改性活性炭脱除硫化氢工艺参数研究

针对改性活性炭脱除硫化氢过程,研究了空速、温度、原料气浓度、颗粒分布孔径4个主要工艺参数对脱硫效率的影响。结果表明:空速在1 500～4 200h-1时穿透硫容随着空速的降低而增加,当空速继续降低为1 200h-1时穿透硫容基本不变;当0～40℃时,随着温度的升高,穿透时间增加,脱硫效率提高,当温度超过40℃时,随着温度继续升高脱硫效率降低;相同空速下原料气硫化氢浓度变化只改变穿透时间;改性活性炭脱硫剂发挥脱硫作用的微孔结构范围是1～5nm。     

LDO处理垃圾渗滤液中氮的实验研究

研究了复合金属氧化物（LDO）用于处理垃圾渗滤液中氮的可行性,并与传统吸附剂粉末活性炭（PAC）进行了比较,考察了投加量、振荡速度、吸附时间、吸附温度、pH等因素对处理效果的影响。结果表明,当垃圾渗滤液中总氮浓度为561mg/L、LDO投加量为6g/L、振荡速度为170r/min、吸附时间为60min、温度为25℃、pH值为11时,LDO对总氮的吸附量最高,达到41mg/g。在相同条件下,LDO对总氮的吸附量是PAC的2.5—3.5倍。     

高效粉煤灰分选系统的设计与应用

粉煤灰分选是一种实用技术,从分选机的原理出发,设计合理的分选机结构,选择合理的系统布置和参数能够保证分选的高效率。文中还着重对分选系统的防磨措施、工艺设计、调节方法、分选效率作了详细的描述。对实际应用项目的设计、安装调试、运行测试等内容做了介绍,并验证了本分选系统的调节手段多样、方便,效率高达85%以上。     

VFA generation from waste activated sludge: effect of temperature and mixing

The success of enhanced biological phosphorus removal (EBPR) depends on the constant availability of volatile fatty acids (VFAs). To reduce costs, waste streams would be a preferred source. Since VFAs were shown to vary in the incoming sewage and fermentate from primary sludge the next available source is waste activated sludge (WAS). The opportunity is particularly good in plants where WAS is stored before shipment. Little information is however available on the rate of VFA release from such sludge, especially at the lower temperatures and under the storage conditions typically found in colder climates. Bench-scale batch tests were performed to investigate the effect of temperature and requirement for mixing on VFA generation from WAS generated in full scale non-EBPR wastewater treatment plant. WAS fermentation was found highly temperature-dependent. Hydrolysis rate constant (k_h) values of 0.17, 0.08 and 0.04 d⁻¹ at 24.6, 14 and 4 °C were obtained, respectively. Arrhenius temperature coefficient was calculated to be 1.07. It took 5 d to complete hydrolysis at 24.6 °C, 7 d at 14 °C, and 9 d at 4 °C. The fermentation lasted for 20 d. At 24.6 °C the mixed reactor reached 84% of the overall VFA production only in 5 d. When temperature dropped to 14 and 4 °C, the ratio of VFA production at day 10 to overall VFA production in the mixed reactor were 62% and 48%, respectively. The overall VFA-COD concentration in the non-mixed reactors was much lower than the mixed reactors. The information is important for the designer as there was uncertainty with the effect of temperature and mixing on sludge fermentation.     

红斑顠体虫在活性污泥中的生长特性研究

以活性污泥为研究对象,研究了污泥中红斑顠体虫的生长情况以及红斑顠体虫对污泥减量的影响.结果表明:(1)红斑顠体虫的培养温度应该保持在20℃以上.在低污泥负荷(F/M) (＜0.4 mg/(mg·d))下,红斑顠体虫均能大量出现.(2)当温度大于20℃、红斑顠体虫处于生长期的活性污泥浓度(MLSS)＞3.0 g/L时,红...     

甲苯气体的动态吸附净化及吸附剂再生实验研究

研究了活性炭纤维(ACF)对甲苯气体的动态吸附净化过程及热空气解吸脱附再生过程.采用3种经验方程对ACF的吸附等温线进行拟合,其中Langmuir方程拟合效果最好,拟合相关系数R2 =0.9960,说明在给定的浓度范围内,ACF对甲苯的吸附是以单分子层吸附为主.穿透曲线实验表明,ACF对甲苯吸附效果较好,Yoon-Ne...     

Na2S·HNO3改性活性炭对水中低浓度Pb2+吸附性能的研究

采用回流蒸煮、微波焙烧的方法改性活性炭,通过Boehm滴定法、TG和FT-IR分析了改性前后活性炭表面官能团的变化情况.Boehm滴定表明:改性活性炭的总酸度、羧基、内酯基皆有增加;TG曲线中的多个失重峰说明了改性活性炭表面含氧基团的增加;FT-IR谱图上500～720 cm-1范围内新峰的出现说明了改性活性炭表面增加...     

微波辅助-活性炭法处理电厂EDTA锅炉清洗废水可行性研究

采用微波辅助-活性炭法处理电厂EDTA锅炉清洗废水,研究了微波辐射时间、微波功率以及再生次数对活性炭吸附能力的影响,并根据实验结果设计了工艺流程,分析了微波辅助-活性炭法处理电厂EDTA锅炉清洗废水的可行性.研究表明,微波辅助-活性炭法处理EDTA清洗废水的最佳微波辐射时间和微波功率分别为5 min和680 W,微波辐...     

高声能密度超声波破碎污泥细胞效能的研究

采用超声波在较高声能密度下处理SBR的剩余污泥,主要考察了含固率、声能密度和作用时间对污泥细胞破碎效果的影响。结果表明,在声能密度0.5～3 W/mL内,含固率1%～1.5%的剩余污泥经超声波作用后,上清液SCOD随作用时间呈线性升高;在声能密度1～3 W/mL内,含固率0.25%～0.5%的剩余污泥经超声波作用后,上清液SCOD随作用时间呈平缓缓慢升高。高声能密度超声波更适合对较高含固率污泥的细胞破碎;此情况下,上清液SCOD增幅、NH4＋-N、TN及TP升幅均与声能密度正相关。经超声波作用6 min后,污泥形态结构已破坏。     

活性焦烟气脱硫技术在有色行业的推广应用

介绍了活性焦烟气脱硫技术原理、流程和特点,该技术具有脱硫效率高、工况适应性强、流程简单、节水、无二次污染、可同时脱除多种污染物和可回收硫资源等优点,介绍了活性焦烟气脱硫技术在有色金属行业的发展和应用情况。针对我国硫资源和水资源短缺的国情,建议在有色金属行业加快推广应用活性焦烟气脱硫技术,在治理大气污染的同时回收硫资源。