Techno-economic evaluation of ultrasound and thermal pretreatments for enhanced anaerobic digestion of municipal waste activated sludge

To enhance the anaerobic digestion of municipal waste-activated sludge (WAS), ultrasound, thermal, and ultrasound + thermal (combined) pretreatments were conducted using three ultrasound specific energy inputs (1000, 5000, and 10,000 kJ/kg TSS) and three thermal pretreatment temperatures (50, 70 and 90 °C). Prior to anaerobic digestion, combined pretreatments significantly improved volatile suspended solid (VSS) reduction by 29-38%. The largest increase in methane production (30%) was observed after 30 min of 90 °C pretreatment followed by 10,000 kJ/kg TSS ultrasound pretreatment. Combined pretreatments improved the dimethyl sulfide (DMS) removal efficiency by 42-72% but did not show any further improvement in hydrogen sulfide (H₂S) removal when compared with ultrasound and thermal pretreatments alone. Economic analysis showed that combined pretreatments with 1000 kJ/kg TSS specific energy and differing thermal pretreatments (50-90 °C) can reduce operating costs by $44-66/ton dry solid when compared to conventional anaerobic digestion without pretreatments.     

阴燃中出现有焰火的理论初探

阴燃是一种自维持,不断传播的,异相反应的放热燃烧过程。典型的阴燃例子有蚝烟,地下煤矿的燃烧等。从热安全角度来看阴燃过程,不完全的氧化反应和可燃物热解都会产生很多的有毒气体,对人造成危害;另外在一定的条件下,阴燃还会突然转化为有焰火,进行更猛烈的燃烧,造成更大的破坏。     

工业设备的震害预测研究

综合考虑地震作用和结构材料的随机性 ,运用概率论的知识建立了地震作用下钢铁工业设备各种破坏形式的极限状态方程 ,并求出了对应于某种地震烈度 ,设备出现各种破坏状态的概率。在此基础上 ,通过模糊综合评判的手段提出了工业设备的震害预测方法 ,并编制了相应的软件。此种方法的建立使设备抗震预测变得方便、可行。     

细水雾对锂离子电池热失控抑制作用的实验研究

为研究细水雾对锂离子电池热失控的抑制作用,利用自设计细水雾实验装置对18650型锂离子电池热失控进行抑制实验,对比两节电池依次燃爆和不同阶段使用细水雾的温度曲线。研究表明,细水雾对于抑制锂离子电池热失控有效,但不同热失控阶段细水雾抑温效果差异较大,结合锂离子电池多米诺效应和机载灭火设备适航性要求,应尽可能将细水雾喷雾时间节点靠近初次爆炸的时间节点。提出通过准确探测初次爆炸发生和进一步增强细水雾抑制作用来控制锂离子电池热失控及多米诺效应的发生和传播。     

火电厂锅炉再热器联络管裂纹分析及处理

某火电厂亚临界锅炉墙式再热器蒸汽出口至屏式再热器联络管母管及排空气管接管座产生裂纹发生渗漏。通过对墙式再热器出口管道排空气管接管座裂纹特征、结构型式、管道现场布置情况、运行环境等方面进行综合分析,认为排空气管道安装布置不合理,无保温措施,导致冷凝水倒流,形成热疲劳裂纹并逐步延伸扩展。确认产生裂纹的原因后,优化管道安装布置、对接管座结构型式做出改进并对产生裂纹的管道进行了更换,改进后锅炉运行约1.8× 10⁴ h后复检无缺陷。     

An assessment of how distance and diesel oxidation catalyst will impact thermal decomposition behaviors of particles

Decomposition mass loss and pyrolysis products analyses of particles sampled at various locations along the tailpipe of a Euro-IV diesel engine were performed using a thermogravimetry in conjunction with Fourier transformation infrared spectrometry-mass spectrum. Diesel particles were collected at the same location with and without diesel oxidation catalyst (DOC) mounted on the test engine separately. The three poles in thermal gravity-differential thermal gravity images suggested that the decomposition process of diesel particles could be divided into three stages which correspond to the decompositions of lower boiling substances, higher boiling substances and soot respectively. It is noticed that no matter whether DOC was mounted or not, the further the particles were sampled away from the engine block, the lower the peak temperatures and the heavier the mass losses within the first two stages, which indicated that the soluble organic fraction in the particle samples increased and therefore lowering the activation energy of thermal decomposition. Hydroxyl, ammonia, C_xH_y fragments, benzene, toluene, and phenol were found to be the primary products of particle decomposition, which didn't change with the location of particle sample point. The employment of DOC increased the activation energy for particle oxidation and resulted in a higher peak temperature and lower mass loss within the first-stage. Moreover, the CO stretching bands of aldehyde and ketone at 1771 cm^?1 was only detected without a DOC, while the NO₂ peak at 1634 cm^?1 was solely noticed with the presence of DOC. Compared to the first-stage pyrolysis products, more polycyclic aromatic hydrocarbons and less C_xH_y fragments were seen in the second-stage.     

土壤调理剂对土壤-水稻系统Cd、Zn迁移累积的影响及健康风险评价

选取湖南省长沙市北山镇某中重度Cd污染稻田,研究了土壤调理剂(石灰石+偏高岭土+钙镁磷肥)对稻田土壤重金属Cd、Zn的钝化效果,以及对水稻各部位累积Cd和Zn的影响,并进行了Cd的健康风险评价.结果表明,使用土壤调理剂提高了稻田土壤p H值.Cd的CaCl_2提取态含量降低了0.9%~24.1%,Zn的CaCl_2提取态含量降低了22.5%~69.6%.土壤调理剂显著降低了水稻糙米中Cd与Zn的含量,与对照相比分别降低了10.8%~47.3%、10.3%~17.5%;土壤调理剂对水稻糙米Cd的吸收和累积的影响要远大于Zn,水稻糙米中的Cd/Zn比随着土壤调理剂施用量的增加而显著降低.研究区大米重金属Cd目标危害系数THQ值大于1,说明当地人群通过食用大米途径摄入重金属Cd存在健康风险.土壤调理剂有效地抑制了水稻植株对土壤中Cd的吸收,并降低了Cd/Zn比,使糙米中的Cd含量显著降低,从而降低了当地人群通过食用大米途径摄入重金属Cd的健康风险.     

电厂温排水对水库生态环境的影响

本文报告了电厂温排水对陡河水库生态环境的影响。结果表明,陡河水库年均水温比对照水体洋河水库提高2.8～4.8℃。溶解氧随着水温而变化,但从未低于5.0mg/l,增温后水体中各种营养盐类含量呈增加趋势,水体富营养化明显。     

基于卷积神经网络的冲击地压预警方法研究*

为探究深度学习在冲击地压预警方面的应用前景,以新疆某冲击地压矿井为研究背景,将深度学习和专家评判运用到微震数据分析中,基于卷积神经网络构建冲击地压预警模型。充分利用一维卷积神经网络对时序数据有较强特征提取能力的优势,以微震数据及其特征参数作为输入,以专家评判值作为标签,借助Python-Keras框架实现冲击地压预警模型的构建和训练。研究结果表明:模型预警效果并不随着训练迭代次数的增加而逐渐最优,存在最优迭代次数,对于所建模型当迭代次数为30时测试集的冲击危险预测结果与专家评判结果基本吻合,同时说明模型可以较好地学习专家评判经验实现冲击地压预警。研究表明所建模型对研究时段内发生的5次大能量矿震事件均进行预警,其准确度较高,具有现场实际应用价值。     

聚氯乙烯电缆料老化前后的火灾危险性研究

利用微型燃烧量热计（MCC）、热重分析（TGA）、实时红外光谱（RTFTIR）以及热重-红外联用技术（TG-FT-IR）研究了PVC电缆料老化前后火灾危险性的变化。MCC结果表明,老化后的PVC的最大热释放速率增加了56.3%,总热释放量从10.6kJ/g增加到16.8kJ/g,点燃温度也由302℃提前到282℃。TG-FTIR和RTFTIR的分析结果显示,PVC的主要降解产物有水、碳氢化合物、二氧化碳和一氧化碳。PVC达到最大降解速率的温度约为240℃,与MCC、TG的结果相符合。PVC的裂解气体中包含CO2和CO,还有剧毒气体HCl。这些实验数据说明PVC材料在使用过程中火灾危险性加大,为老城区电气线路和设备的改造提供了理论依据和实验基础。