有机废物厌氧消化工艺应用现状及前景展望

与其他常规处理方法相比,利用厌氧消化技术处理有机废物更具有优嚏,因为它不仅可以有效减少污省染,还可以产生很好的经济效益和巨大的环境效益。简要介绍了厌氧消化技术的机理、影响因素、类型,以及在有机废物处理领域的应用现状,并重点介绍了国外近年来发展形成的典型厌氧消化工艺,同时分析了厌氧消化技术在有机废物资源化处理领域的广阔应用前景。     

中型针织面料印染厂废水处理研究

针对中型针织面料印染厂含有机污染物浓度较高的废水,设计了一套废水处理工艺流程,并通过实例对其进行了检验。废水水质CODcr为1 200 mg/L、BOD5为400 mg/L、SS为280 mg/L、色度为400倍、处理水量1 000 m^3/d,在经过水解、生物接触氧化和沉淀等工艺处理后,出水指标稳定,并且达到了环保部门的排放要求。     

印染废水治理方案分析

某针织印染厂年产3000吨针织高档服装布料,排放的生产废水中含有大量的有机物,COD、BOD5、色度浓度比较高。该厂选择了"厌氧水解酸化+接触氧化法+活性炭吸附"处理工艺。该工艺采用厌氧水解酸化处理工艺进行前期处理,去除大部分有机物,减轻了后续接触氧化处理工艺的压力,同时通过活性碳过滤进行脱色,达到较好的处理效果。运行结果表明,经该工艺处理后,废水中的COD、BOD5、色度等指标均能达标排放,有利于企业的可持续发展。     

Performance of completely autotrophic nitrogen removal over nitrite process under different aeration modes and dissolved oxygen

In this study, three sequential batch biofilm reactors (SBBRs) were operated for 155 days to evaluate the performance of completely autotrophic nitrogen removal over nitrite (CANON) process under different aeration modes and dissolved oxygen (DO). Synthetic wastewater with 160-mg NH4 ⁺-N/L was fed into the reactors. In the continuously-aerated reactor, the efficiency of the ammonium nitrogen conversion and total nitrogen (TN) removal reached 80% and 70%, respectively, with DO between 0.8–1.0 mg/L. Whereas in the intermittently-aerated reactor, at the aeration/non-aeration ratio of 1.0, ammonium was always under the detection limit and 86% of TN was removed with DO between 2.0–2.5 mg/L during the aeration time. Results show that CANON could be achieved in both continuous and intermittent aeration pattern. However, to achieve the same nitrogen removal efficiency, the DO needed in the intermittently-aerated sequential batch biofilm reactor (SBBR) during the aeration period was higher than that in the continuously-aerated SBBR. In addition, the DO in the CANON system should be adjusted to the aeration mode, and low DO was not a prerequisite to CANON process.     

Sludge reduction during brewery wastewater treatment by hydrolyzation-food chain reactor system

During brewery wastewater treatment by a hydrolyzation-food chain reactor (FCR) system, sludge was recycled to the anaerobic segment. With the function of hydrolyzation acidification in the anaerobic segment and the processes of aerobic oxidation and antagonism, predation, interaction and symbiosis among microbes in multilevel oxidation segment, residual sludge could be reduced effectively. The 6-month dynamic experiments show that the average chemical oxygen demand (COD) removal ratio was 92.6% and average sludge production of the aerobic segment was 8.14%, with the COD of the influent at 960–1720 mg/L and hydraulic retention time (HRT) of 12 h. Since the produced sludge could be recycled and hydrolyzed in the anaerobic segment, no excess sludge was produced during the steady running for this system.     

腐殖酸-重金属对ANAMMOX菌脱氮性能的影响及其动力学分析

通过批次实验研究了两种典型重金属离子[Cu（Ⅱ）和Ni（Ⅱ）]与腐殖酸对厌氧氨氧化（ANAMMOX）脱氮效果（SAA）的影响并进行了动力学模型分析,同时探讨了腐殖酸-重金属对ANAMMOX脱氮的影响.结果表明,在投加ρ[Cu（Ⅱ）]和ρ[Ni（Ⅱ）]均为3mg·L^-1时,对ANAMMOX有促进作用,SAA分别提高了8.64%和7.78%;当ρ[Cu（Ⅱ）]和ρ[Ni（Ⅱ）]分别为20mg·L^-1和5mg·L^-1时则对ANAMMOX有抑制作用,抑制效果随重金属离子浓度增加而越发显著,指数拟合表明Cu（Ⅱ）和Ni（Ⅱ）对ANAMMOX的IC50分别为29.67mg·L^-1和28.75mg·L^-1.在投加ρ（腐殖酸）为1mg·L^-1时SAA提高了7.37%, 40mg·L^-1时抑制率即达到36.80%,线性拟合表明腐殖酸对ANAMMOX菌的IC50为58.36mg·L^-1.修正的Michaelis-Menten模型能较...     

稻田微氧层和还原层土壤有机碳矿化对氮素添加的响应

田间条件下,淹水稻田由于上覆水中溶解氧的扩散作用,使其表层土壤存在约1 cm厚的微氧层,这个特殊层次中碳氮转化的特征尚未明晰.以亚热带典型稻田土壤为对象,采用100 d室内模拟培养试验,结合¹³C稳定同位素示踪和磷脂脂肪酸(PLFA)分析技术,研究稻田土壤微氧层(0～1 cm)和还原层(1～5 cm)外源新鲜有机碳(¹³C-水稻秸秆)和原有土壤有机碳矿化对氮肥施用[(NH₄)₂SO₄]的响应规律及其微生物过程.结果表明,氮素添加使土壤总CO₂和¹³C-CO₂累积排放量分别提高11.4%和12.3%;培养结束时,氮素添加下还原层比微氧层土壤总有机碳含量和¹³C回收率分别降低2.4%和9.2%.培养前期(5 d),氮素添加提高还原层微生物总PLFAs,且细菌和真菌PLFAs响应一致,但对微氧层微生物丰度无显著影响;氮素添加对微氧层和还原层总¹³C-PLFAs丰度均无显著影响...     

可见光促有机物诱导铁还原的多相类芬顿体系强化效能与机制

近年来,亚铁离子活化过硫酸盐的类芬顿(Fe²⁺-PMS/PS)高级氧化技术发展日趋成熟,但因Fe³⁺无法还原导致反应停止的问题仍制约其大规模应用.结果发现,当把以双酚A（BPA）为代表的某些有机物与Fe³⁺和TiO₂混合,所形成的某种络合物可以拓宽TiO₂光响应范围捕获可见光,通过TiO₂将光生电子传递给Fe³⁺进行还原,从而实现Fe³⁺/Fe²⁺的无限循环.依据上述原理,构建了可见光下BPA-TiO₂-Fe³⁺-PS复合体系来降解BPA,并对其催化性能、催化机制和影响因素进行探讨.结果表明,该体系具有突出的催化性能,60 min内BPA(50 mg·L^-1)降解率达到93.1%,矿化度达到70%.同时验证该体系可以通过双酚A自生光电子还原Fe³⁺, 60 min还原得到的Fe²⁺稳...     

缺氧MBBR耦合部分厌氧氨氧化强化城市生活污水深度脱氮

缺氧MBBR是强化传统城市污水处理系统脱氮的一种方法,本研究通过向城市污水后置反硝化SBR中投加填料构建了缺氧双污泥系统,实现了城市生活污水部分厌氧氨氧化深度脱氮.在250d的运行中脱氮性能逐渐提高并实现稳定,出水总氮在5 mg·L~(-1)左右. 211～250 d的平均硝氮、氨氮和总氮去除率分别为(97. 7±2. 9)%、(93. 3±2. 9)%和(94. 3±2. 7)%.长期运行中观测到氨氮和硝氮的同步去除.针对氨氮去除途径进行分析,系统同化、硝化作用微弱.缺氧MBBR中存在厌氧氨氧化活性且对脱氮有不可忽视的作用.实时定量PCR结果进一步说明缺氧MBBR中厌氧氨氧化菌富集,特别是缺氧填料生物膜中厌氧氨氧化菌丰度由初始的4. 37×10~7copies·g~(-1)增长到了2. 28×10~(10)copies·g~(-1).本研究表明缺氧填料生物膜在厌氧氨氧化的富集强化城市污水深度脱氮中或许具有可应用的潜能.     

石化废水深度处理用臭氧催化氧化体系的研究＊

文章就臭氧催化氧化体系在石化废水处理中的作用进行了深入研究,对催化剂载体、催化剂配伍体系以及臭氧的投加方式进行了优化筛选。根据实验,多元催化掺杂体系较一元催化体系氧化效果好,CODCr的去除率可由一元催化时的20%提高到多元催化时的33%;在臭氧的投加方式上,分段投加要优于单级投加,臭氧投加分配比例为6∶3∶1时,CODCr的去除率可由单一投加时的9%提高到分级投加时的19%。