基于锥形量热仪的几种防火布燃烧性能研究

生产企业常在电缆或者贵重高危机器处设置防火布来保护生产设备设施的消防安全,选取五种常用的防火布:石棉纤维防火布、陶瓷纤维防火布、硅胶防火布、涂胶防火布、碳素纤维防火布,通过锥形量热仪实验研究不同辐射强度对防火布燃烧性能的影响。结果表明:点燃时间的均方根倒数与辐射强度之间呈现线性关系;在35 kW/m~2辐射强度工况下,碳素纤维防火布的热释放速率最大,达到272.59 kW/m~2,有效燃烧热的峰值也最大,达到529.52 kJ/g;综合比较各样品的燃烧性能,防火能力强弱顺序为:硅胶防火布石棉纤维防火布陶瓷纤维防火布碳素纤维防火布涂胶防火布。     

密度对聚氨酯软泡收缩及燃烧行为的影响

采用锥形量热仪研究不同密度聚氨酯软泡(FPUF)的燃烧行为,并根据摄像、体视显微镜所观察的样品形体及泡孔结构的变化来研究火灾条件下FPUF的收缩特性。研究结果表明,收缩是表层泡孔受热发生热解生成焦油所致的泡孔塌缩现象,焦油层下方泡孔结构基本没有变化;FPUF密度越大着火前的收缩速率越小,同一时刻表层泡孔热解生成的焦油层越薄。FPUF的着火燃烧可分为受热收缩、燃烧收缩和池火燃烧三个阶段。中高密度样品HRR曲线先出现平台后出现峰值,分别对应于燃烧收缩和池火阶段,且密度越大HRR曲线的平台越低、峰值越高,燃烧收缩阶段的FIGRA越小,而池火燃烧阶段的FIGRA越大。着火前的快速收缩导致低密度样品的HRR曲线不出现平台只呈现单峰。     

Importance of accounting for the piping system and boundary conditions in determining the maximum surge pressure following heat-exchanger tube-rupture

Shell-tube type heat exchangers are often used to exchange heat between a high-pressure fluid and a low-pressure fluid, and the pressure difference between the two fluids could be significantly high. If the difference in the design pressure between the low-pressure (LP) and high-pressure sides is greater than that covered by American Petroleum Institute (API 520 and 521) 10/13^th rule, dynamic analysis is required to ascertain that the maximum surge pressure that could be reached does not compromise the integrity of the LP side of the exchanger. API guidelines also notes that attention should also be given not only to the shell-side of the heat exchanger under evaluation, but also to the “upstream and downstream systems” This paper offers further insight into the importance of including the surrounding piping systems around the subject heat-exchanger where a tube-rupture scenario is considered, and also directs attention to the importance of correctly specifying the appropriate boundary conditions (B.C.) at the far ends of both the upstream and downstream piping systems. It demonstrates the effects of specifying different B.C. on the maximum pressure surge via a case study of a hot separator vapour condenser in a bitumen hydrotreating unit, where the process fluid on the tube-side is a vapour–liquid mixture at 9660 kPa(g). The vapour mass fraction of the process fluid is approximately 0.5, and is mostly hydrogen. The fluid on the LP side is cooling water connected to the plant supply and return cooling systems as well as another adjacent low pressure condenser. The design pressure for the cooling water piping system and the adjacent condenser is 1380 kPa(g).     

热脱附-气相色谱法测定环境空气中芳烃和卤代烃

建立了热脱附-气相色谱法测定环境空气中9种芳烃和卤代烃方法。阐述了样品管制备、采样袋预处理、现场采样和实验富集等过程。采用保留时间定性、外标法定量。进行了自动热脱附仪的吸附和解吸效率的试验,各组分的吸附效率均在97%以上,解吸效率达98 9%。最低检出质量浓度氯乙烯为0 0003mg/m3、1,2-二氯乙烷和1,2-二氯丙烷为0 0002mg/m3、苯、甲苯、乙苯、对二甲苯、苯乙烯和邻二甲苯均为0 0001mg/m3。试图以不更换TenaxTA吸附剂标准冷阱来测定齐鲁石化环境空气中特征污染物乙烯,由于冷阱对乙烯的二级吸附未能很好地解决,试验效果不理想,有待进一步研究。     

沈阳市城市污水中的热能回收及利用研究

以北部污水处理厂为例,结合沈阳城市污水源热泵系统规划思路,对沈阳市7座污水处理厂及污水特征参数进行了论述及推算。通过调查分析供暖企业的燃煤现状及供暖情况,推算出了采用污水供暖取代燃j采供暖后的环境效益及经济效益,提出了沈阳建立污水源热泵系统的对策及建议。     

Suppression of premixed flames with inert particles

Dispersal of inert particles on a flame front is one of the techniques employed to suppress explosions. The current study investigates the influence of micron-sized (75–90 μm) inert (sand) particles on the laminar burning velocity of methane-air premixtures of different equivalence ratios (0.9–1.2) and reactant temperatures (297, 350, 400 K) using a Bunsen-burner type experimental apparatus. When an inert particle interacts with the flame zone, it extracts energy from the flame, thereby acting like a heat sink and hence reducing the flame temperature. Results show that for sand particle size in the range of 75–90 μm, a concentration of 380–520 g/m³ is necessary for extinction of a methane-air flame at ambient temperature. An increase in reactant temperature reduces the heat-sink effect necessitating a higher concentration of sand to extinguish the flame. A mathematical model is developed to generalize the results and make them applicable to a wide range of parameters.     

污水处理厂污泥的综合利用

利用普通工业锅炉将消化污泥泥饼与煤制成混合燃料进行焚烧处理 ,提供了混合燃料组份分析及实际运行试验情况 ,得出了切实合理可行的泥煤最佳配比 ,并就产生的社会经济效益和环境效益进行了评估。     

一种新型的环保节能采暖系统——地源热泵空调系统

本文简介了地源热泵采暖系统的结构、技术特点及原理,以及在国内外的使用情况和应用现状,该系统设备的合理配制,安全保证问题,经济性分析,环保,节能效果。     

热泵机组的噪声影响及治理

风冷式热泵噪声对周围环境产生一定的影响，已成为城市中带普遍性的固定噪声源，在调查分析热泵噪声及其传播特性的基础上，以两个实例剖析了热泵机组噪声治理中，距离衰减低，排风余压小（50Pa)，安装条件限制等技术措施，结果表明，采用全封闭的隔声消声装置，能把热泵的噪声传播影响降低20dB（A）左右。     

热应激与人的行为特性

在许多作业环境中，人们都要受到热应激的作用，热应激不仅能引起不良的生理反应，还会对人的行为特性有不利的影响。人们往往注重于热应激引起的生理反应及生理耐受极限，忽视了它对人的行为特征的影响。本文侧重论述热应激对人的行为影响，以加深了解热应激的作用，为存在热应激的人－机系统设计及改善人－机关系综合措施提供理论依据。