脱氮除磷(NPR)工艺中试研究

NPR工艺是一种活性污泥法和生物膜法相结合的工艺,具有强化脱氮除磷的能力.中试研究采用固定的分段进水比例(厌氧流量∶缺氧流量=7∶3),在污泥龄为10 d的情况下,比较了0.6 m3/h和0.9 m3/h2种流量下对氮磷去除效果,分析了在0.6 m3流量下,工艺是如何对CODCr,NH3-N,PO43-进行去除的.试验发现:在0.6 m3/h流量下:出水稳定达到GB 18918-2002《城镇污水处理厂污染物排放标准》一级A标准,在0.9 m3/h流量下,出水稳定达到GB18918-2002《城镇污水处理厂污染物排放标准》一级B标准.     

电吸附技术在济宁三号煤矿矿井涌水深度处理中的应用

济三煤矿矿井涌水的净化出水进行深度处理采用电吸附技术,设计处理量8000m^3／d,脱盐率大于50％,产水率大于75％,吨水处理成本1．35元。     

Comparison of quartz sand, anthracite, shale and biological ceramsite for adsorptive removal of phosphorus from aqueous solution

The choice of substrates with high phosphorus adsorption capacity is vital for sustainable phosphorus removal from waste water in constructed wetlands. In this study, four substrates were used： quartz sand, anthracite, shale and biological ceramsite. These substrate samples were characterized by X- ray diffractometry and scanning electron microscopy studies for their mineral components （chemical components） and surface characteristics. The dynamic experimental results revealed the following ranking order for total phosphorus （TP） removal efficiency： anthracite 〉 biological ceramsite 〉 shale 〉 quartz sand. The adsorptive removal capacities for TP using anthracite, biological ceramsite, shale and quartz sand were 85.87, 81.44, 59.65, and 55.98 mg/kg, respectively. Phosphorus desorption was also studied to analyze the substrates＇ adsorption efficiency in wastewater treatment as well as the substrates＇ ability to be reused for treatment. It was noted that the removal performance for the different forms of phosphorus was dependent on the nature of the substrate and the adsorption mechanism. A comparative analysis showed that the removal of particulate phosphorus was much easier using shale. Whereas anthracite had the highest soluble reactive phosphorus （SRP） adsorptive capacity, biological ceramsite had the highest dissolved organic phosphorus （DOP） removal capacity. Phosphorus removal by shale and biological ceramsite was mainly through chemical adsorption, precipitation or biological adsorption. On the other hand, phosphorus removal through physical adsorption （electrostatic attraction or ion exchange） was dominant in anthracite and quartz sand.     

MBR出水后置化学除磷研究

选用不同的化学除磷药剂及固液分离方式,针对膜生物反应器出水进行后置化学除磷静态试验研究。试验表明,在MBR出水平均浓度为(6.0±0.3)mg/L时,在化学药剂的最佳投药量和混凝时间的条件下,TP可以稳定达到一级A标准,去除率达到95%以上;滤液达一级A标准,氯化铝、氯化铁、聚合硫酸铁、硫酸铝最佳投加量为1.5 mol/mol,硫酸铁、聚合硫酸铝最佳投加量为3.0 mol/mol,最佳混凝时间均为10 min;滤纸和滤膜可以有效分离混凝混合液中的TP,滤液TP可稳定达一级A标准,而微网对混合液中粒径小于D10的颗粒无法分离,致使滤液TP无法达标;PAM投加后,絮体粒径显著增大,固液分离效果也相应增强。微网分离效果较投加前有了明显提高,滤液TP可稳定达到一级B标准。     

改良UNITANK工艺在东鄱污水处理厂的应用分析

介绍了改良UNTIANK工艺在东鄱污水处理厂的应用情况,对比传统UNITANK工艺与改良UNTIANK工艺在除磷脱氮方面的去除效果,并讨论改良UNITANK工艺的结构、运行方式、工艺特点及存在问题,得出相关结论。     

Pd/activated carbon sorbents for mid-temperature capture of mercury from coal-derived fuel gas

Higher concentrations of Hg can be emitted from coal pyrolysis or gasification than from coal combustion, especially elemental Hg. Highly efficient Hg removal technology from coal-derived fuel gas is thus of great importance. Based on the very excellent Hg removal ability of Pd and the high adsorption abilities of activated carbon（AC） for H2 S and Hg, a series of Pd/AC sorbents was prepared by using pore volume impregnation, and their performance in capturing Hg and H2 S from coal-derived fuel gas was investigated using a laboratory-scale fixed-bed reactor. The effects of loading amount, reaction temperature and reaction atmosphere on Hg removal from coal-derived fuel gas were studied. The sorbents were characterized by N2 adsorption, X-ray diffraction（XRD） and X-ray photoelectron spectroscopy（XPS）. The results indicated that the efficiency of Hg removal increased with the increasing of Pd loading amount, but the effective utilization rate of the active component Pd decreased significantly at the same time. High temperature had a negative influence on the Hg removal. The efficiency of Hg removal in the N2-H2S-H2-CO-Hg atmosphere（simulated coal gas） was higher than that in N2-H2S-Hg and N2-Hg atmospheres, which showed that H2 and CO, with their reducing capacity, could benefit promote the removal of Hg. The XPS results suggested that there were two different ways of capturing Hg over sorbents in N2-H2S-Hg and N2-Hg atmospheres.     

超声波法对微囊藻的去除和抑制作用研究

超声波法可以通过破坏细胞壁达到直接除藻和抑制活体细胞生长的2种作用处理废水中微囊藻。以铜绿微囊藻的3种不同藻株为实验对象,对超声法直接去除微囊藻和超声法抑制微囊藻生长的影响因素分别进行单因素平行实验。采用叶绿素a含量作为活体藻细胞指标,分别对超声法除藻、抑藻的最佳条件进行了分析。结果显示,超声法对铜绿微囊藻不同藻株的去除效果基本一致,选用对数增长期的微囊藻在超声功率为1 200 W、超声时间为7 min时,叶绿素a去除率为82%,对微囊藻的直接去除效果最好。改变超声模式,采用多频次间歇超声模式(超声总能量相同):超声功率为1 200 W、隔1天超声2 min,共超声4次,培养14 d后与对照组相比,最终叶绿素a含量下降了95%,有更佳的微囊藻抑制效果。     

NF90纳滤膜除硼性能研究

压力、回收率、p H值、温度对NF90纳滤膜去除酸性模拟含硼废水中的硼有较大影响。结果表明,在压力一定时,除硼率随回收率的升高而降低,回收率一定时,除硼率随压力的升高而升高;p H在3~5时,除硼率随p H值升高而降低;温度的升高将使除硼率下降。在本实验条件下,NF90纳滤膜除硼率为20%~40%,采用NF90纳滤膜方法除硼还需进行更进一步的研究处理。     

磷化氢的释放对提高生活污水除磷效果的试验研究

传统的污水除磷工艺通过排除剩余污泥或化学污泥达到除磷的目的,而磷化氢气体的发现,为污水除磷提供了新的途径。以磷化氢气体的形式将污水中的总磷排出系统,不仅能减少剩余污泥的排放,还能将磷化氢气体收集起来加以回收利用,可同时解决水体富营养化和磷资源匮乏的矛盾。本文首先总结了影响磷化氢气体产生的因素,并通过正交试验对密封的一体化生活污水反应器的工艺参数进行了优化,得出在铁投加量为100g、不进行预曝气时反应器收集到的磷化氢气体最多;然后通过研究磷化氢气体产生与污水总磷去除率的关系,得出提高磷化氢的释放速率将有助于提高生活污水的除磷效率;最后通过对正交试验前后系统中各种形态的磷进行物料衡算,分析了系统中磷的迁移转化途径。     

石墨-活性炭纤维复合电极电吸附处理含盐废水的研究

高盐废水是目前水处理领域的难点,作为一种新型的除盐技术,电吸附技术具有众多优点.本文研究了一种新型碳基复合材料,石墨-活性炭纤维复合电极,并考察了其应用于电吸附的影响因素和除盐效果.在电压为1.6 V,停留时间为60min,极板间距为1 cm时电吸附装置的除盐效果最优.用其分别对精制棉黑液和叶绿素铜钠废水进行了处理.电极对数为8对时对经酸析处理后的精制棉黑液的电导率和COD的去除率分别达到58.8%和75.6%;电极对数为6~8时对叶绿素铜钠生产废水的电导率的去除率能超过50.0%,COD的去除率约为13.5%.