生态田处理油田污水的探索与实践

生态田污水处理技术具有低投资、低能耗、低运行费用等诸多优点,结合油田所处的地理位置及实际生产情况,利用生态田天然植物的生物效能,对油田污水处理后用于植被灌溉,并且针对处理过程中存在的问题提出了工艺改造对策措施,最终实现净化污水的目的。     

光源对光催化降解甲醛效果的影响及预测模型

利用环境测试舱模拟不同光源种类和光照强度下的室内环境,以甲醛溶液的光催化降解为探针反应,分析Ce-TiO2光催化降解甲醛溶液效果与光源的关系。并且采用指数平滑法中的3次指数平滑模型,建立Ce—TiO2光催化降解甲醛溶液效果的预测模型,预测结果表明实测值与预测值误差小,预测值精确度高,这为光催化降解甲醛溶液的研究,提供了一个新的思路。     

低温结晶净化柠檬酸盐解吸贫液中硫酸根

在柠檬酸盐吸收—解吸脱硫技术中,完成循环吸收过程的吸收液由于烟气杂质催化和高温解吸变成了含低二氧化硫浓度、中高硫酸根浓度、多种有机酸共存的柠檬酸盐解吸贫液,造成吸收效率下降、SO2平衡容量严重降低,必须进行溶液净化,特别是净化硫酸根。针对这一问题,实验室采用低温结晶法净化柠檬酸盐脱硫解吸贫液模拟液,通过对溶液中硫酸根浓度分析,研究了不同反应时间、温度、初始硫酸根浓度、柠檬酸根总浓度和溶液p H对硫酸根去除效率的影响。结果表明,硫酸根去除率与冷冻温度和溶液p H有关。在柠檬酸根总浓度1.5 mol/L,初始硫酸根浓度40 g/L,冷冻温度3℃,p H 4.5的条件下,可将硫酸根净化至16.9 g/L。     

纳米腐植酸基复合树脂的制备及其对Ni~(2+)和Cd~(2+)的吸附

采用水溶液聚合法,以丙烯酸、丙烯酰胺及改性蒙脱土为原料,纳米腐植酸为基体,N,N’-亚甲基双丙烯酰胺为交联剂,过二硫酸钾为引发剂,制备了丙烯酸-蒙脱土-丙烯酰胺/纳米腐植酸复合树脂(简称复合树脂)。考察了溶液pH、吸附时间、吸附温度、初始离子浓度等因素对复合树脂分别吸附Ni~(2+)和Cd~(2+)的影响。实验结果表明:在吸附温度35℃、吸附时间90 min、溶液pH为7、初始Ni~(2+)和Cd~(2+)的浓度分别为0.02 mol/L、复合树脂加入量16.7 g/L的条件下,Ni~(2+)和Cd~(2+)的吸附量分别为383.02 mg/g和359.27 mg/g;复合树脂吸附Ni~(2+)和Cd~(2+)的吸附等温线均满足Langmuir等温吸附方程;吸附过程均符合准二级动力学方程;复合树脂重复使用6次,其对Ni~(2+)和Cd~(2+)的吸附量分别降低了17.1%和9.3%。     

Dynamic changes of rhizosphere properties and antioxidant enzyme responses of wheat plants (Triticum aestivum L.) grown in mercury-contaminated soils

A pot experiment was conducted to investigate the dynamic changes in the rhizosphere properties and antioxidant enzyme responses of wheat plants (Triticum aestivum L.) grown in three levels of Hg-contaminated soils. The concentrations of soluble Hg and dissolved organic carbon (DOC) in the rhizosphere soil solutions of the wheat plants were characterised by the sequence before sowing > trefoil stage > stooling stage, whereas the soil solution pH was found to follow an opposite distribution pattern. The activities of antioxidant enzymes in wheat plants under Hg stress were substantially altered. Greater superoxide dismutase (SOD), catalase (CAT) and ascorbate peroxidase (APX) activities were observed in the wheat plants grown in a highly polluted soil than in a slightly polluted soil (with increases of 11–27% at the trefoil stage and 26–70% at the stooling stage); however, increasing concentrations of Hg up to seriously polluted level led to reduced enzyme activities. The present results suggest that wheat plants could positively adapt to environmental Hg stress, with rhizosphere acidification, the enhancement of DOC production and greater antioxidant enzyme activities perhaps being three important mechanisms involved in the metal uptake/tolerance in the rhizospheres of wheat plants grown in Hg-contaminated soils.     

双极膜电渗析技术处理稀土钠皂化废水回收液

采用双极膜电渗析（BMED）技术处理稀土钠皂化废水回收液,使回收液中的氯化钠转化为氢氧化钠溶液（简称碱）和盐酸（简称酸）而回用。考察了电流和初始酸碱浓度对膜对电压、回收的酸和碱的浓度、电流效率和能耗的影响。实验结果表明,随电流的增大,膜对电压升高,回收的酸和碱的浓度也明显增加,电流效率和能耗均提高;随初始酸碱浓度的增加,膜对电压、电流效率和能耗均下降,回收的酸和碱的浓度逐渐增加;综合考虑各方面因素并侧重考虑回收的酸和碱的浓度,本实验适宜的工艺条件为：电流25 A、初始酸碱浓度0.3 mol/L。在此条件下反应150 min,回收酸的浓度为1.24 mol/L,回收碱的浓度为1.55 mol/L。     

适宜处理分散性生活污水的人工湿地除磷填料的筛选及改性

为提高人工湿地除磷效能,从沸石、陶粒、萤石、膨胀蛭石、石灰石、麦饭石、火山岩、牡蛎壳、钢渣和废砖块这10种具有较高磷素饱和吸附量的填料中,筛选出钢渣、沸石和石灰石3种适宜处理分散性生活污水的人工湿地填料,并分别使用不同浓度梯度的酸(碱)、盐对3种填料进行改性,以增强其除磷能力。研究结果表明,钢渣、沸石和石灰石分别经2 mol/L AlCl3、2 mol/L NaOH及2 mol/L AlCl3、0.5 mol/L AlCl3溶液改性后,磷素吸附量达到最高值(0.272、0.0801和0.351 mg/g),而双常数方程能更好地描述优选填料对生活污水中磷的吸附动力学过程,综合考虑填料的吸附效果、成本及来源,改性石灰石是人工湿地处理分散性生活污水时较为理想的除磷填料;此外,填料经铝改后,氮磷吸附效果普遍优于其他改性条件,且Al-P有利于植物直接吸收利用,含铝废水来源广泛,故利用铝改液处理人工湿地填料具有较高的应用推广价值。     

纳米SiO2在含阴离子表面活性剂低浊水处理中的应用

在含有阴离子表面活性剂-十二烷基硫酸钠(SDS)的6 NTU高岭土悬浊液中,改变SDS的浓度,投加纳米SiO2与聚合铝PAC进行动态混凝实验与静沉实验,借助图像分析技术与分形理论,探讨了纳米SiO2与PAC处理含SDS低浊水的作用机理、絮凝效果与形态学特征.结果表明:①纳米SiO2与SDS使高岭土粒子表面负电性增强.纳米SiO2的絮凝机理以吸附架桥为主.②纳米SiO2对SDS的去除效果优于PAC.SDS浓度越高,去除效果越显著.但纳米SiO2对无机高岭土粒子的处理能力不如PAC,PAC絮凝后的上清液浊度低.当SDS浓度增至10 mg/L时,纳米SiO2对SDS的去除率高,而PAC对SDS的絮凝能力弱,PAC对无机颗粒的去除效果也下降.③助凝剂纳米SiO2较强的吸附活性能加快PAC絮体成长为结构密实的RLCA构型,分维值高,絮凝效果好.     

Reducing commercial fishing deck hazards with engineering solutions for winch design

INTRODUCTION: The majority (67%) of hospitalized injuries among Alaska commercial fishermen are associated with deck machinery. This paper describes the "Prevention Through Design" process to mitigate one serious machinery entanglement hazard posed by a capstan deck winch. METHODS: After observing that the capstan winch provides no entanglement protection and the hydraulic controls are usually out of reach of the entangled person, NIOSH personnel met with fishermen and winch manufacturers to discuss various design solutions to mitigate these hazards. RESULTS: An emergency-stop ("e-stop") system was developed that incorporated a momentary contact button that when pushed, switches a safety-relay that de-energizes the solenoid of an electro-hydraulic valve stopping the rotating winch. The vessel owners that had the e-stop installed enthusiastically recommend it to other fishermen. NIOSH entered into a Proprietary Technology Licensing Agreement with a company to develop the system for commercial use. CONCLUSIONS: This is an example of a practical engineering control that effectively protects workers from a hazardous piece of equipment by preventing injuries due to entanglement. This solution could reduce these types of debilitating injuries and fatalities in this industry.     

污泥停留时间对污泥减量化的影响

污泥停留时间不但决定系统剩余污泥的排放量,还直接影响到污泥的絮凝沉降性能及活性等。由实验可知:污泥停留时间延长,可导致微生物缺乏营养,减少污泥产生量;从而导致SVI升高,污泥负荷降低。因此,延长污泥停留时间减少剩余污泥量,可以节省尿素和KH2PO4投入量,从经济上节省运行成本。