统,为确保输油安全生产提供了有利保证.     

硫酸系统水平衡分析计算和生产实践

在硫酸系统中,通过水平衡分析计算烟气带入净化工序的SO2体积分数和含水量,确定净化工序的能力,控制干燥塔进口烟气温度,使干吸工序生产出合格产品;通过计算,烟气带入净化工序的水量小于产品带出的水量,制酸净化污水经过污水处理工序处理后返回到净化工序重复使用,实现净化污水零排放,消除对环境的污染.     

Removal of copper ions from aqueous solution by calcium alginate immobilized kaolin

Kaolin has been widely used as an adsorbent to remove heavy metal ions from aqueous solutions. However, the lower heavy metal adsorption capacity of kaolin limits its practical application. A novel environmental friendly material, calcium alginate immobilized kaolin (kaolin/CA), was prepared using a sol-gel method. The e ects of contact time, pH, adsorbent dose, and temperature on Cu2+ adsorption by kaolin/CA were investigated. The Langmuir isotherm was used to describe the experimental adsorption, the maximum Cu2+ adsorption capacity of the kaolin/CA reached up to 53.63 mg/g. The thermodynamic studies showed that the adsorption reaction was a spontaneous and endothermic process.     

Structural and electrochemical properties of annealed La1-xYxNi3.55Mno.4Alo.3Coo.75 hydrogen storage alloys

The effects of the annealing and partial substitution of Y for La on the structural and electrochemical properties of La_1-xY_xNi_3.55Mn_o.4Al_o.3Cr_o.75 (x = 0, 0.1 and 0.2) alloys were reported in the present work. The single-phased CaCu₅-type structure was retained after La was partially substituted by Y. However, the increase of Y content leads to decrease of the lattice parameters and the unit-cell volume. The annealed La_o.9Y_o.1Ni_3.55Mn_o.4Al_o.3Co_o.75 alloys shows typical isometric microstructure, indicating that the composition segregation is improved by annealing. Y substitution for La in the alloys is effective to improve the electrochemical properties at both room temperature and high temperature. A critical substitution content of Y is found at x = 0.1.     

Catalytic bubble-free hydrogenation reduction of azo dye by porous membranes loaded with palladium nanoparticles

Catalytic bubble-free hydrogenation reduction of azo dye by porous membranes loaded with palladium （Pd） nanoparticles was studied for the first time. The effects of Pd loading, dye concentration and reuse repetitions of membranes were investigated. In reduction, the dye concentration decreased whereas the pH rose gradually. An optimal Pd loading was found. The catalytic membranes were able to be reused more than 3 times.     

Biosorption mechanisms involved in immobilization of soil Pb by Bacillus subtilis DBM in a multimetal-contaminated soil

Mechanisms of soil Pb immobilization by Bacillus subtilis DBM, a bacterial strain isolated from a heavy-metal-contaminated soil, were investigated. Adsorption and desorption experiments with living bacterial cells as well as dead cells revealed that both extracellular adsorption and intracellular accumulation were involved in the Pb2＋removal from the liquid phase. Of the sequestered Pb（II）, 8.5% was held by physical entrapment within the cell wall, 43.3% was held by ion-exchange, 9.7% was complexed with cell surface functional groups or precipitated on the cell surface, and 38.5% was intracellularly accumulated.Complexation of Pb2＋with carboxyl, hydroxyl, carbonyl, amido, and phosphate groups was demonstrated by Fourier transform infrared spectroscopic analysis. Precipitates of Pb5（PO4）3OH, Pb5（PO4）3Cl and Pb10（PO4）6（OH）2that formed on the cell surface during the biosorption process were identified by X-ray diffraction analysis. Transmission electron microscopy–energy dispersive spectroscopic analysis confirmed the presence of the Pb（II）precipitates and that Pb（II） could be sequestered both extracellularly and intracellularly.Incubation with B. subtilis DBM significantly decreased the amount of the weak-acid-soluble Pb fraction in a heavy-metal-contaminated soil, resulting in a reduction in Pb bioavailability, but increased the amount of its organic-matter-bound fraction by 71%. The ability of B.subtilis DBM to reduce the bioavailability of soil Pb makes it potentially useful for bacteria-assisted phytostabilization of multi-heavy-metal-contaminated soil.