脱木素工艺处理造纸废水的实践与机理

脱木素工艺为中小制浆企业的黑液治理提供了新的方法。系统中酸化纤维污泥减小碱木素胶粒间的斥力 ,吸附废水中已析出的木质素和细小纤维 ;酸破坏了系统中胶体的水化膜 ,增大了胶体的粒径 ;混凝剂中和胶体表面电荷 ,增加颗粒间的接触机会 ,同时发挥了絮凝沉降的作用。该工艺与传统工艺相比 ,减少了酸及混凝剂的用量 ,木素沉降速度快。当试验废水pH =5、绝干纤维污泥与进水CODCr质量之比为 1.1、硫酸铝投加量为 160mg/L时 ,CODCr去除率高于 63 %。     

利用水泥处理垃圾渗滤液生物处理出水的研究

利用水泥的表面吸附和水化反应性质处理垃圾渗滤液生物处理出水可以取得很好的效果,COD的去除率可达69.5%.处理效果与水灰比、反应时间密切相关,低水灰比和较长反应时间对COD的去除更为有利.对处理前后水样的COD和TOC分析表明,水泥对非TOC贡献的COD有很强的去除效果.     

侧联式球磨机的噪声控制

介绍了侧联式球磨机噪声产生原理及其噪声控制方法,选择了制作局部式隔声罩的噪声控制设计和装置结构.在中国铝业中州分公司热电厂球磨机上应用,取得了很好的隔声效果.     

Baseline study of methane emission from open digesting tanks of palm oil mill effluent treatment

Anthropogenic release of greenhouse gases, especially CO₂ and CH₄ has been recognized as one of the main causes of global warming. Several measures under the Kyoto Protocol 1997 have been drawn up to reduce the greenhouse gases emission. One of the measures is Clean Development Mechanisms (CDM) that was created to enable developed countries to cooperate with developing countries in emission reduction activities. In Malaysia, palm oil industry particularly from palm oil mill effluent (POME) anaerobic treatment has been identified as an important source of CH₄. However, there is no study to quantify the actual CH₄ emission from the commercial scale wastewater treatment facility. Hence, this paper shall address the CH₄ emission from the open digesting tanks in Felda Serting Hilir Palm Oil Mill. CH₄ emission pattern was recorded for 52 weeks from 3600 m³ open digesting tanks. The findings indicated that the CH₄ content was between 13.5% and 49.0% which was lower than the value of 65% reported earlier. The biogas flow rate ranged between 0.8 l min⁻¹ m⁻² and 9.8 l min⁻¹ m⁻². Total CH₄ emission per open digesting tank was 518.9 kg day⁻¹. Relationships between CH₄ emission and total carbon removal and POME discharged were also discussed. Fluctuation of biogas production was observed throughout the studies as a result of seasonal oil palm cropping, mill activities, variation of POME quality and quantity discharged from the mill. Thus only through long-term field measurement CH₄ emission can be accurately estimated.     

纤维改性硫酸亚铁还原铬渣水泥固化体研究

以浸出毒性、表面浸出率、抗日晒能力和抗压强度为指标考察了纤维改性硫酸亚铁还原铬渣水泥固化体的性能。实验结果表明：纤维改性硫酸亚铁还原铬渣水泥固化体养护7d和28d后的浸出毒性均低于国家标准、抗压强度均大于10MPa,可以做最终处置或进行综合利用;与普通铬渣水泥固化体相比,纤维改性硫酸亚铁还原铬渣水泥固化体在加入植物纤维为0．8g时的处理效果最好,浸出毒性、表面浸出率分别降低了76．I％和76．8％;抗日晒能力、抗压强度分别提高了36．4％和52．1％。     

Decolorization of molasses melanoidins and palm oil mill effluent phenolic compounds by fermentative lactic acid bacteria

Lactobacillus plantarum SF5.6 is one of the lactic acid bacteria (LAB) that has the highest ability of molasses melanoidin (MM) decolorization among the 2114 strains of LAB. The strains were isolated from spoilage, pickle fruit and vegetable, soil and sludge from the wastewater treatment system by using technical step of enrichment, primary screening and secondary screening. This LAB strain SF5.6 was identified by 16S rDNA analysis and carbohydrate fermentation (API 50 CH). The top five LAB strains having high MM decolorization ( 55%), namely TBSF5.8-1, TBSF2.1-1, TBSF2.1, FF4A and SF5.6 were selected to determine the optimal condition. It was found that the temperature at 30°C under facultative conditions in GPY-MM medium (0.5% glucose, 0.1% peptone, 0.1% yeast extract, 0.1% sodium acetate, 0.05% MgSO4 and 0.005% MnCl2 in MM solution at pH 6) giving a high microbial growth and MM decolorization for all five strains. It was noticed that the decolorization of MM by LAB strains might be cell growth associated. L. plantarum SF5.6 grew rapidly within one day while the other strains took 2–3 days. This L. plantarum SF5.6 could rapidly decolorize MM to 60.91% without any lag phase, and it also had the ability to remove 34.00% phenolic compounds and 15.88% color from treated palm oil mill effluent.     

序列间歇式活性污泥法处理毛纺厂废水的研究

采用序列间歇式活性污泥法处理毛纺厂废水。试验结果表明,经4h曝气处理,进水COD为190～650mg/L时,出水COD始终低于100mg/L,去除率大多在80％～90％之间,色度去除率大多在50％以上,出水COD和色度均达到行业排放标准。还对较低COD浓度下序列间歇式活性污泥法的COD降解过程进行了研究,推导出一级反应动力学关系式Sr＝So（1－10￣^-k1^t）,并以试验数据进行了拟合,求解出动力学常数k1和So。     

三氧化钨光催化法脱色处理化纤厂废水

以WO3粉体作为催化剂对化纤厂废水采用光催化氧化法进行脱色处理,讨论了光催化氧化法的反应机理,以及化纤厂废水的pH值、光催化剂的投入量、光照时间各因素对废水色度去除率的影响。实验结果表明：WO3粉体的投入量为1．000g／L,pH值为3．00时,利用300W高压汞灯光照7h后,废水试样的吸光度由0.596降低至0．020,色度去除率达到96．6％。     

纺织企业噪声职业危害风险评价及降噪措施

噪声是纺织业的主要职业危害之一。纺织企业生产车间的噪声不仅会影响到纺织生产的效率、工人的工作能力及安全,还会对纺织工人的健康造成危害,甚至导致职业病。以南方某纺织企业为研究对象,对其生产车间的噪声进行了调查测量,并采用职业病作业危害、职业接触风险评估二种评价方法,对该企业各生产工序的噪声职业危害进行风险评价,得出评价结论,从声源、声传播途径、个体防护及管理制度四个方面提出了降噪措施,以便更好地加强防治,预防减少噪声职业危害。     

Characterization of fulvic acids during olive mill waste composting (Elemental,Thermal and fluorescence analyses)

Elemental analysis, fluorescence spectroscopy and differential scanning calorimetry (DSC) were applied to the study of fulvic acids isolated from different stages during olive mill waste composting. The fulvic extracted acids are characterized by a high nitrogen content and O/C ratio values that may result from the high degree of humification and the synthesis of more condensed humic complexes. This was confirmed by fluorescence spectroscopy in the synchronous-scan mode by the decrease of shoulder intensities at intermediate wavelengths indicating the increase of polycondensation and conjugation of unsaturated structures and the greater uniformity of fluorophores. Fluorescence spectra in the emission, excitation and synchronous modes became simpler with compost maturation. This was confirmed by DSC results which proved the high degree of polycondensation of aromatic nuclei of fulvic acid molecules during olive mill waste composting.