袋式除尘器在沥青混凝土搅拌设备上的应用

分析了沥青混凝土搅拌设备的构成以及生产沥青混凝土的工艺及烟尘特点;通过应用工程实例,指出袋式除尘器是沥青混凝土搅拌设备最理想的除尘系统之一。     

钢渣掺量对泡沫混凝土砌块性能的影响

泡沫混凝土是一种环保、节能的保温隔热材料,以其优良的保温性能,受到越来越多研究者的关注。对钢渣的特性进行了分析测试,对钢渣不同掺量对泡沫混凝土砌块特性的影响进行了研究,结果表明,采用添加5％～35％钢渣所制备的钢渣泡沫混凝土砌块,其密度等级为JC／T1062—2007中的B10级,掺人5％、15％钢渣的泡沫混凝土抗压强度达到A3．5等级,掺人25％、35％钢渣的泡沫混凝土抗压强度达到A2．5等级。随着钢渣掺量的增大,抗压强度、抗折强度降低,吸水率增大。在同一钢渣掺量的情况下,泡沫混凝土砌块的抗压强度变化率增加显著,而且随着钢渣的加入量升高而增大。钢渣的加入有利于提高泡沫混凝土砌块的后期抗压强度。     

Use of recycled fine aggregate in concretes with durable requirements

The use of construction waste materials as aggregates for concrete production is highly attractive compared to the use of non-renewable natural resources, promoting environmental protection and allowing the development of a new raw material. Several countries have recommendations for the use of recycled coarse aggregate in structural concrete, whereas the use of the fine fraction is limited because it may produce significant changes in some properties of concrete. However, during the last decade the use of recycled fine aggregates (RFA) has achieved a great international interest, mainly because of economic implications related to the shortage of natural sands suitable for the production of concrete, besides to allow an integral use of this type of waste. In this study, the durable behaviour of structural concretes made with different percentage of RFA (0%, 20%, and 30%) is evaluated. Different properties related to the durability of concretes such as absorption, sorptivity, water penetration under pressure, and carbonation are determined. In addition, the results of compressive strength, static modulus of elasticity and drying shrinkage are presented. The obtained results indicate that the recycled concretes have a suitable resistant and durable behaviour, according to the limits indicated by different international codes for structural concrete.     

CFRP加固高强混凝土梁锚固方式试验研究

高强混凝土梁受拉底面粘贴补强纤维布后,延性降低显著。为提高补强梁的综合性能,利用四点弯曲梁静载试验,在补强加固梁梁端及跨中实施不同的锚固方式,对比不同锚固组合下加固梁的强度和延性。研究表明:端部U锚能改善加固梁破坏模式,提高加固梁的延性和强度及补强纤维布的利用率。端部U锚联合跨中全包锚固能进一步提高加固梁的延性,显著提高补强纤维布的利用率,且能平衡变形性和承载力在安全储备中的比重;在补强纤维布断裂后,能有效限制补强纤维布的剥离和滑移,继续发挥补强作用,使加固梁延性和强度得以恢复;能对包裹区混凝土产生约束作用,提高混凝土的延性。因此端部U锚联合跨中全包锚固是合理且有充分安全储备的锚固方式。     

混凝土大坝震害评估模型的研究及对黄河上游大坝的分析

利用前人所编的历代(共四代)地震烈度(地震动)区划图,组合叠加后得到一个综合烈度(地震动)。这种叠加是一个集成的专家系统综合认识结果,以此作为坝体可能遭受地震破坏危险的因素。初步研究建立了混凝土大坝震害评估模型,此模型是考虑了坝体的结构类型、建设年代、使用现状、场地条件、抗震设防水平等因素,用逐步线性拟合方法进行回归分析得到的。用此模型对汶川地震破坏的坝体进行了实例分析,分析结果比较符合实际。最后,用这个模型对黄河上游10座重点混凝土大坝做了震害评估分析。     

Preparation and performance of arsenate (V) adsorbents derived from concrete wastes

Solid adsorbent materials, prepared from waste cement powder and concrete sludge were assessed for removal of arsenic in the form of arsenic (As(V)) from water. All the materials exhibited arsenic removal capacity when added to distilled water containing 10–700 mg/L arsenic. The arsenic removal isotherms were expressed by the Langmuir type equations, and the highest removal capacity was observed for the adsorbent prepared from concrete sludge with heat treatment at 105 °C, the maximum removal capacity being 175 mg-As(V)/g. Based on changes in arsenic and calcium ion concentrations, and solution pH, the removal mechanism for arsenic was considered to involve the precipitation of calcium arsenate, Ca₃(AsO₄)₂. The enhanced removal of arsenic for the adsorbent prepared from concrete sludge with heat treatment was thought to reflect ion exchange by ettringite. The prepared adsorbents, derived from waste cement and concrete using simple procedures, may offer a cost effective approach for arsenic removal and clean-up of contaminated waters, especially in developing countries.     

EFFECTS OF CROPPING SYSTEMS ON NO3-N LOSSES TO TILE DRAIN1

Abstract: Diverse cropping systems can have significant impacts on nutrient losses through tile drain systems and to surface water bodies (rivers and streams). Increased transport of nitrogen to water bodies can reduce dissolved oxygen and enrich the supply of nutrients, resulting in hypoxic zones. With the objective of reducing the transport of nutrients from agricultural watersheds, long term studies (1990 to 1998) were conducted in Iowa to investigate the impact of tillage, crop rotation, and N-management practices on NO₃-N leaching losses to tile drain water. Results of these studies indicated that continuous corn production systems required higher input of nitrogen fertilizers and resulted in significantly higher NO₃-N leaching losses compared to rotated corn in plots either fertilized with manure or urea ammonium nitrate. Also, rotated corn gave higher corn yields, 8 megagrams per hectare (Mg/ha) versus 6 Mg/ha, than continuous corn. The higher N application rates resulted in increased NO₃-N concentrations in tile water. A strip cropping system with alfalfa lowered NO₃-N concentrations in tile water to less than 10 mg/l. These studies indicated that better land use practices can reduce NO₃-N leaching losses to surface and ground water systems and will help in mitigating environmental concerns of the production agriculture.     

CRITICAL EVALUATION OF CERTAIN METHODS OF UNSTEADY GROUNDWATER HYDRAULICS1

The basic theories and fundamental assumptions usually employed in the solution of unsteady groundwater flow problems are reviewed critically. The best known method of analysis for such problems is based on the Dupuit-Forchheimer approximation and leads to a nonlinear parabolic differential equation which is generally solved by linearization or numerical methods. The accuracy of the solution to this equation can be improved by use of a different approach which does not employ the Dupuit Forchheimer assumption, but rather is based on a semi-numerical solution of the Laplace equation for quasi-steady conditions. The actual unsteady process is replaced by a sequence of steady-state conditions, and it is assumed that the actual unsteady flow characteristics during a short time interval can be approximated by those associated with “average” steady state flow. The Laplace equation is solved by a semi-discretization method according to which the horizontal coordinate is divided into subintervals, while the vertical coordinate is maintained continuous. The proposed method is applied to a typical tile drainage problem, and, based on a comparison of calculated results with experimental data, the method is evaluated and practical conclusions regarding its applicability are advanced.     

浅谈钢筋混凝土结构的可靠性鉴定

系统介绍了混凝土结构检测的主要内容及方法,总结了我国目前可靠性鉴定三种方法的主要理论、优缺点及使用范围,并指出耐久性对可靠性鉴定的重要意义,以及耐久性评估所采用的理论和存在的问题。     

火灾后钢筋混凝土损伤程度的灰关联分析

由于火灾对钢筋混凝土结构的影响存在不确定性,使得人们不能准确地确定火灾后钢筋混凝土结构的损伤程度,给评估和加固修复带来很大困难。本文运用灰色系统理论中灰关联分析数学模型定量分析了高温下钢筋混凝土梁的3种影响因素,并确定了各因素间的主次关系,为高温后钢筋混凝土结构的安全评估及修复加固提供了理论依据。