Fenton氧化深度处理石化废水厂二级出水研究

采用连续流Fenton氧化对石化废水处理厂二级出水进行了处理试验,研究了药剂投量对COD及磷处理效果的影响,同时对处理过程中有机物的变化特性进行了分析.结果表明,原水COD平均为64.8 mg·L-1,PO3-4-P平均为0.79 mg·L-1,当H2O2(30%)投加量为0.4 m L·L-1,Fe SO4·7H2O的投加量为0.8 g·L-1,PAM投加量为0.9 mg·L-1,停留时间为30 min时,COD的平均去除率为24.3%,出水COD低于50 mg·L-1,PO3-4-P平均去除率为95.5%,原水中相对分子质量小于1×103的有机物占80.4%,Fenton氧化处理后该部分比例增加至95.6%.三维荧光分析结果表明,Fenton氧化对水中蛋白类、酚类去除效果显著.GC-MS结果表明,石化二级出水中检出主要有机物约117种,氧化后检出27种,含不饱和键类有机物去除明显.Fenton氧化可用于石化二级出水的深度处理.     

Preparation and characterization of Fe2O3-CeO2-TiO2/γ-Al2O3 catalyst for degradation dye wastewater

In order to develop a catalyst with high activity for catalytic wet oxidation （CWO） process at room temperature and atmospheric pressure, Fe2O3-CeO2-TiO2/γ-Al2O3 catalyst was prepared by consecutive impregnation method and the prepared parameters were optimized. The structure of the catalyst was characterized by BET, XRF, SEM and XPS technologies, and the actual wastewater was used to investigate the catalytic activity of Fe2O3-CeO2-TiO2/γ-Al2O3 in CWO process. The experimental results showed that the prepared catalyst exhibited good catalytic activity when the doping amount of Ti was 1.0 wt% （the weight ratio of Ti to carriers）, and the middle product, Fe2O3-CeO2-TiO2/γ-Al2O3, was calcined in 450℃ for 2 h. The CWO experiment for treating actual dye wastewater indicated that the COD, color and TOC of actual wastewater were decreased by 62.23%, 50.12% and 41.26% in 3 h, respectively, and the ratio of BOD5/COD was increased from 0.19 to 0.30.     

Environmental impact of a coal combustion-desulphurisation plant: abatement capacity of desulphurisation process and environmental characterisation of combustion by-products

The fate of trace elements in a combustion power plant equipped with a wet limestone flue gas desulphurisation (FGD) installation was studied in order to evaluate its emission abatement capacity. With this aim representative samples of feed coal, boiler slag, fly ash, limestone, FGD gypsum and FGD process water and wastewater were analysed for major and trace elements using the following techniques: inductively coupled plasma-mass spectrometry (ICP-MS), inductively coupled plasma-atomic emission spectrometry (ICP-AES), ion chromatography (IC), ion selective electrode (ISE) and atomic absorption spectroscopy (AAS). Mass balances were established allowing to determine the element partitioning behaviour. It was found that, together with S, Hg, Cl, F, Se and As were those elements entering in the FGD plant primarily as gaseous species. The abatement capacity of the FGD plant for such elements offered values ranged from 96% to 100% for As, Cl, F, S and Se, and about 60% for Hg. The environmental characterisation of combustion by-products (boiler slag, fly ash and FGD gypsum) were also established according to the Council Decision 2003/33/EC on waste disposal. To this end, water leaching tests (EN-12457-4) were performed, analysing the elements with environmental concern by means of the aforementioned techniques. According to the leaching behaviour of combustion by-products studied, these could be disposed of in landfills for non-hazardous wastes.     

Influence of NOx on the activity of Pd/θ-Al2O3 catalyst for methane oxidation: Alleviation of transient deactivation

Alumina supported Pd catalyst（Pd/Al₂O₃） is active for complete oxidation of methane, while often suffers transient deactivation during the cold down process. Herein, heating and cooling cycle tests between 200 and 900 °C and isothermal experiments at 650 °C were conducted to investigate the influence of NO_x on transient deactivation of Pd/θ-Al₂O₃ catalyst during the methane oxidation. It was found that the co-fed of NO alleviated transient d...     

基于循环经济理念的煤炭型老工业基地振兴的研究与分析——华丰煤矿为例

华丰煤矿就其地理位置，资源条件和社会环境而言，发展循环经济有着独特优势。按照发展循环经济的要求，充分合理的开发利用资源是当前落实科学发展观所迫切需要解决的问题，发展循环经济需要市场机制与煤矿系统的双重作用，尤其离不开煤矿系统的推进。     

Recent trends in rock dust modifications for improved dispersion and coal dust explosion mitigation

Underground coal mine explosions is perhaps the most hazardous danger in the coal mining industries. Efforts have been made to abate the coal dust explosion by applying rock dust either dry or wet. Dry dust has the best lift characteristic which efficiently quenches the flame propagation of a potential explosion. As a trade-off, undesired respirable dust particles are thereby generated imposing a severe health hazard on coal miners. Wet dusting is an alternative to dry dusting which significantly reduces the exposure to respirable dust particles. However, wet dust is subject to adverse caking issues which lead to a drastic reduction in the dispersibility of the particles. The present work summarizes the studies conducted to date regarding the surface modification of rock dust particles for the purpose of eliminating or alleviating the problems accompanying coal mine dusting applications, meanwhile improving the dispersive properties of dust particles and the ability to suppress the coal dust explosion.     

电化学间接氧化法处理H_2S气体的研究

采用填料塔对铁盐溶液吸收 H2 S的过程进行了初步研究 ,考察了气液比、填料层高度、吸收温度、Fe3+浓度、进气 H2 S浓度和 H+浓度等因素对 H2 S去除率的影响。结果表明 ,气液比、填料层高度和吸收温度对吸收效率的影响比较显著。通过正交试验选出最佳工艺条件 ,在此工艺条件下 H2 S的去除率接近 10 0 %。     

次氯酸钠氧化预处理草甘膦生产废水

利用次氯酸钠对草甘膦生产废水进行预处理，废水ｐＨ对处理效果影响不大，可将次氯酸钠直接投入到原碱性废水中，在其用量相当理论量的４０％、氧化时间为４ｈ时，草甘膦的去除率为９８％。预处理后的废水对厌氧消化过程不再产生抑制作用。     

超临界水氧化法处理含硫废水研究

研究了用超临界水氧化法（ＳＣＷＯ法）在６７３．２￣７７３．２Ｋ、２４￣３０ＭＰａ条件下处理含硫废水。结果表明,ＳＣＷＯ可将硫离子高效去除。增加反应空时、压力、氧硫比可显著提高硫的去除率。较低温度下,温度的升高对硫的去除率影响不明显;较高温度下,升高温度可显著提高硫的去除率。     

基于神经网络的煤矿底板突水预测

阐述了运用人工神经网络建立煤矿底板突水预测模型的思路与方法,并以山东国家庄煤矿为例,对该方法的合理性和准确性进行了验证．研究表明,利用人工神经网络建立非线性系统的预测模型,具有自学习、自适应、精度高等显著优点．