Operating condition influences on PCDD/Fs emissions from sinter pot tests with hot flue gas recycling

This study was designed to clarify the influence of operating conditions on the formation and emissions of polychlorinated-pdibenzodioxins and dibenzofurans (PCDD/Fs) from a sintering process with hot flue gas recycling. A pilot scale sinter pot with simulated flue gas recycling was developed, and four key operational parameters, including temperature, oxygen content of the simulated waste flue gas, the coke rate of the sintering mixture, and the quicklime quality, were selected for exploring PCDD/Fs formation. The results showed that the temperature of the recycled flue gas had a major affect on PCDD/Fs formation, and a high temperature could significantly increase their formation during sintering. A clear linear correlation between the temperature of recycling flue gas and PCDD/Fs emission (r = 0.93) was found. PCDD/Fs could be reduced to a certain extent by decreasing the level of oxygen in the recycled flue gas, while sintering quality was unchanged. The coke rate had no significant influence on the formation of PCDD/Fs, but the quality of quicklime used in the sintering mixture could affect not only the amount of PCDD/Fs emissions but also the sintering productivity. Compared with a benchmark sinter pot test, PCDD/Fs emissions markedly decreased with improvements to quicklime quality. However, the reduction in PCDD/Fs emissions realized by using high-quality quicklime was limited by the temperature of the inlet gas. The highest reduction achieved was 51% compared with conventional quicklime when the temperature of the inlet gas was 150°C.     

废弃混凝土对C_3S形成动力学的影响

废弃混凝土中石灰石的含量比较稳定,适合取代天然石灰石作为钙质原料配制水泥生料,并含有少量的SiO2,可以起部分硅质原料的作用。硬化的水泥浆体在高温下脱水形成氧化钙、氧化铝和氧化铁等氧化物,都是制造水泥所必须的氧化物。实验室利用20%和40%的废弃混凝土代替部分石灰石制备水泥熟料。研究了废弃混凝土对硅酸盐水泥熟料形成动力学的影响。用快速滴定法测定了不同熟料中f-CaO含量,根据文章提出CaO反应生成C3S的转化率,并用Amhenius公式计算了熟料中C3S形成反应的表观活化能。研究表明:废弃混凝土能改善生料的易烧性,并能降低熟料的烧成温度。     

辽宁太子河沉积物重金属污染及潜在生态危害评价

为全面了解辽宁太子河底泥沉积物中重金属的污染特征,测试了太子河表层沉积物中重金属元素铜、铅、镉和锌的含量,并采用地积累指数法和潜在生态危害指数法评价了沉积物中重金属污染及其潜在生态危害程度。结果表明,辽宁太子河底泥沉积物中各种重金属元素的污染程度由强至弱依次为:Cd>Zn≥Cu>Pb;金属污染构成的潜在生态危害由强至弱依次为:Cd>Cu≈Zn>Pb,其中Cd的影响占绝对主导地位。     

聚合物/表面活性剂二元体系对油水界面性质的影响

文章应用界面张力仪、Zeta电位仪和表面黏弹性仪测定了聚合物、表面活性剂及其二元复合体系的质量浓度对油水界面性质的影响,并应用透射电镜观察了采出液的液膜结构。结果表明,随着聚合物质量浓度的增加,油水界面的界面剪切黏度值和界面张力值增大,颗粒表面Zeta电位的绝对值增大;随着表面活性剂质量浓度的增加,油水界面的界面剪切黏度变化幅度很小,但界面张力显著减小,颗粒表面Zeta电位绝对值增大;聚合物与表面活性剂复合能够形成稳定的聚合体,具有较大的界面剪切黏度值,较小的界面张力和较高的Zeta电位值;体系中聚合物、表面活性剂及水中悬浮物形成了类似"晶体"结构。     

长江原水臭氧-生物活性炭挂膜中试研究

为了探究面向长江水源的臭氧-生物活性炭深度处理工艺的挂膜技术,进行了长江原水常州段的臭氧-生物活性炭挂膜中试研究.结果表明,在挂膜前期,由于炭柱的物理吸附作用逐渐饱和,炭柱对DOC(溶解性有机碳)、UV_(254)和COD_(Mn)(高锰酸盐指数)的去除率逐渐降低,对氨氮几乎没有去除,在挂膜中后期,由于活性炭上生物膜逐渐成熟,生物降解起主导作用,有机物和氨氮去除率升高并趋于稳定.90 d后,炭柱对DOC、UV_(254)和COD_(Mn)这3个有机物指标的去除率分别稳定在30.64%、57.50%和30.00%以上,氨氮去除率稳定在88.93%左右,认为挂膜成功.扫描电镜图显示活性炭表面出现丰富的菌胶团,同时高通量测序也验证了活性炭中丰富多样的微生物群落结构.     

不确定背景值下浅水湖泊沉积物重金属生态风险评价

基于安徽某湖泊沉积物柱状样重金属实测含量,研究了各类重金属的垂向变化趋势及来源;采用拉丁超立方抽样方法随机产生已知范围内的重金属背景值,计算沉积物重金属综合潜在生态风险水平,研究其结果不确定性,评价湖泊沉积物重金属污染程度.结果表明,沉积物重金属的含量及综合潜在生态风险水平沿深度方向呈逐渐降低的趋势,上层沉积物存在较高的综合潜在生态风险;不确定性评价方法可以在沉积物垂向上得到沉积物重金属综合潜在生态风险水平的包络面,不确定性的结果可以给出综合潜在生态风险超出风险阈值的可信度和特定置信度下的综合潜在生态风险指数置信区间;90%置信度下两个沉积物采样点上层重金属综合潜在生态风险指数（RI）的置信区间分别为340.08~412.89和271.61~327.67,处于重度综合潜在生态风险水平阈值附近的评价结果让不同风险偏好的决策者在面临修复、清淤等决策时可以做出符合自身预期的决策.     

国家干线公路移动源VOCs排放及臭氧生成潜势研究

基于国家干线公路4346个交通监测站日平均监测数据,采用移动源VOCs测算方法,建立国家干线移动源VOCs排放清单,使用最大增量反应活性（MIR）估算VOCs的臭氧生成潜势（OFP）,并通过动态分段技术和核密度估计方法对臭氧生成强度的空间特征进行分析.结果表明,客车是国家干线移动源VOCs年排放量最大的源,占客货总排放量70.50%;广东省年排放量最大,占全国干线公路VOCs排放量的10.7%;G15沈海高速年排放量最大,占全国干线公路VOCs排放量的5.4%.烯烃和芳香烃为移动源OFP主要的贡献者,前十种有机污染物占干线移动源总OFP的67.29%.从客货车日均OFP强度上来看,受车流量影响,各干线差异明显.北京天津呈团簇状集聚,至石家庄一线为带状分布;济南淄博潍坊青岛一线呈弯月带状分布;南京苏州上海杭州呈团状,至上海又集聚;粤港澳大湾区以深圳为中心高度聚集;沈阳、郑州、西安、武汉、重庆等交通枢纽出现次一级强度集聚.     

太原市夏季大气VOCs污染特征及臭氧生成潜势

2018年8月采集太原市大气样品,分析太原市夏季大气VOCs的污染特征,并利用最大增量反应活性系数法（MIR系数法）估算了VOCs的臭氧生成潜势（OFP）.结果表明,太原市夏季大气VOCs浓度为17.36~89.60μg/m³,其中烷烃占比58.01%、芳香烃占比20.06%、烯烃占比16.52%、炔烃占比5.40%.大气VOCs浓度变化表现为明显的早晚双高峰特征,且以早高峰影响为主.OFP分析显示,烷烃、烯烃、芳香烃、炔烃分别占总OFP的19.16%、47.74%、31.75%、1.35%,C₃~C₅类烯烃是活性较高的物种,对O₃生成贡献较大.     

南方丘陵区河流表层沉积物重金属污染评价

采样分析南方丘陵山区瓯江、钱塘江、闽江、九龙江沉积物中重金属含量,并对其来源及生态风险进行研究.结果显示,沉积物中Mn、Zn、As、Cd、Pb、V在九龙江有较高浓度,Ni、Cu在钱塘江浓度最高,Cr、Sb在瓯江浓度最高,而Al、Co和V的最高浓度分布在闽江.但重金属含量空间差异不显著.SQGs、Igeo和EF评价显示,Cd在研究区沉积物中污染最为严重,呈中度至重度污染,其次是Mn、Zn、Pb,其在研究区部分地区存在轻度污染,其他重金属处于无污染状态.RI评价显示,研究区河流沉积物存在极高重金属潜在生态风险,尤其是Cd.相关分析和PCA分析显示,Zn、As、Cd、Pb来自于自然过程、矿业开采及农业生产过程,Cr、Ni、Sb来自于工业生产过程产生废水,Al、Co和V来自于自然过程,而Cu则来源于混合源.pH值、TP、TN和LOI是影响水体中重金属含量的重要因子.本研究为河流生态系统的健康和保护提供重要依据.     

Characteristics of volatile organic compounds, NO2, and effects on ozone formation at a site with high ozone level in Chengdu

Chengdu is a megacity in the southwest of China with high ozone (O₃) mixing ratio. Observation of volatile organic compounds (VOCs), NO₂ and O₃ with high temporal resolution was conducted in Chengdu to investigate the chemical processes and causes of high O₃ levels. The hourly mixing ratios of VOCs, NO₂, and O₃ were monitored by an online system from 28 August to 7 October, 2016. According to meteorological conditions, Chengdu, with relative warm weather and low wind speed, is favorable to O₃ formation. Part of the O₃ in Chengdu may be transported from the downtown area. In O₃ episodes, the average mixing ratios of NO₂ and O₃ were 20.20?ppbv and 47.95?ppbv, respectively. In non-O₃ episodes, the average mixing ratios of NO₂ and O₃ were 16.38?ppbv and 35.15?ppbv, respectively. The average mixing ratio of total VOCs (TVOCs) was 40.29?ppbv in non-O₃ episodes, which was lower than that in O₃ episodes (53.19?ppbv). Alkenes comprised 51.7% of the total O₃ formation potential (OFP) in Chengdu, followed by aromatics which accounted for 24.2%. Ethylene, trans-pentene, propene, and BTEX (benzene, ethylbenzene, toluene, m/p-xylene, o-xylene) were also major contributors to the OFP in Chengdu. In O₃ episodes, intensive secondary formations were observed during the campaign. Oxygenated VOCs (OVOCs), such as acetone, Methylethylketone (MEK), and Methylvinylketone (MVK) were abundant. Isoprene rapidly converted to MVK and Methacrolein (MACR) during O₃ episodes. Acetone was mainly the oxidant of C3-C5 hydrocarbons.