混凝-MBR组合技术净化洗车废水试验研究

研究混凝-MBR组合技术净化洗车废水,首先对该技术净化CODcr、UV254、NH3 -N和浊度的效果进行了考察,实验结果表明,当废水温度大于22℃时、溶解氧浓度大于4.8 mg/L时、pH值在6到8之间的条件下,该组合技术对CODcr、NH3 -N和浊度的净化效果较好,平均净化率分别达到90.2%、96.4%和98%以上,高于传统MBR技术和常规技术,出水CODcr约为20 mg/L,NH3 -N基本在0.7 mg/L以下,浊度也小于0.5NTU,水质优于中国建设部生活杂用水水质标准( CJ25.1-89).     

PVDF超滤膜进行聚乙二醇甲基丙烯酸甲酯 (PEGMA)紫外光照射接枝的膜面表征与抗污染分析

本文采用紫外光照射接枝的方法将聚乙二醇甲基丙烯酸甲酯(PEGMA)亲水单体接枝在疏水性聚偏氟乙烯(PVDF)超滤膜表面,改善PVDF膜的亲水性能.实验中以N,N-亚甲基双丙烯酰胺(MBAA)为交联剂作为对比,发现添加MBAA可以减少PEG接枝层的溶胀性.本实验研究不同改性条件对膜性能的影响,利用表面接触角(CA)、红外光谱分析(ATR-IR)、扫描电镜(SEM)等手段表征膜表面特征,同时研究了改性膜对乳化油和牛血清蛋白溶液分离效率和抗污染能力.实验结果表明,经改性后膜亲水性明显提高,对污染物的截留效果和抗污染能力均有所提高.     

Investigation on removal pathways of Di 2-ethyl hexyl phthalate from synthetic municipal wastewater using a submerged membrane bioreactor

Highly hydrophobic Di 2-ethyl hexyl phthalate (DEHP) is one of the most prevalent plasticizers in wastewaters. Since its half-life in biological treatment is around 25 days, it can be used as an efficiency indicator of wastewater treatment plant for the removal of hydrophobic emerging contaminants. In this study, the performance of submerged membrane bioreactor was monitored to understand the effect of DEHP on the growth of aerobic microorganisms. The data showed that the chemical oxygen demand (COD) and ammonia concentration were detected below 10 and 1.0 mg/L, respectively for operating conditions of hydraulic retention time (HRT) = 4 and 6 hr, sludge retention time (SRT) = 140 day and sludge concentration between 11.5 and 15.8 g volatile solid (VS)/L. The removal efficiency of DEHP under these conditions was higher and ranged between 91% and 98%. Results also showed that the removal efficiency of DEHP in biological treatment depended on the concentration of sludge, as adsorption is the main mechanism of its removal. For the submerged membrane bioreactor, the pore size is the pivotal factor for DEHP removal, since it determines the amount of soluble microbial products coming out of the process. Highly assimilated microorganisms increase the biodegradation rate, as 74% of inlet DEHP was biodegraded; however, the concentration of DEHP inside sludge was beyond the discharge limit. Understanding the fate of DEHP in membrane bioreactor, which is one of the most promising and futuristic treatment process could provide replacement for conventional processes to satisfy the future stricter regulations on emerging contaminants.     

超滤-反渗透集成膜技术深度处理酒精废水

采用超滤-反渗透集成膜技术对酒精废水二级生化处理出水进行深度处理,考察了不同超滤膜对废水的预处理性能,研究了超滤-反渗透集成膜技术对废水污染物的去除效果,并探索了不同清洗方式对反渗透膜通量恢复的影响。试验结果表明:超滤能有效地去除废水浊度和大分子有机物,为反渗透提供良好的进水水质;超滤-反渗透膜系统产水浊度、硬度、总铁均小于0.1 NTU、0.03 mmol/L和0.03 mg/L,电导率处于60~120μS/cm之间,可回用作锅炉补充水;酸洗+碱洗组合清洗方式能有效恢复反渗透膜通量,其废水膜通量可恢复为新膜废水通量的93.75%。     

膜生物反应器中膜污染机理和控制研究新进展

膜生物反应器(MBR)相比于传统活性污泥法具有出水水质好、设备占地面积小、剩余污泥产率低和便于自动控制等诸多优点,在污水处理和回用方面极具发展前景。然而膜污染是制约MBR广泛应用的最大障碍。文章着眼于总结MBR中膜污染机理和控制的研究新进展。介绍了MBR中膜污染的分类、污染机理和膜污染影响因素的研究概况,在此基础上,综述了MBR膜污染控制方法方面的进展,并对MBR中的膜污染机理和控制的研究发展方向做了展望。     

生物铁强化膜生物反应器处理印染废水的研究

通过向普通膜生物反应器(MBR)中添加氢氧化铁,驯化成生物铁污泥,形成生物铁膜生物反应器,分析各自对印染废水的处理效果,结果表明,生物铁MBR对COD的去除效果更好,去除率提高10%左右,但水力停留时间的长短对COD的去除效率影响不是很明显;通过改变泥龄观察处理效果,结果表明,生物铁MBR可以在较长泥龄的条件下运行而处理效果不会受到影响,比普通MBR排放更少的污泥,能达到污泥减量化;同时生物铁污泥絮体的形成为硝化细菌提供了良好的生存环境,使得对氨氮的去除效率比较稳定。试验说明:生物铁污泥的强化生化与物化作用可以加强系统整体的稳定性。     

膜分离法处理加油站油气的研究

针对加油站收油和发油过程中产生的油气污染,分别采用玻璃态油气截留型PEEK中空纤维膜组件和橡胶态油气渗透型GMT板框式膜组件,在自行设计建造的膜分离设备上,对比考察了2种膜组件和整个膜系统对油气污染治理和回收的效果.结果表明,2种膜系统对VOCs/空气混合气有很好的净化能力,尾气能够达标排放;在富油气返回油罐的模拟加油站实际运行情况的循环实验条件下,尾气也低于25 g·m-3的国标.     

阴极电极面积和膜面积对H型MFCs产电能力的影响

以生活污水为底物,碳棒作电极,构建H型瓶式微生物燃料电池(microbial fuel cells,MFCs),研究了阴极电极面积和膜面积对电池产电能力的影响.阳极以厌氧污泥作接种体,两室分隔物使用阳离子交换膜(cation exchange membrane,CEM),阳极不使用中介体,阴极使用无催化剂的普通碳电极....     

膜进样-单光子电离/化学电离-质谱仪在线检测水中VOCs

介绍了自行研制的膜进样-单光子电离/化学电离-飞行时间质谱仪.光子能量为10.6 eV的真空紫外灯作为单光子电离的光源,同时利用光电子电离产生O 2＋试剂离子,用于待测物分子的化学电离,通过调节电离区的电场条件可在2 s之内实现2种电离模式的快速切换.水中挥发性有机物（VOCs）以50μm的硅橡胶膜进行快速富集,膜后加入吹扫气加快样品脱附,吹扫气体还可抑制质谱分析器中油气本底,提高信噪比.SPI模式下,甲基叔丁基醚的检出限达到2μg·L-1（10 s分析时间）;SPI-CI模式下,三氯甲烷检出限达到1μg·L-1（10 s分析时间）.该仪器已成功应用于模拟加油站附近地下水中的甲基叔丁基醚和饮用水消毒副产物中的挥发性有机物的快速检测.结果表明该仪器在水中挥发性有机物在线检测方面有着广阔的应用前景.     

Influence and mechanism of N-(3-oxooxtanoyl)-L-homoserine lactone (C8-oxo-HSL) on biofilm behaviors at early stage

N-acyl-homoserines quenching, enzymatic quenching of bacterial quorum sensing, has recently applied to mitigate biofilm in membrane bioreactor. However, the effect of AHLs on the behavior of biofilm formation is still sparse. In this study, Pseudomonas aeruginosa biofilm was formed on ultra-filtration membrane under a series of N-(3-oxooxtanoyl)-L-homoserine lactone (C₈-oxo-HSL) concentrations. Diffusing C₈-oxo-HSL increased the growth rate of cells on biofilm where the concentration of C₈-oxo-HSL was over 10^-7 g/L. The C₈-oxo-HSL gradient had no observable influence on cell density and extracellular polymeric substances of biofilm with over 10^-7 g/L C₈-oxo-HSL. Surprisingly, 10^-11-10^-8 g/L of C₈-oxo-HSL had no effect on cell growth in liquid culture. The cell analysis demonstrated that the quorum sensing system might enhance the growth of neighboring cells in contact with surfaces into biofilm and may influence the structure and organization of biofilm.