铂载钴钼二元硫化物对H_2S电催化活性研究

为考察溶胶凝胶法制备的Co-Mo二元硫化物对H_2S气体的电催化活性,通过循环伏安法和Tafel曲线分析对铂载不同Co、Mo掺杂比的电催化剂进行表征.结果表明,不同阳极电催化剂交换电流密度J_0由大到小依次为,铂载n(Co):n(Mo)=2:3、铂载n(Co):n(Mo)=2:1、铂载n(Co):n(Mo)=1:1和铂,即铂载n(Co):n(Mo)=2:3阳极电催化剂具有较好的活性,这与循环伏安曲线测试结果一致.电解质溶液pH值为6～7时,随着温度的升高铂载n(co):n(Mo)=2:3阳极电催化剂活性呈现上升的趋势.优化后的Co、Mo掺杂原子比约为0.66,此类电催化剂在操作温度80℃下,交换电流密度为1.318mA/cm~2,表观活化焙值为616.6 kJ/mol .研究表明,铂载钴钼二元硫化物适合作为低温H_2S燃料电池阳极电催化剂,其中Co、Mo掺杂比对电催化活性影响较大.     

高气速间歇式生物过滤去除高负荷H2S

采用生物过滤法,以鸡粪堆肥和PE混合物为填料,在高气速条件下间歇式处理高负荷H2S废气。空床停留时间为20、15、10、6.7和5 s时,入口浓度3 000 mg/m3下的平均去除率分别为100%、100%、96.5%、89.2%和90.5%。高气速EBRT为5 s时,高入口负荷2 147 g/(m3.h)时的去除负荷为2 023 g/(m3.h),去除率达94%。采用Michaelis-Ment-en模型进行生物降解宏观动力学研究,其中Ks为550 mg/m3,Vm为6.8×104g/(m3.d)。结果表明,在实验温度17～24℃,湿度30%～50%下,生物过滤法间歇式处理高气速高负荷H2S的去除性能好。     

不同粒径零价铁（ZVI）对污水污泥H_2S和CH_4释放速率的影响

考察了不同粒径零价铁（ZVI）,包括200目普通铁粉（200m-ZVI）、800目超细铁粉（800m-ZVI）和纳米铁粉（nZVI,粒径=20 nm）,对污水污泥的硫化氢和甲烷释放速率的影响。研究发现：（1）在22 d内,添加0.1%的200m-ZVI使污泥的硫化氢释放速率提高48.0%,而添加0.1%的800-ZVI和nZVI,则使污泥的硫化氢释放速率分别降低33.1%和77.1%;（2）不同粒径ZVI均可以提高污泥沼气中的甲烷浓度,且依次为nZVI〉800m-ZVI〉200m-ZVI;（3）在23 d内,添加0.1%的200m-ZVI和nZVI使污泥的甲烷累计产生量分别提高了15.5%和40.6%,而添加0.1%800m-ZVI则使甲烷产生量降低了12.5%。nZVI可以有效控制污泥的硫化氢释放,并显著提升污泥在厌氧发酵过程的产甲烷速率。     

Hydrogen Sulfide Gas Treatment by a Chemical‐Biological Process: Chemical Absorption and Biological Oxidation Steps

In order to remove high concentrations of hydrogen sulfide (H₂S) gas from anaerobic wastewater treatments in livestock farming, a novel process was evaluated for H₂S gas abatement involving the combination of chemical absorption and biological oxidation processes. In this study, the extensive experiments evaluating the removal efficiency, capacity, and removal characteristics of H₂S gas by the chemical absorption reactor were conducted in a continuous operation. In addition, the effects of initial Fe^2 + concentrations, pH, and glucose concentrations on Fe^2 + oxidation by Thiobacillus ferrooxidans CP9 were also examined. The results showed that the chemical process exhibited high removal efficiencies with H₂S concentrations up to 300 ppm, and nearly no acclimation time was required. The limitation of mass‐transfer was verified as the rate‐determining step in the chemical reaction through model validation. The Fe^2 + production rate was clearly affected by the inlet gas concentration as well as flow rate and a prediction equation of ferrous production was established. The optimal operating conditions for the biological oxidation process were below pH 2.3 and 35°C in which more than 90% Fe^3 + formation ratio was achieved. Interestingly, the optimal glucose concentration in the medium was 0.1%, which favored Fe^2 + oxidation and the growth of T. ferrooxidans CP9.     

硫化物水样的稳定性研究

对硫化钠水样的制备及其稳定性进行了研究和讨论,找到一种长期稳定保存硫化钠标准溶液及硫化物标准样品的有效方法。     

非热强介质等离子体反应器用于臭味气体的分解

对非热强介质等离子体反应器用于臭味气体———氨、硫化氢、甲基硫醇的分解进行了试验研究。研究了施加电压、停留时间、初始浓度对臭味气体分解率的影响 ,并对氨的分解产物进行了初步分析。结果表明 ,在这 3种气体的初始体积分数分别为 2 5× 10 -6和 5 0× 10 -6的条件下 ,当施加电压为 16kV、停留时间为 0 .2 3s时 ,氨的分解率达到 97%以上 ;当停留时间为0 .2 3s时 ,硫化氢和甲基硫醇分别在 10kV和 8kV时达到 10 0 %的分解。     

石脑油罐硫铁化合物自燃原因分析

对一起石脑油罐硫化铁化合物自燃事故的经过和原因进行了分析 ,推断出发生在石脑油罐硫铁化合物自燃并非为FeS自燃 ,并提出了预防同类事故的防范措施。     

EMMC process for combined removal of organics, nitrogen and an odor producing substance

In order to improve the process performance regarding the removal of organics, nitrogen, and an odor-causing compound (sulfide) contained in domestic wastewater, an entrapped-mixed-microbial cell (EMMC) with and without humic substances for both fixed and moving carrier reactors and conventional suspended growth culture (i.e. conventional activated sludge process) were investigated simultaneously. Both synthetic (simulated to the organics concentration of general domestic sewage) and actual domestic wastewater were investigated under operational conditions of 12 h of hydraulic retention time (HRT) with 1 h of aeration and 1 h of non-aeration, and 6 h of HRT with continuous aeration, at a room temperature of 25 +/- 2 degrees C. It was found that entrapping humic substances in the EMMC carriers had no impact on the removal of organics, nitrogen, and the odor-producing compound. Additionally, the performance of the EMMC moving carrier system for the removal of these pollutants is similar to that of the EMMC fixed carrier system. In general, the EMMC associated systems which provide high solids retention time achieve a better removal of chemical oxygen demand (COD), nitrogen, and the odor-producing substance than the suspended growth system for both HRTs of 6 h (continuous aeration) and 12 h (1 h of aeration and 1 h of non-aeration). Both the fixed and moving carrier EMMC processes, therefore, have the potential for improvement or replacement of the existing conventional activated sludge process with regard to improving the effluent qualities (such as COD, nitrogen and odor-producing compound) for reuse/disposal.     

用改性活性碳纤维去除CO2原料气中的H2S

采用固定床动态吸附实验，用改性活性碳纤维（ACF）吸附去除CO2原料气中的H2S。通过改变改性剂种类、反应温度和原料气中CO2浓度，找出用改性ACF去除CO2原料气中H2S的规律。实验结果表明：常温下，可用NaON改性的ACF来消除CO2的酸性对去除H2S的不利影响；随着反应温度的升高，CO2与ACF形成的C（O＊）中间产物增多，CO2的存在有利于改性ACF去除H2S；而当反应温度过高时，CO2与ACF形成的C（O＊）中间产物发生分解，导致ACF碳化，不利于H2S的吸附去除。     

多因素耦合条件下硫化矿自燃神经网络动态预测模型研究

硫化矿石自燃是多种因素、多场耦合综合作用的结果,是一典型的非线性问题。笔者应用人工神经网络技术,以Matlab软件为平台,通过现场调查和理论分析,建立了矿石含硫量、通风强度、环境温度3因素与硫化矿石自燃之间的预测模型;通过数据样本学习与部分现场监测数据相结合进行模拟,研究表明预测数据与实测结果基本吻合,误差控制在10%以内,取得了较好的效果。该研究为预防硫化矿石自燃提供一个新的思路和方法,具有一定的理论意义和应用价值。