双变截面SCR脱硝系统导流板优化设计

根据某电厂1 000 MW塔式锅炉脱硝系统催化剂首层速度偏差较大的问题,建立了基于CFD仿真分析技术的三维SCR脱硝系统数学模型,对该系统双变截面烟道处的导流板布置方式进行研究,以优化催化剂首层的速度分布。通过对比不同结构导流板下的结果,提出将原始SCR系统的双变截面烟道拆分为X方向和Z方向2个变截面烟道的改造方案。在此结构下重新进行优化设计,改造后系统内的回流区和低速区消除,流场均匀性显著提升,取得了积极的效果。为实际电厂优化调试,解决类似工程问题提供了参考数据。     

Heavy metals in soils from a typical industrial area in Sichuan,China: spatial distribution,source identification,and ecological risk assessment

Anthropogenic activities could result in increasing concentrations of heavy metals in soil and deteriorating in soil environmental quality. Topsoil samples from a typical industrial area, Shiting River Valley, Sichuan, Southwest China, were collected and determined for the concentrations of Cu, Zn, Cr, Cd, As, and Hg. The mean concentrations of these metals were lower than the national threshold values, but were slightly higher than their corresponding background values, indicating enrichment of these metals in soils in the valley, especially for Cu, Zn, and Hg. The topsoils in this area demonstrated moderate pollution and low potential ecological risk. Principal component analysis coupled with cluster analysis was applied to analyze the data and identified possible sources of these heavy metals; the results showed that soil Cd, Hg, As, Cu, and Zn were predominantly controlled by human activities, whereas Cr was mainly from the parent material. The spatial distribution of the heavy metals varied distinctly and was closely correlated to local anthropogenic activities. Furthermore, the concentrations of heavy metals in the industrial land demonstrated relatively higher levels than those of other land use patterns. Soil metal concentrations decreased with the distance increase from the traffic highway (0–1.0 km) and water system (0–2.0 km). Additionally, soil properties, especially pH and soil organic matter, were found to be important factors in the distribution and composition of metals.     

双碱法多级雾化超重力旋转床烟气脱硫研究

多级雾化超重力旋转床是一种新型的强化传质设备 ,适合于大流量的废气处理。本文选择NaOH Ca(OH) 2双碱法烟气脱硫工艺进行了实验研究 ,考察了再生液的PH0 值、液气比及气体中的SO2 初始浓度等对脱硫率的影响     

菌丝体表面分子印迹壳聚糖吸附剂对Cr3+的吸附性能研究

菌丝体表面分子印迹吸附剂所保留的印迹对过渡金属离子有着良好的吸附作用,以Cr3 作为吸附离子,系统研究了该吸附剂的吸附特性和影响因素.结果表明:吸附剂对Cr3 的饱和吸附容量可达60 mg/g;其吸附行为满足Langmuir方程式.初始浓度为200 mg/L时,最佳吸附pH在3～4,吸附容量可达到50 mg/g左右,离子强度对吸附没有影响,用0.5 mol/L硝酸或硫酸解吸Cr3 ,解吸率在90%以上.     

颗粒物吸附乐果的动力学特征

研究了乐果在颗粒物表面上吸附的动力学特征,观察了颗粒物的性质对吸附行为的影响.结果表明,乐果在3种颗粒物上的吸附过程均符合一级动力学规律,其相关系数在0.986 2～0.990 5,达到极显著水平.颗粒物的性质与吸附量相关分析发现,不同颗粒物对乐果的吸附程度是由颗粒物的有机质、粘粒、阳离子交换容量(CEC)和pH等理化特征综合作用的结果.pH对吸附行为影响的实验结果指出,随着体系的pH逐渐增大,颗粒物对乐果的吸附能力增强.     

错流式动态膜-生物反应器中污泥活性的研究

应用错流式动态膜-生物反应器（CDMBR）对己内酰胺废水进行了180d的实验，实验过程中测定反应器的膜出水和上清液的水质，并对污泥进行了耗氧呼吸速率测定。结果表明，上清液COD一直保持在100mg／L以下，而膜出水的则保持在50mg／L以下，膜对上清液的COD去除率达50％，而对氮的去除没有贡献。可溶性细胞产物（SMP）在反应器内容易积累，停留足够的时间后能被生物降解。通过投加抑制剂测定耗氧呼吸速率，发现异养菌、硝化细菌和亚硝化细菌的活性由于F／M的降低和SMP积累受到一定的抑制，但不影响系统的处理效率。跨膜压力、膜面流速越大，通量衰减得也就越快。     

调理剂对CAF污泥浓缩工艺影响的试验研究

涡凹气浮（CAF）已广泛应用于工业废水和城市污水的预处理中.由于污泥本身的特性原因,CAF在污泥处理中尚没有应用.通过试验投加污泥调理剂改变污泥的特性,以达到将CAF工艺用于浓缩活性污泥的目的.试验表明,CAF工艺浓缩低浓度剩余活性污泥效果很好,但正确选择污泥调理剂的投加点和投加量对CAF污泥浓缩工艺至关重要.     

Chemical characterizations of soluble aerosols in southern China

Soluble aerosols are measured at Guangdong and Hainan Provinces of southern China. The measured chemical composition of aerosols includes F-, Cl-, NO3-, SO4=, Na+, NH4+, K+, Ca2+, and Mg2+. The locations of measurements include a mega city (Guangzhou), a medium city along the coastline (Haiko), a small city along the coastline (Shanya), and a remote island site in the South China Sea (Yongxing island). The results reveal that aerosols in this region are complex and heterogeneous. Sulfate aerosol (SO4=) has the highest concentrations in Guangzhou (approximately 41% of total soluble aerosol mass), suggesting that anthropogenic activities (e.g., coal burning) play important roles in controlling aerosol concentrations in Guangzhou. By contrast, the concentrations of chlorine (Cl-) and sodium (Na+) are higher in Yongxing than in Guangzhou, indicating that the sea salt is the dominant aerosol in this marine environment site. In the medium (Haiko) and small (Shanya) city sites, the effects of anthropogenic and marine activities on aerosols fall in between the values in the mega city and the remote island site. The measured ratio of Cl-/Na+ shows that the ratio is less than 1.16 in all observation sites. The ratio in the Guangzhou city, the Haiko city, the Shanya city, and the Yongxing island is 0.52, 0.91, 0.24, and 0.53, respectively, indicating that significantly heterogeneous chemical reactions occur on sea salt particles. Unlike those in Europe and North America, there are high concentrations of calcium (Ca+) in all observation sites. The percentage of calcium mass to the measured total soluble aerosols mass is 21, 32, 34, and 30 at Guangzhou, Haiko, Sanya, and Yongxing, respectively. The calculations show that calcium plays an important role in neutralizing aerosols. The calculated "cation/anion" (summation operator[ion+]/summation operator[ion-]) ratio is 2.5, 2.5, 3.2, and 2.1, at Guangzhou, Haiko, Shanya, and Yongxing, respectively. The high "cation/anion" ratios suggest that SO4=, NO3-, and Cl- are neutralized, and the aerosols as a whole (internally mixed), appear to be in an alkaline mode in this region. However, without taking into account for calcium, the calculated "cation/anion" ratio reduces to 1.2, 0.98, 1.3, and 0.8 at Guangzhou, Haiko, Sanya, and Yongxing, respectively. The property of aerosols switches from an alkaline mode to an acidity mode at the Haiko and Yongxing sites.     

300MW燃煤机组烟气控制装置对气态汞去除效果

利用美国EPA OH法对烟气中不同形态汞的气态汞进行测试,研究300 MW锅炉的袋式除尘、静电除尘和湿法烟气脱硫对气态汞的去除效果。研究结果表明,静电除尘器对气态汞的去除效率仅为32.50%,对颗粒态汞的去除效率达76.88%,而使用袋式除尘器对气态汞的去除效率可达44.33%,可脱除99.92%以上的颗粒态汞;应用湿法烟气脱硫对二价汞的去除率可达49.03%。通过对粉煤灰、炉渣和脱硫石膏等燃煤副产物汞含量分析发现,脱硫石膏中汞的含量最高达0.77 mg/kg,汞及其环境毒性是燃煤副产物安全利用时需要注意一个主要问题。     

基于SBBR的单级自养脱氮快速启动

以普通活性污泥为接种污泥,采用人工配制无机氨氮废水进行单级自养脱氮工艺快速启动研究。启动过程经历了污泥适应期、部分短程硝化选择期以及单级自养脱氮实现期3个阶段。经过29 d的培养驯化,通过控制游离氨的方法实现了部分短程硝化。当出水中亚硝酸盐积累率达到60%左右时,立即将序批式生物膜反应器(SBBR)由连续曝气改为间歇曝气,间歇曝气使得厌氧氨氧化菌(AAOB)的富集与亚硝酸氧化菌(NOB)的淘汰同时进行,并且避免了高浓度亚硝酸盐对AAOB的抑制作用,从而实现了单级自养脱氮的快速启动。实验仅用50 d成功启动了SBBR单级自养脱氮工艺,总氮容积去除负荷达到0.173 kg N/(m3·d),氨氮的平均去除率达到98.68%,总氮的平均去除率达到80.87%。成功启动之后,反应器内只有少量的悬浮污泥,大部分的污泥都附着在填料上,污泥颜色呈褐色,而反应器内壁及出水管上附着的污泥呈浅砖红色,表明反应器内富集了大量的AAOB。