水钴矿湿法冶金废渣抑制钴、钒浸出毒性工艺研究

以水钴矿湿法冶金废渣为研究对象,采取电化学辅助方法酸浸分离钴、钒并抑制其浸出毒性,考察了电辅助浸出时间、液固比、硫酸浓度、电流密度等因素对抑制废渣钴、钒浸出毒性的影响。结果表明:在浸出时间为120 min、硫酸浓度为600 mg/L、浸出液固比为10:1(mL/g)、电流密度为200 A/m ²条件下,经电化学辅助酸浸处理,水钴矿湿法冶金废渣的钴、钒、铜、锰、镍等重金属元素浸出毒性均明显降低;水平振荡法和硫酸硝酸法试验处理后的废渣钴浸出毒性分别降低99.1%和98.8%,钒浸出毒性分别降低91.7%和95.1%,较好实现了废渣浸出毒性的高效抑制和有价元素的分离回收。     

苯甲酸生产残液中锰、钴和镍的提取及分离

探讨了苯甲酸生产残液中锰、钴和镍的提取及分离方法。首先采用酸溶液提取残液中的金属元素;然后通过氨水沉淀法分离锰;最后使用p507萃取剂分离钴和镍。实验结果表明:当苯甲酸生产残液中锰、钴和镍的质量分数分别为0.085 0%,0.307 1%,0.015 5%时,在硫酸浓度为2.0 mol/L、过氧化氢溶液质量分数为25%的条件下,锰、钴和镍的提取率分别为88.59%,87.77%,86.50%;当氨水浓度为2 mol/L时,锰的沉淀率达94.24%;在平衡水相p H为4、p507萃取剂皂化率为60%、油相中p507萃取剂的体积分数为15%的条件下,钴萃取率达87.53%,镍萃取率仅为8.46%,钴镍分离系数为68.70。     

酸浸出法回收冶金污泥中的有价金属

采用二次酸浸出的方法回收镍钴湿法冶金工业污泥中的有价金属。先采用水和硫酸作为浸出剂浸出Mg和Na,最佳工艺条件为浸出液的pH 7.5、浸出时间5 min、浸出剂体积与干污泥质量的比(ω)为10 mL/g。再采用硫酸作为浸出剂、焦亚硫酸钠作为还原剂进行二次酸浸,在硫酸与污泥质量比为1.3、焦亚硫酸钠与污泥质量比为0.3、ω为5 mL/g、浸出温度85℃、浸出时间20 min的最佳工艺条件下,Co、Ni、Cu、Mn和Zn的浸出率分别达92.45%、93.48%、89.52%、97.78%和94.79%。经XRD表征,浸出后污泥中未见原污泥中的矿物相,说明原污泥中的矿物几乎全部被溶解。     

Impact of wastewater reuse on cobalt status in Egyptian environment

Cobalt is used in the manufacture of alloys,catalysts in the petroleum industry,catalytic converters,and paint pigments.Thus the potential for Co releases into the environment is highly increased.Use of waste sludges and sewage effluent to fertilize and irrigate soils has also increased soil Co concentrations.Total cobalt contents of alluvial delta soil of Egypt show considerable variation ranging from 13.1 to 64.7 ppm.The impact of either wastewater irrigation or industrial activities on soil total Co was obvious due to accumulation of organic matter and solid waste in the surface soil samples.Food crops and vegetables should not be grown on soil highly contaminated by Co.It is noteworthy that the delayed neutron activation analysis(DNAA)technique could be used successfully for total Co determination due to its high sensitivity.It is quit clearly that dust samples of Cairo City contains higher Co level.as compared to Suez Canal Region(Ismailia.Port Said and El-Suez cities).The high values in Cairo City may be due to the existence of industries around the city and the intensive traffic.To minimize Co environmental hazards,waste effluents should be treated on site.Thus,levels of potentially toxic Co needs to be continuously monitored and should be removed during several treatment processes before the disposal of these wastes.     

中国主要土壤对钴的吸附特征

对我国几种土类对钴吸附的研究表明,在平衡钴浓度不很高的条件下,土壤对钴的等温吸附表现为直线型,吸附量有明显的从南到北增加的趋势.通过修正竞争吸附方程对pH-钴吸附量曲线的描述,揭示出影响我国土壤对钴吸附容量的主要因素是粘土矿物类型,其次为土壤有机质及粘粒含量;随着土壤中铁锰氧化物的增加;其吸附强度增加.可变电荷高的土壤对钴吸附受pH的影响非常明显.永久电荷为主的土壤则不然.低的土壤pH可抑制铁锰氧化物对钴的强烈吸附.     

钴在土壤和植物系统中的迁移转化行为及其毒性

钴是人与动植物必需的微量元素,但土壤环境中过量的钴可通过土壤-粮食/蔬菜-人与动物等途径进入人体或动植物体内,对其产生危害,因此有必要了解土壤中钴的含量,应该将钴纳入必须检测与掌控的指标。然而,我国目前对于土壤中钴的含量却没有一个明确的评价体系,致使无法有效地对土壤中钴的含量进行评价和管控,从而给土壤以及人和动植物的健康都带来一定的风险。本文通过整理近20多年的国内外文献资料,综述了钴的特点、应用、形态、含量、毒性、评估方法,指出了现行对土壤中钴污染风险评估体系中存在的问题,并提出了今后的研究方向。     

钴与5-磺酸[杯(4)芳烃偶氮]氨基喹啉显色反应的研究及应用

合成了新试剂5-磺酸[杯(4)芳烃偶氮]氨基喹啉,并研究了该试剂与钴显色反应条件.结果表明,在pH＞12的碱性介质中,在TritonX-100存在下,CAQ与钴发生显色反应,生成1:1稳定络合物.λmax=650 nm,ε=4.80×104L·mol-1·cm-1,钴含量在0～1 200μg/L内符合比耳定律.方法用于矿样中钴的测定,结果令人满意.     

Bioaccumulation of cobalt,digestive enzyme activities,and growth of freshwater catfish,Heteropneustes fossilis (Bloch), fed cobalt-supplemented diets

Experiments were conducted to determine the effects of excess dietary cobalt (Co) on its bioaccumulation, on digestive enzyme activities, and on the growth of freshwater catfish Heteropneustes fossilis (Bloch). Four isonitrogenous diets (average crude protein: 32.7%) were formulated to prepare a control diet (T1) with no Co, and three Co-supplemented diets with 0.05 (T2), 0.1 (T3), and 1.0 (T4)% Co. The results showed that H. fossilis fed with T3 diet showed maximum apparent protein digestibility, feed conversion, protein utilization, and growth. Protease and lipase activities were also maximum in T3 diet. Accumulation of Co in different soft and hard tissues of the fish did not show any correlation with the level of Co in the diet. The concentration of Co in the water increased with its dietary level, being at an alarming level at 1.0% dietary Co. It is concluded that an additional supply of dietary Co up to a level of 0.1% is a viable option to augment growth of the catfish H. fossilis, but at higher levels of Co it may be detrimental to the fish and the aquatic ecosystem.     

水中钴测定方法的比对研究

通过对石墨炉原子吸收法、电感耦合等离子体质谱法、比色法测定水中钴的方法性能进行比对研究,分析了各自的优缺点,为实验人员对钴分析方法选择提供良好的技术依据。当测定钴含量为5.00%~99.5μg/L时,石墨炉原子吸收法的RSD为2.6%~3.9%,加标回收率为93.5%~101.4%;ICP-MS法的RSD为2.0%~3.3%,加标回收率为95.6%~97.1%;5-CI-PADAB光度法的RSD为3.8%~4.8%,加标回收率为91.6%~103.8%。     

PPy/TiO2光催化微生物燃料电池产电及在钴酸锂浸出中的应用

以无水氯化铁为氧化剂,碳纸为基板,通过化学氧化法制备聚吡咯/二氧化钛（PPy/TiO₂）光电阴极,采用XRD、IR、SEM对光催化材料进行表征.以碳纸为阳极;碳纸、TiO₂改性碳纸和PPy/TiO₂改性碳纸为阴极,构建双室微生物燃料电池（MFC）.在光照条件下,研究了MFC废水处理效果、产电性能及阴极钴酸锂的浸出情况.结果表明：PPy/TiO₂改性碳纸最大功率密度为10425.7mW/m²,分别是碳纸和TiO₂改性碳纸的1.97和1.86倍;PPy/TiO₂改性碳纸阴极Co（Ⅱ）浸出率为47.8%,分别是碳纸和TiO₂改性碳纸的1.87和1.76倍.