钼矿区污灌菜地土壤重金属污染的生态风险预警评价

通过对钼矿区地下水进行重金属含量分析,发现地下水已受重金属污染。该受污染地下水为矿区菜地唯一灌溉用水。本文研究钼矿区污灌菜地土壤的重金属污染现状及生态风险。选取矿区、尾矿区、选矿区周边菜地的土壤样本60个,用HNO3-HF-HClO4处理后,采用等离子体发射光谱仪（ICP-AKS）测定土壤样品中Pb、As、Hg、Cr、Cd、Zn、Cu、Ni的全量,采用生态风险指数进行生态风险预警评价。结果表明：矿区、尾矿区、选矿区周边受污染菜地尾矿区农田土壤的生态风险指数（IER）分别为59．42、80．60、154．83,其预警类型均为重警;污染程度为矿区菜地〈尾矿区菜地〈选矿区菜地。     

西部管道工程HSE一体化绩效管理应用研究

分析了我国管道工程项目HSE绩效管理存在问题,运用绩效管理理论,结合“PMT（业主）＋PMC（监理）＋EPC（施工总承包方）”一体化模式及西部管道工程,阐述了HSE一体化绩效管理体系的建立及应用情况。     

The method for leakage detection of urban natural gas pipeline based on the improved ITA and ALO

To solve the problems of the difficulty in early leakage monitoring and larger positioning error for urban hazardous chemicals pipelines, the optimized method based on the improved Inverse Transient Analysis (ITA) and Ant Lion Optimizer (ALO) was proposed. Firstly, based on the obtained experiment's results of leakage of natural gas in the non-metallic pipeline, the segment classification method was incorporated into the pressure gradient calculation. The modified method can adapt to the multi-node characteristics of urban pipe networks and help to obtain the preliminary positioning calculation results after optimization. Then the calculation results were embedded in the ITA calculation model. The input parameters of the gas pipeline such as boundary conditions, leakage rate and friction coefficient were used to establish the characteristic linear equations. Then the objective function of the least-squares criterion was defined, and the improved ITA model suitable for leakage detection of urban natural gas pipeline networks was constructed. Finally, the ALO was used to optimize the calculation process of the improved ITA model, and iteratively optimize the optimal friction coefficient and its corresponding minimum objective function (OF) value. As a result, a more precise location of the leakage source was calculated. The validation of the modified method is conducted by comparing the calculated values with the experiment's results. The results show that the method can accurately predict the location where the pipeline leakage occurs. The minimum error is 3.17%. Compared with the traditional ITA, this method not only accelerates the convergence speed of the objective function, but also improves the accuracy of location calculation.     

基于广义概念的城市燃气管道泄漏精确定位

为了准确地检测城市燃气管道泄漏,提出了一种基于广义概念的管道泄漏检测定位方法。声发射技术对于管道泄漏的检测、定位是一个极好的工具,但由于泄漏源的传播容易受到周围背景噪声以及复杂工况的影响,其定位误差较大。基于时延估计的互相关信号处理方法被广泛用于管道泄漏检测定位,但由于泄漏应力波传播通道的动态特性,使得源信号在传播过程中会产生波形变化,给互相关函数峰值位置的确定带来困难。由此引入广义相关分析方法,通过对信号进行前置滤波,在一定程度上减少了传播通道动态特性因素对泄漏点定位的不利影响,得到了更为准确的时延估值。在此基础上,通过模拟实验,编写Matlab神经网络代码,构造GRNN模型,进一步预测定位。结果表明,GRNN预测的声发射检测值、互相关定位值以及广义相关定位值,相比之前定位精度分别得到提高,其中基于广义相关的延时估计方法定位最为精确,将该方法用于工程实际中,可以更加精确地定位出泄漏点。     

Release and dispersion behaviour of carbon dioxide released from a small-scale underground pipeline

The development of carbon capture and storage (CCS) brings challenges for safety issues regarding carbon dioxide (CO₂) transmission pipelines. Once a pipeline is punctured or full-bore ruptured, the leaked CO₂ is hazardous to personnel and the environment. Small-scale devices were established with the aim of studying the release and dispersion behaviour of gas and liquid CO₂ from a punctured underground pipeline. A sandbox was built to simulate the underground conditions. The parameters of the sand used in the experiments were tested. CO₂ concentrations on the ground and temperatures around the release orifice in the sand were analysed. The results indicate that in the CO₂ gas release experiments, the CO₂ concentration on the sand surface decreases with increasing horizontal distance in the form of a power function. CO₂ concentrations in upward release are slightly larger than those in horizontal release at the same location but are obviously bigger than values in downward release. The temperature-drop region is much smaller than that in air. A frozen ice ball can be generated near the release orifice during the gas phase of the CO₂-release process. In the liquid phase of CO₂-release experiments, a large amount of dry ice is generated near the release orifice. Dry ice can only be generated in the area close to the release orifice, especially in the near-field area.     

Underground parallel pipelines domino effect: An analysis based on pipeline crater models and historical accidents

This paper focuses on the analysis of the possibility of domino effect in underground parallel pipelines relying on historical accident data and pipeline crater models. An underground pipeline can be considered as safe following an accident with an adjacent gas or liquefied pipeline when it remains outside the ground crater generated. In order to prevent the domino effect in these cases, the design of parallel pipelines has to consider adequate pipeline separations based on the crater width, which is one of the widely used methods in engineering applications. The objective of this work is the analysis of underground petroleum product pipelines ruptures with the formation of a ground crater as well as the evaluation of possible domino effects in these cases. A detailed literature survey has been carried out to review existing crater models along with a historical analysis of past accidents. A FORTRAN code has been implemented to assess the performance of the Gasunie, the Batelle and the Advantica crater models. In addition to this, a novel Accident-Based crater model has been presented, which allows the prediction of the crater width as a function of the relevant design pipeline parameters as well as the soil density. Modifications have also been made to the Batelle and Accident-Based models in order to overcome the underestimation of the crater width. The calculated crater widths have been compared with real accident data and the performance evaluation showed that the proposed Accident-Based model has a better performance compared to other models studied in this work. The analysis of forty-eight past accidents indicated a major potential of underground parallel pipelines domino effect which is proven by two real cases taken from the literature. Relying on the investigated accidents, the crater width was smaller than or equal to 20 m in most cases indicating that the definition of underground pipeline separations at around 10 m would be sufficient to ensure a small probability of the domino effect.     

油气长输管道施工企业清洁生产研究

清洁生产在油气长输管道施工领域涉及较少,观念和方法还未完全推广。油气长输管道施工企业与传统生产型企业有许多不同之处,以某企业清洁生产审核为例,就如何通过清洁生产审核挖掘清洁生产潜力来做探索性、建议性的研究。实践证明,该企业清洁生产机会的突破口为柴油消耗,通过柴油消耗平衡图的建立和重点耗油设备运行状况的调查,找到了降低柴油消耗的清洁生产方案,使企业达到了“节能、降耗、减污、增效”的目的。     

油气长输管道工程施工风险管理

目前我国新建管线几乎都是长距离输送油气,施工地质条件相当恶劣.本文针对油气长输管道的组成及其施工分类和特点,探讨了对油气长输管道工程施工进行动态全过程风险管理的方法.     

埕岛油田海底管道运行现状及安全分析

分析了中国石化埕岛油田海底管道安全运行现状及存在的问题,介绍了解决问题的对策措施及实施效果。     

模拟海水管路的电偶效应数值仿真研究

目的 研究钛合金模拟海水管路与船体间在不同电连接方式下的电位以及腐蚀电流密度分布,明确防腐措施.方法 针对钛合金模拟海水管路与船体结构,基于有限元建立仿真模型,开展两者的电偶效应数值仿真计算,重点研究两者电连接状态、接触界面绝缘状态和所有结构体单元绝缘状态的电位和电流密度分布情况.结果 在船体钢与钛合金管路系统电连接时...