可靠性强化试验技术在某型伺服作动器研制中的适用性探索

目的探索可靠性强化试验技术在典型机电液一体化产品伺服作动器研制过程中的适用性。方法以某型伺服作动器为研究对象,从故障激发的角度对可靠性强化试验技术的应用进行可行性分析,在响应调查和应力分析的基础上,结合产品的工作特点设计适用于该类伺服作动器的可靠性强化试验方案,包含低温步进应力试验、高温步进应力试验、快速温度循环试验10个循环、振动步进应力试验(包含气锤式三轴向六自由度超高斯随机振动方式及电磁振动台随机振动方式)及综合环境应力试验5个循环,并依此进行试验。结果在快速温度循环试验及综合环境应力试验过程中,均有效地激发出了产品的漏油故障,与相似产品外场暴露的漏油故障模式相吻合。结论可靠性强化试验技术可有效地应用于典型机电液一体化产品伺服作动器的研制过程,设计的可靠性强化试验方案可有效地激发外场出现频率较高的故障,可作为该类产品研制的试验手段之一。     

GJB 150A淋雨试验强化试验程序数值模拟和试验装置设计研究

目的 研究GJB 150.8A—2009《军用装备实验室环境试验方法第8部分:淋雨试验》中强化试验程序的工程实现方法.方法 在标准解读的基础上,以强化试验程序用喷嘴为对象,建立数值模型,分析喷嘴在强化试验程序过程中的流场分布,并基于分析结果给出强化试验程序试验装置设计的思路和方法.结果 在喷嘴内,压力变化剧烈,极短距离内由276 kPa迅速降至101 kPa.水流经过喷嘴经历了激烈的加速过程,从距离喷嘴出口0.01～0.4 m,水流速度从251 m/s迅速降至17.8 m/s,到远场趋于稳定.结论 分析结果对指导强化试验程序的试验装置的设计和试验实施具有重要参考意义.     

热强化气相抽提对不同质地土壤中苯去除的影响

研究应用电阻加热强化气相抽提技术对砂土、壤土和黏土中苯去除效果的影响及作用机制.与常规抽提结果相比,在热强化处理作用下气相抽提对砂土和壤土中苯的去除效率提高了13.1%和12.3%,处理时间分别降低75%和14%.热强化处理使得黏土含水率下降,土壤渗透率升高,黏土颗粒表面羧基和乙基的吸收峰消失,有机质含量减少,苯的去除效率与对照相比提高了34%.对于砂土和壤土,热强化主要是通过促进苯在土体中扩散来提高去除效率,从而实现在较短时间内污染物质的大量去除;而对于黏土则是通过降低土壤颗粒表面有机基团的含量,从而降低污染物和土壤颗粒的吸附能力,并通过降低含水率和升高渗透率从而提高土壤中气体的扩散性能,以达到增强气相抽提效果的目的.     

生物可降解螯合剂谷氨酸 N,N -二乙酸四钠对污泥中重金属萃取效率的研究

谷氨酸N,N-二乙酸四钠(GLDA)具有较强金属螯合能力,是新一代生物可降解绿色螯合剂.通过分批提取实验对GLDA去除工业污泥中Cd、Ni、Cu、Zn的萃取过程进行研究,考察了萃取时间、萃取体系p H值、螯合剂用量等因素对重金属萃取效果的影响,并采用修正的BCR连续提取法分析萃取前后污泥中重金属的形态.结果表明,GLDA对污泥中Cd具有良好的去除效果;体系在p H=4,螯合剂与重金属总量摩尔比为3∶1的条件下,多种重金属取得最佳萃取效果;Zn主要以残渣态存在,导致该金属萃取率低;螯合能力不仅与萃取时间,萃取体系p H值,螯合剂用量,螯合常数等因素有关,而且还与金属的形态分布有关.     

钙、氯对磷酸盐稳定污染土壤中铅的促进作用研究

为探讨促进磷酸盐稳定污染土壤中铅的方法,在全铅含量为517 mg·kg-1的铅冶炼污染土壤中加入5 mmol·kg-1磷酸盐,同时加入10mmol·kg-1硝酸钙或5 mmol·kg-1氯化钾,在15%或30%的含水率下培养40 d,之后种植黑麦草.结果表明,与单独施用磷酸盐相比,采用磷酸盐与钙、氯结合或增加培养期间的土壤含水率后,土壤DTPA-Pb含量下降3.92%~26.1%;对于同一添加剂处理,培养期间土壤含水率从15%增加到30%,土壤有效铅(DTPA-Pb)含量下降8.83%~24.4%.增加土壤含水率后,土壤有效磷(Olsen-P)含量均显著升高(p0.05).土壤铅的EXAFS分析表明,与未施用磷酸盐的对照相比,土壤中加入磷酸盐后矿物态铅的比例由57%上升至81%,加施钙、氯或增加土壤含水率后,多数处理矿物态铅的比例有所下降,而有机结合态铅比例上升.与对照相比,污染土壤中施用磷酸盐后,植物产量大幅增加,但施用钙、氯或增加培养期间含水率后,部分处理植物产量有所下降.以上结果表明,在铅冶炼污染土壤中加入磷酸盐时,加入钙、氯或者增加土壤含水率均有利于铅的稳定,但以上措施可能对植物生长产生不利影响.     

Denitrification potential enhancement by addition of external carbon sources in a pre-denitrification process

The aim of this study is to investigate the denitrification potential enhancement by addition of external carbon sources and to estimate the denitrification potential for the predenitrification system using nitrate utilization rate （NUR） batch tests. It is shown that the denitrification potential can be substantially increased with the addition of three external carbon sources, i.e. methanol, ethanol, and acetate, and the denitrification rates of ethanol, acetate, and methanol reached up to 9.6, 12, and 3.2 mgN/（g VSS.h）, respectively, while that of starch wastewater was only 0.74 mgN/（g VSS,h）. By comparison, ethanol was found to be the best external carbon source. NUR batch tests with starch wastewater and waste ethanol were carried out. The denitfification potential increased from 5.6 to 16.5 mg NO3-N/L owing to waste ethanol addition. By means of NUR tests, the wastewater characteristics and kinetic parameters can be estimated, which are used to determine the denitrification potential of wastewater, to calculate the denitrification potential of the plant and to predict the nitrate effluent quality, as well as provide information for developing carbon dosage control strategy.     

Oxidative stress and DNA damages induced by cadmium accumulation

Experimental evidence shows that cadmium （Cd） could induce oxidative stress and then causes DNA damage in animal cells, however, whether such effect exists in plants is still unclear. In the present study, Vicia faba plants was exposed to 5 and 10 mg/L Cd for 4 d to investigate the distribution of Cd in plant, the metal effects on the cell lipids, antioxidative enzymes and DNA damages in leaves. Cd induced an increase in Cd concentrations in plants. An enhanced level of lipid peroxidation in leaves and an enhanced concentration of H2O2 in root tissues suggested that Cd caused oxidative stress in Vicia faba. Compared with control, Cd-induced enhancement in superoxide dismutase activity was significant at 5 mg/L than at 10 mg/kg in leaves, by contrast, catalase and peroxidaseactivities were significantly suppressed by Cd addition. DNA damage was detected by neutral/neutral, alkaline/neutral and alkaline/alkaline Comet assay. Increased levels of DNA damages induced by Cd occurred with reference to oxidative stress in leaves, therefore, oxidative stress induced by Cd accumulation in plants contributed to DNA damages and was possibly an important mechanism of Cd-phytotoxicity in Vicia faba plants.     

Effects of nitrate concentration in interstitial water on the bioremediation of simulated oil-polluted shorelines

Nutrient addition has been proved to be an effective strategy to enhance oil biodegradation in marine shorelines.To determine the optimal range of nutrient concentrations in the bioremediation of oil-polluted beaches,nitrate was added to the simulated shoreline models in the initial concentration of 1,5 and 10 mg/L.Whenever the NO3-N concentration declined to 70% of its original value, additional nutrients were supplemented to maintain a certain range.Results showed adding nutrients increased the oil biodegradation level,the counts of petroleum degrading bacteria(PDB)and heterotrophic bacteria (HB),and the promoted efficiency varied depending on the concentration of nitrate.Oil degradation level in 5 mg/L(NO_3-N)group reached as much as 84.3% accompanied with the consistently highest counts of PDB;while in 1 mg/L group oil removal efficiency was only 35.2%,and the numbers of PDB and HB were relatively low compared to the other groups supplemented with nutrients.Although counts of HB in the 10 mg/L group were remarkable,lower counts of PDB resulted in poorer oil removal efficiency (70.5%) compared to 5 mg/L group.Furthermore,it would need more NO_3-N(0.371 mg)to degrade 1 mg diesel oil in the 10 mg/L group than in the 5 mg/L group(0.197 mg).In conclusion, Nitrate concentration in 5 mg/L is superior to 1 and 10 mg/L in the enhancement of diesel oil biodegradation in simulated shorelines.     

载钯螯合树脂的制备、表征及其降解多溴联苯醚的初步研究

以聚丙烯醛-异烟酰腙螯合树脂为高分子载体, 利用其活性基团对钯的选择性富集分离性能, 将金属元素钯键合到高分子载体上, 制备一种含钯树脂材料(树脂1), 并进一步原位还原得到还原态的载钯树脂(树脂2)。利用红外光谱、扫描电镜和X射线衍射等对以上2种含钯树脂材料进行了分析表征,并考察了它们对持久性有机污染物(POPs)多溴联苯醚(PBDEs)的脱溴降解性能。结果表明,2种树脂对BDE₂₀₉均有降解活性, 其中树脂1的降解性能比树脂2的降解性能要高, 树脂中钯的氧化形态可能对BDE₂₀₉的催化降解起主要作用。     

微量金属元素及其配合物对厨余垃圾甲烷发酵的影响

生物可利用的微量金属元素不仅能够保证污染物以最大的速率转化,而且还可以使某些特殊的转化得以发生,并提高微生物对有毒污染物质的耐受能力。在研究厨余垃圾总固体浓度(total solid, TS)、接种量和C/N比对厨余垃圾厌氧发酵影响的基础上,重点探讨微量金属元素钴及其配合物丝氨酸对厨余垃圾厌氧发酵甲烷产量及关键酶含量的影响。结果表明,当TS为0.5%、接种污泥量为100 mL/L和C/N比为20∶1时,厨余垃圾厌氧发酵的甲烷产率较高,为367 mL/g COD;添加2 μmol/L的微量金属元素钴-配合物丝氨酸时,甲烷产率则提高到432 mL/g COD,相应地,辅酶M的含量由空白实验的41.21 μmol/g VSS提高到54.64 μmol/g VSS,辅酶F₄₂₀的含量由0.31 μmol/g VSS提高到0.48 μmol/g VSS。