EGSB反应器处理焦化废水的颗粒污泥反应动力学研究

为了对处理实际焦化废水微氧EGSB反应器污染物去除机理进行研究,建立了处理实际焦化废水微氧EGSB反应器内污染物质降解动力学模型,考察EGSB反应器启动和稳定运行阶段不同运行条件时COD去除效果,并分析动力学参数的变化。研究确定了处理实际焦化废水(进水COD 2 000 mg/L左右)微氧EGSB反应器在启动和稳定运行阶段所适用的基质降解模型,动力学常数vmax、KI、KS、vmax/KS、KS/KI分别为7.34×10-3h-1、197.76 mg/L、19.53 mg/L、3.7×10-4L/(h·mg)、0.10和2.4×10-2h-1、66.64 mg/L、44.07 mg/L、5.4×10-4L/(h·mg)、0.66;微氧EGSB反应器内颗粒污泥能够逐渐适应并高效降解焦化废水中污染物质,焦化废水中毒性污染物质对颗粒污泥的抑制程度是由KS/KI决定的,KS/KI越大,抑制程度越弱,处理实际焦化废水EGSB反应器启动和稳定运行阶段的KS/KI分别为0.04~0.1和0.66~0.74;液体上升流速Vup的提高能够明显提高最大比基质降解速率vmax,降低半饱和常数KS和抑制常数KI,最终强化微氧EGSB反应器的运行效果,稳定运行阶段COD去除率高达92.7%。     

Production and the application of anaerobic granular sludge produced by landfill

Sludge granulation is considered to be the most critical parameter governing successful operation of an upflow anaerobic sludge blanket and expanded granular sludge bed (EGSB) reactors. Pre-granulated seeding sludge could greatly reduce the required start-up time. Two lab-scale and a pilot-scale EGSB reactors were operated to treat Shaoxing Wastewater Treatment Plant containing wastewater from real engineering printing and dyeing with high pH and sulfate concentration. The microbiological structure and the particle size distribution in aerobic excess sludge, sanitary landfill sludge digested for one year, and the granular sludge of EGSB reactor after 400 d of operation were analyzed through scanning electron microscopy (SEM) and sieves. The lab-scale EGSB reactor seeded with anaerobic sludge after digestion for one year in landfill showed obviously better total chemical oxygen demand (TCOD) removal efficiency than one seeded with aerobic excess sludge after cation polyacrylamide flocculation-concentration and dehydration. The TCOD removed was 470.8 mg/L in pilot scale EGSB reactor at short hydraulic retention time of 15 h. SEM of sludge granules showed that the microbiological structure of the sludge from different sources showed some differences. SEM demonstrated that Methanobacterium sp. was present in the granules of pilot-scale EGSB and the granular sludge produced by landfill contained a mixture of anaerobic/anoxic organisms in abundance. The particle size distribution in EGSB demonstrated that using anaerobic granular sludge produced by sanitary landfill as the seeding granular sludge was feasible.     

好氧颗粒污泥处理制糖工业废水厌氧出水的除磷特性研究

制糖工业废水经厌氧生物处理后,COD大幅下降,但是出水中N、P含量仍然较高,严重破坏水体生态平衡.利用好氧颗粒污泥对制糖工业废水的厌氧出水进行脱氮除磷处理,讨论了其除磷过程.经复合底物(乙酸盐、丙酸盐、丁酸盐)培养的好氧颗粒污泥直径1.7 mm,SVI为38.43 mL.g-1,TP去除率达90.9%,出水磷含量仅为1.3 mg.L-1,单位COD释磷率为0.571,厌氧条件下磷的释放速率达到5.73 mg.(g.h)-1,好氧颗粒污泥表现出较好的沉淀性能和较高的除磷活性.由于底物中丙酸盐、丁酸盐含量增加,使得聚磷菌在反硝化过程中NO3--N的利用率增加,即消耗单位质量的NO3--N可以吸收更多的磷.好氧颗粒污泥及其胞外聚合物中P元素的含量与其中Mg、Ca、Fe元素的含量表现出很高的相关性,胞外聚合物对P的吸附使得体系除磷能力进一步增强.通过对污泥反硝化除磷的研究发现,反硝化聚磷菌占总聚磷菌的61.9%,其吸磷量与消耗硝酸盐的比值[m(P)/m(NO3--N)]为1.14.     

Effect of wastewater COD/N ratio on aerobic nitrifying sludge granulation and microbial population shift

The effect of COD/N ratio on the granulation process and microbial population succession was investigated. Four identical sequencing batch reactors, R1, R2, R3 and R4, were operated with various initial COD/N ratios ranging from 0/200 to 800/200 (m/m). Ethanol was fed as the source of COD. Aerobic granules were successfully cultivated in R2 and R3, operating with the COD/N ratio of 200/200 and 400/200, respectively. Scanning electron microscope observations indicated that short rod-shaped and spherical bacteria were dominant in R2, while granules produced in R3 were surrounded with a large amount of filamentous bacteria. The average specific nitritation rate in R2 and R3 were 0.019 and 0.008 mg N/(mg MLVSS.hr), respectively. Fluorescence in situ hybridization results demonstrated that nitrifying bacteria population was enriched remarkably in R2. It indicated that nitrification ability and nitrifying bacteria population were enriched remarkably at low COD/N ratio. However, no granules were formed in R1 and R4 which might attribute to either limited or excessive extracellular polymeric substances production. This study contributed to a better understanding of the role of COD/N ratio in nitrifying sludge granulation.     

Biodegradation of p-cresol by aerobic granules in sequencing batch reactor

The cultivation of aerobic granules in sequencing batch reactor for the biodegradation of p-cresol was studied. The reactor was started with 100 mg/L of p-cresol. Aerobic granules first appeared within one month of start up. The granules were large and strong and had a compact structure. The diameter of stable granules was in the range of 1-5 mm. The integrity coefficient and granules density was found to be 96% and 1046 kg/m³, respectively. The settling velocity of granules was found to be in the range of 2× 10^-2-6× 10^-2 m/sec. The aerobic granules were able to degrade p-cresol upto 800 mg/L at a removal efficiency of 88%. Specific p-cresol degradation rate in aerobic granules followed Haldane model for substrate inhibition. High specific p-cresol degradation rate up to 0.96 g p-cresol/(g VSS. day) were sustained upto p-cresol concentration of 400 mg/L. Higher removal efficiency, good settling characteristics of aerobic granules, makes sequencing batch reactor suitable for enhancing the microorganism potential for biodegradation of inhibitory compounds.     

丝状菌污泥致密过程的强化条件研究

利用强化条件促使丝状菌污泥致密,是控制丝状菌污泥膨胀的一种新途径.分别采用提高溶解氧、加大表面流体流速、增加进水钙离子浓度、延长饥饿时间等方法从污泥的沉降性能方面探讨了丝状菌污泥在何时致密及怎样致密等问题.结果表明,加大表面气体流速能够短期内改善污泥的沉降性能,并且形成丝状菌颗粒污泥,污泥的SVI从膨胀时的800 mL/g降低为350 mL/g,但长期作用不明显,SVI在保持了一段时间较低值后,再次升高到800 mL/g以上.增加进水钙离子浓度能够通过形成簇状污泥群落来提高污泥的沉降性能,SVI值逐渐降低到300 mL/g,但是没有形成丝状菌颗粒.提高溶解氧和延长曝气时间在改善污泥沉降性能和丝状菌颗粒化两方面皆无明显效果,污泥的SVI并没有降低.另外,通过研究网眼椭圆度与污泥SVI的关系,发现具有高椭圆度(椭圆度O约为1.5)的成簇生长丝状菌菌群,能够改善污泥沉降性能.浸泡实验发现酸性条件对菌丝的凝聚具有破坏作用,碱性条件和二价阳离子对其影响不显著.     

不同磷浓度下生物除磷颗粒系统的COD需求

本试验采用SBR反应器,接种成熟的生物除磷颗粒,通过分阶段改变进水中总磷(TP)和COD浓度,研究了不同磷浓度条件下COD负荷对生物除磷颗粒系统的影响,得出不同磷浓度下生物除磷颗粒系统具有良好性能所需最低COD浓度.结果表明,进水TP浓度为10 mg·L-1时,生物除磷颗粒系统维持良好性能所需最低COD浓度为175 mg·L-1,出水TP浓度在0.5mg·L-1以下,颗粒粒径和SVI分别为1 020μm和36 m L·g-1,PN和PS含量(以MLSS计)分别为78 mg·g~(-1)和39 mg·g~(-1),PN/PS较低,颗粒具有较好的结构和性能.进水TP浓度为6 mg·L-1时,生物除磷颗粒系统良好除磷性能所需最低COD浓度为150 mg·L-1,出水TP浓度在0.3 mg·L-1以下,颗粒粒径和SVI分别为960μm和35 m L·g-1,PN和PS含量分别为75 mg·g~(-1)和35 mg·g~(-1),PN/PS较低,颗粒具有较好的结构和性能.整个运行过程中,COD去除率在83%以上,出水COD浓度在25mg·L-1以下.在不同磷浓度条件下,随着进水COD浓度降低,微生物分泌PN和PS含量均减少,PN/PS增大,颗粒粒径减小,SVI增加,颗粒的结构和性能恶化.     

灭螺植物资源的开发利用研究

利用我国灭螺植物资源的优势 ,对32种药用植物[1]进行了灭螺实验 ,并从中筛选出5种对水陆两栖型钉螺(Oncomelaniahupensis)毒杀作用强烈、资源丰富、对环境污染较小的植物。研制了植物颗粒剂和植物粉剂两种灭螺剂型用于灭螺实验。实验结果表明 :植物颗粒灭螺剂对钉螺有强烈的毒杀作用 ,钉螺取食颗粒剂后24h死亡率分别达84 8%～100 % ,其毒杀效果明显优于相同植物的其它灭螺方法 ,对钉螺致死时间比1×10-3g/l氯硝柳胺化学灭螺剂提前12～24h。与其他植物灭螺方法比较 ,具有应用广泛、简便实用的特点 ,为利用植物资源进行灭螺提供了一种新的方法。     

水源水生物处理工艺启动中氨氮的去除

通过沉淀槽与生化槽串联的试验系统，分析了微污染水源水生物接触氧化处理工艺启动过程氨氮和亚硝酸盐氮的变化规律。研究结果表明，在无暴气条件下和曝气条件下，填料上硝酸盐细菌的生长均依赖于亚硝酸盐细菌转化氨氮为亚硝酸盐氮的过程。启动中氨氮去除效果趋于稳定的过程是两类硝化细菌在生长速率和转化能力上趋于稳定的过程。提供生化槽充足的曝光气量是保证填料上硝化细菌稳定生长，顺利完全启动过程的必要条件。     

硝化细菌的固定化研究

通过对呼吸速率的测定，比较了3种不同的硝化细菌包埋方法。实验结果表明，海藻酸钠包埋法最佳。考察了海藻酸钠法固定的硝化细菌与游离的硝化细菌在不同温度下硝化速率的大小，发现固定化的硝化细菌比游离的硝化速率高，表明其具有抗低温能力的特点。通过对富营养化水体进行的降解试验表明，所得结果具有一致性。