缩聚-Fenton-A/O生物流化床组合工艺处理酚醛废水的工程案例分析

以广州某公司生产酚醛树脂时产生的酚醛废水为研究对象,针对其高浓度、生物毒性强、可生化性差及难降解等特点,设计缩聚-Fenton-A/O生物流化床联合工艺进行处理。此工艺的工程实践中,在总HRT低于75 h的操作条件下,当进水COD、苯酚及甲醛浓度分别为1.0×105～1.2×105 mg/L、2.2×104～2.5×1...     

Cr(VI) uptake mechanism of Bacillus cereus

In this study, we investigated the Cr(VI) uptake mechanism in an indigenous Cr(VI)-tolerant bacterial strain -Bacillus cereus through batch and microscopic experiments. We found that both the cells and the supernatant collected from B. cereus cultivation could reduce Cr(VI). The valence state analysis revealed the complete transformation from Cr(VI) into Cr(III) by living B. cereus. Further X-ray absorption fine structure and Fourier transform infrared analyses showed that the reduced Cr(III) was coordinated with carboxyl and amido functional groups from either the cells or supernatant. Scanning electron microscopy and atomic force microscopy observation showed that noticeable Cr(III) precipitates were accumulated on bacterial surfaces. However, Cr(III) could also be detected in bacterial inner portions by using transmission electron microscopy thin section analysis coupled with energy dispersive X-ray spectroscopy. Through quantitative analysis of chromium distribution, we determined the binding ratio of Cr(III) in supernatant, cell debris and cytoplasm as 22%, 54% and 24%, respectively. Finally, we further discussed the role of bacterium-origin soluble organic molecules to the remediation of Cr(VI) pollutants.     

碱熔预处理对粉煤灰溶解规律的影响及其动力学

在用粉煤灰合成沸石分子筛的过程中,粉煤灰在碱液中的溶解影响到合成反应的速率以及合成分子筛的性能。采用碱熔的方法处理粉煤灰,研究了粉煤灰在碱液中的溶解机理以及碱熔预处理对粉煤灰溶解规律的影响,并采用Noyes-Whitney方程分析其溶解动力学。结果表明,经过碱熔预处理的粉煤灰有36．11％的SiO2和16．33％的Al2O3转化为水溶性成分,剩余的非水溶性部分在碱液中的溶解速率也有大幅提高,硅铝离子达到平衡浓度的时间缩短,铝离子的平衡浓度有较大提升。Noyes-Whitney方程对粉煤灰在碱液中的溶解规律适用,相关系数都达到0．979以上。     

风量对高频气力分选机分选效率及金属分布规律的影响——以废弃印刷电路板粉末为例

以金属高富集粒级0.5～0.125 mm的废弃电路板为分选物料,通过ICP-AES测定分选产品,研究了风量对高频气力分选机分选效率及金属分布规律的影响.结果表明,风量变化对分选效率及金属分布规律影响显著,当风量为200m3/h时分选效率达到最大值78.23％,铜品位为86.745％,相比原料中铜品位13.96％,富集约6.2倍.随着风量的变化,金属的分布呈现规律性变化:密度比铜大或与铜相差不多的金属颗粒(铅、铂和锌等),其变化规律与铜相似,回收率在85％左右变化;密度比铜小很多的金属颗粒(铝、镁等),由于其密度与分选物料中的非金属非常接近,在分选过程中会随非金属带人轻产物中去,从而造成重产物中铝和镁品位最低,甚至低于其在原料中的品位.所以若要分离富集铝和镁,须对分选后的物料进行二次分选.     

一株耐铬不动杆菌对十二烷基硫酸钠的降解特性

研究醋酸钙不动杆菌H1的降解广谱性时,发现其能在高浓度十二烷基硫酸钠(SDS)环境中生长。经过对菌株H1降解特性研究,结果表明,该菌利用SDS的最适温度为30℃,最适pH为7.0,最适接种量为2%,并适应低渗透压环境。当SDS浓度低于400 mg/L时,菌株H1对SDS的降解率在85%以上,且在SDS浓度为400 mg/L时,达到最大降解率94%。当K2Cr2O7为500 mg/L时,菌株H1对SDS的降解率仍达到50%左右。添加酵母浸出物可促进SDS的降解。     

温度对SBR单级好氧生物除磷性能的影响

以合成废水为研究对象,以丙酸钠作为单一碳源,分别设置温度为5、15、25、35℃的4组序批式反应器(R1、R2、R3、R4),考察了温度对单级好氧工艺除磷的影响。结果表明,稳定运行阶段,R1、R2、R3、R4出水磷浓度分别为4.05、2.17、1.34和0.11 mg/L,去除效率分别为61.5%、79.3%、87.2%和99.0%,吸磷速率分别为0.501、1.432、2.538和3.700mg P/(g VSS·h),即提高温度有利于磷的去除。此外,各反应器中多聚磷酸盐激酶(PPK)和外切磷酸盐酶(PPX)活性分别为0.093、0.213、0.376、0.549 U和0.010、0.019、0.029、0.025 U,导致吸磷速率和释磷速率随之增大,可知温度影响聚磷菌PPK和PPX的活性,从而影响除磷效果。静置阶段,聚磷菌体内储能物质糖原质和聚羟基脂肪酸酯基本保持不变,但各反应器均出现了释磷现象,聚磷作为主要供能物质,单位释磷量分别为1.95、6.42、9.90和9.56 mg P/(g TSS),提高温度可促进静置段聚磷分解提供能量,从而驱动好氧吸磷达到更好的除磷效果。     

Speciation of Cu and Zn during composting of pig manure amended with rock phosphate

Pig manure usually contains a large amount of metals, especially Cu and Zn, which may limit its land application. Rock phosphate has been shown to be effective for immobilizing toxic metals in toxic metals contaminated soils. The aim of this study work was to investigate the effect of rock phosphate on the speciation of Cu and Zn during co-composting of pig manure with rice straw. The results showed that composting process and rock phosphate addition significantly affected the changes of metal species. During co-composting, the exchangeable and reducible fractions of Cu were transformed to organic and residue fractions, thus the bioavailable Cu fractions were decreased. The rock phosphate addition enhanced the metal transformation depending on the level of rock phosphate amendment. Zinc was found in the exchangeable and reducible fractions in the compost. The bioavailable Zn fraction changed a little during the composting process. The composting process converted the exchangeable Zn fraction into reducible fraction. Addition of an appropriate amount (5.0%) of rock phosphate could advance the conversion. Rock phosphate could reduce metal availability through adsorption and complexation of the metal ions on inorganic components. The increase in pH and organic matter degradation could be responsible for the reduction in exchangeable and bioavailable Cu fractions and exchangeable Zn fraction in rock phosphate amended compost.     

改进气相色谱法测定总烃与非甲烷总烃

采用十通阀、双定量环进样(进样量0.5 m L),专用的甲烷柱和总烃柱分别分离两路气样,单FID检测器检测的方法测定环境空气和固定污染源废气中的总烃和非甲烷总烃(NMHC)。实验结果表明:总烃与甲烷工作曲线的相关系数分别为0.997 7和0.999 0;总烃与甲烷测定结果的相对标准偏差均未超过1.5%;总烃与NMHC的检出限均为0.04 mg/m~3;总烃的加标回收率为90.3%~113.0%,NMHC的加标回收率为91.1%~110.0%。上述指标均满足HJ 604—2011和HJ/T 38—1999中对总烃及NMHC的测定要求。用注射器采样后的气样应尽量避光保存,放置时间宜在8 h之内。该方法无需制备除烃空气,大幅提升了检测效率。