一株稠油降解菌的筛选及其产物乳化性能研究

稠油亦称重质原油,稠油中胶质和沥青质等大分子组分含量较高.通过以稠油为唯一碳源的摇瓶发酵和稠油平板实验,从辽河油田油水样中筛选获得一株稠油降解菌AD.对菌株AD发酵所产表面活性剂的CMC值、乳化活性、稠油降黏作用等进行了测定.结果表明,菌株AD产表面活性剂对原油具有较强的乳化、降黏作用,可耐高温和高浓度盐,适用于油藏微碱性环境,稠油降黏率最高可达81.7％,与曙光油田的地层水有较好的配伍性.     

胜坨油田原油温室气体排放特征及其影响因素

为研究油田开发过程中原油在大气条件下的碳排放特征,完善油气系统潜在温室气体排放清单,以胜利油田典型区块——胜坨油田原油为研究对象,通过改进的静态室-气相色谱及质谱法对原油在大气条件下的自然脱气(排放)过程进行模拟试验研究. 结果表明:CH₄和CO₂是胜坨油田原油溶解气中的两种主要温室气体;将模拟时间(48 h)均分为4个时段,CH₄、CO₂的主要排放阶段为0~12 h,并且其排放量远高于>12~24、>24~36和>36~48 h,其中,不同温度下CH₄、CO₂的最大排放率均出现在0~2 h. 原油在空气中暴露时间的长短及所处大气温度的高低直接影响温室气体的累积排放,CH₄、CO₂的累积排放量均随模拟试验的进行而递增;原油所处环境温度越高,累积排放量越大,3 ℃时CH₄、CO₂的累积排放量分别为12.498、15.071 g/m3,13 ℃时为20.626、21.004 g/m3,27 ℃时为31.353、26.954 g/m3. CH₄、CO₂在不同温度下的相对排放量存在差异,表现为低温(3、13 ℃)条件下CH₄排放量低于CO₂,相对高温(27 ℃)条件下表现相反. 研究显示,原油所处大气环境的温度及暴露时间是影响原油温室气体排放的重要因素.      

Transesterification of Caesalpinia eriostachys seed oil using heterogeneous and homogeneous basic catalysts

Caesalpinea eriostachys seed oil, as a source of triglycerides with potential application for biodiesel production in Mexico is introduced. Its lipid profile obtained by Gas Chromatography-Mass Spectrometry (GC-MS) revealed saturated and unsaturated glycerol esters as the constituents. Therefore, heterogeneous and homogeneous catalyzed transesterification reactions were assayed employing ZnAl hydrotalcites and KOH, as the catalysts, respectively. The transesterification reactions yielded 59% for Zn/Al(2), 79% for Zn/Al(4), and 90% for KOH, depicting typical behavior, as in biodiesel production data from literature, where Zn-Al hydrotalcites or KOH were assayed. The caloric, density, viscosity values, and fatty acid methyl esters profile from reaction products were concordant to EN 14214, suggesting C. eriostachys as a promising feedstock for biodiesel production.     

Impact of various blends of Mimusops elengi methyl esters on performance and emission characteristics of a diesel engine

The basic objective of the research work was to study the effect of various blends of Mimusops elangi methyl ester (MEME) on engine performance, combustion, and emission characteristics of a single-cylinder direct-injection compression ignition engine, running at constant speed. The raw oil was extracted from Mimusops elangi seeds through mechanical crusher. The neat MEME was obtained through transesterification process and mixed with diesel in versatile proportions of 10% of MEME (10% MEME–90% Diesel), 20% of MEME(20% MEME–80% Diesel), 30% of MEME(30% MEME–70% Diesel), 40% of MEME(40% MEME–60% Diesel), and 100% MEME on a volume basis. Their properties were validated based on ASTM standards. Experimental investigation revealed that the 20% blend resulted in 4.18%, 5.12% more prominent performance characteristics of brake thermal efficiency, brake specific energy consumption, and superior emission diminution of 5.26% of HC, 16.6% of CO, 6.2% of smoke when compared with base diesel fuel, despite marginal penalty of 5.26% of carbon dioxide and 4.8% of oxides of nitrogen emission at full load condition. Characteristics of combustion parameters like pressure inside the cylinder and rate of the heat released were superior for 20% blend of MEME at the peak load condition.     

Experimental investigation of performance and emission characteristics of diesel engine using Jatropha biodiesel with alumina nanoparticles

Biodiesels have come up as a very strong alternative for diesel fuel. Biodiesels such as Jatropha Oil Methyl Ester (JOME) are comparable in performance with that of the diesel engine. The thermal efficiency of engines fuelled with biodiesels was found lower than conventional diesel fuel but due to the bio-origin, the emission characteristics are much better. However, biodiesel increases the NOx emissions as these are rich in oxygen, hence nanoparticles are used in this experiment to curb the high temperatures and reduce the NOx formation. The experiment on naturally aspired diesel engine was conducted with four prepared test fuels other than neat diesel and neat biodiesel. The 50 and 150 of alumina nanoparticles were added separately to the pure diesel and pure Jatropha biodiesel to form the nano emulsions using ultrasonicator. The properties of nanoemulsion were evaluated using dynamic light scattering technique using zetasizer. The performance and emission characteristics of multi-cylinder diesel engine with these nanoemulsions were compared with that of neat fuels. The results showed that using nanoparticles with diesel and biodiesel can contribute in a more efficient, economical, and eco-friendly engine operation.     

胜利油田区水体中环境雌激素生态风险评估

为了评价胜利油田石油开采对水体中雌激素生态风险。首先,检测胜利油田区26个样品中盐度、总氮、总磷、余氯、COD、石油烃类物质含量6个常规水质指标,结果发现水体中总氮及COD的含量均值达到5.2mg/L及64mg/L,这表明该区域有机污染物及富营养化程度比较严重。其次,利用人雌激素受体基因酵母干粉法检测了样品中环境雌激素含量,结果分析发现不同采样点间的雌激素污染水平不同,雌激素含量与水质指标间无显著相关性。样品中雌激素含量范围0.046-0.072ng/L,均值为0.062ng/L,雌激素水平相对较低,这证实胜利油田水体存在环境雌激素生态风险值也较低。     

HSE管理绩效考核在石油钻井企业的成功应用

本文浅析了HSE管理体系起源及其在我国的运行情况,提出了HSE管理绩效考核实施原则和实施办法,同时列举了HSE管理绩效考核在长城钻探工程有限公司井下作业公司的成功应用,并指出企业实施HSE管理绩效考核应注意的事项,可为企业有效控制员工行为安全、提高员工安全意识和技能、提升企业HSE管理水平提供参考.     

扫线污油罐的危险分析及控制

针对轻质油品罐区的两个扫线污油旧罐在使用中存在的隐患,对照油罐的现行相关设计规范进行了危险性分析,提出了扫线污油罐的安全措施。     

海上石油平台消防泵细节设计

以有关规范标准为基础,结合国内海上平台消防泵设计,从细节方面对海上平台消防泵设计进行了研究讨论,主要包括海上平台消防泵性能选择、驱动时间、超压保护、最小流量保护、计量等。     

国内石油储运业现状及安全建议

分析了国内石油储运业的现状与发展趋势,提出几点建议。