Regulated and unregulated emissions from a diesel engine fueled with biodiesel and biodiesel blended with methanol

Experiments were carried out on a diesel engine operating on Euro V diesel fuel, pure biodiesel and biodiesel blended with methanol. The blended fuels contain 5%, 10% and 15% by volume of methanol. Experiments were conducted under five engine loads at a steady speed of 1800 rev min⁻¹ to assess the performance and the emissions of the engine associated with the application of the different fuels. The results indicate an increase of brake specific fuel consumption and brake thermal efficiency when the diesel engine was operated with biodiesel and the blended fuels, compared with the diesel fuel. The blended fuels could lead to higher CO and HC emissions than biodiesel, higher CO emission but lower HC emission than the diesel fuel. There are simultaneous reductions of NO_x and PM to a level below those of the diesel fuel. Regarding the unregulated emissions, compared with the diesel fuel, the blended fuels generate higher formaldehyde, acetaldehyde and unburned methanol emissions, lower 1,3-butadiene and benzene emissions, while the toluene and xylene emissions not significantly different.     

矿用防爆柴油机标准分析与研究

无轨辅助运输技术是当今世界上最先进的煤矿辅助运输技术,矿用柴油发动机作为无轨辅助运输设备的主要心脏部件之一,其许多参数都和煤矿安全密切相关。本文阐述了矿用防爆柴油机要求和特点、采用的技术措施、标准现状,同时对目前矿用防爆柴油机的标准进行了结构分析,提出了防爆柴油机标准要增加的内容。     

Emissions of particulate matter and associated polycyclic aromatic hydrocarbons from agricultural diesel engine fueled with degummed, deacidified mixed crude palm oil blends

Mixed crude palm oil(MCPO),the mixture of palm fiber oil and palm kernel oil,has become of great interest as a renewable energy source.It can be easily extracted from whole dried palm fruits.In the present work,the degummed,deacidified MCPO was blended in petroleum diesel at portions of 30% and 40% by volume and then tested in agricultural diesel engines for long term usage.The particulates from the exhaust of the engines were collected every 500 hr using a four-stage cascade air sampler.The 50% cut-off aerodynamic diameters for the first three stages were 10,2.5 and 1μm,while the last stage collected all particles smaller than 1μm.Sixteen particle bounded polycyclic aromatic hydrocarbons(PAHs) were analyzed using a high performance liquid chromatography.The results indicated that the size distribution of particulate matter was in the accumulation mode and the pattern of total PAHs associated with fine-particles(< 1μm) showed a dominance of larger molecular weight PAHs(4-6 aromatic rings),especially pyrene.The mass median diameter,PM and total PAH concentrations decreased when increasing the palm oil content,but increased when the running hours of the engine were increased.In addition,Commercial petroleum diesel(PB0) gave the highest value of carcinogenic potency equivalent(BaP eq) for all particle size ranges.As the palm oil was increased,the BaP eq decreased gradually.Therefore the degummed-deacidified MCPO blends are recommended for diesel substitute.     

柴油机排气微粒过滤催化处理技术及进展

介绍了柴油机微粒后处理催化捕集器特点 ,评述了过滤器催化再生方法 ,综述了蜂窝陶瓷载体涂层及催化剂活性组分研究现状。重点阐述了微粒再生催化剂研究进展及其发展趋势     

DOC系统催化性能的仿真和分析

以 Langmuire Hinshelwood机理为理论依据,基于MATLAB/Simulink 建立DOC系统的数值计算模型,研究不同参数(如空速、氧气浓度、NO2/NOx比例)对氮氧化物（NOx）、一氧化碳（CO）、碳氢化合物（HC）转化效率的影响, 并对部分工况进行了实验研究,从而验证数值模型的准确性。结果表明,空速的降低可以增大DOC对CO、HC、NO的氧化性能,这是由于排气在催化器内的反应时间增长。当排气温度为225～300 ℃时,减小空速对增大HC的氧化效率效果明显,当排气温度在175～450 ℃范围内,减小空速对增大NO的氧化效率影响明显;当O2浓度低于1%,排气温度在175～250 ℃时,CO转化效率增大,在250 ℃之后均接近100%。当O2浓度为10%时,温度的变化对CO的转化效率影响很小。当O2浓度大于1%时,温度的变化对NO的氧化效率影响较大;当排气温度在300～550 ℃时,NO2/NOx比例的变化对NO的转化效率影响较大。降低排气中NO2/NOx比例,能够在排气温度高于300 ℃时,明显提高NO的转化效率。     

Analysis of methanol and organometallic MnO2 fuels as alternative fuels in a diesel engine

In this study, methanol and organometallic MnO₂ fuels were used to improve the properties of diesel fuel. In addition, the effect of methanol fuel on engine oil and a piston ring was also examined experimentally in a four-cylinder, direct injection diesel engine running at 200 bar. Three different diesel fuels were prepared by adding 5, 10 and 15% methanol to diesel fuel. In order to prevent phase separation, 1% dodecanol was added to the mixture. Organometallic compounds of manganese were synthesised to prepare the solutions. The most effective amount and performance of anti-freeze were determined. From the results, it was observed that carbon monoxide emissions decreased and NOx emissions increased with the increase in the amount of methanol. On the other hand, organometallic MnO₂ increased the cetane number and decreased the freezing point, viscosity and flame temperature.     

Exposure to benzene,toluene, xylenes and total hydrocarbons among snowmobile drivers in Sweden

The exposure to benzene, toluene, xylenes and total hydrocarbons among 25 individuals exposed to exhaust from a snowmobile equipped with a two-stroke engine has been evaluated. Sampling was performed by pumped and diffusive sampling in parallel. There was a relatively bad agreement between the two air-sampling methods. The bad agreement can in part be explained by back diffusion of the substances from the samplers, a high face velocity, and deposition of droplets of unburned gasoline onto or in the vicinity of the samplers.

The levels of benzene ranged from not detectable (0.01 mg m⁻³) to 2.5 mg m⁻³. For toluene, xylenes and total hydrocarbons the exposure was 0.10–12.0, 0.05–13.0 and 0.90–273 mg m⁻³ respectively. The result from two measurements on individuals travelling on an open sleigh at the rear of the vehicle indicated higher levels of benzene, 0.7–0.8 mg m⁻³. Children are often riding as a passenger on a sledge and may thus have a higher exposure than their parents. This study indicates that spare time driving a snowmobile may cause a considerable exposure to benzene. Using a four-stroke engine equipped with a catalyst could reduce the exposure. To reduce the exposure for the passenger on a sleigh an extension of the exhaust pipe may be effective.     

对柴油机集成后处理系统催化性能的数值模拟

为研究柴油机集成后处理系统的催化性能,应用CFD软件建立包括尿素水溶液分解、一氧化氮氧化和NOx选择性催化还原化学反应的数值计算模型,计算在SCR催化器上游加装DOC和CDPF催化器后不同排气温度和氨氮比时系统的催化效率。结果表明：当温度达到300℃以上时,尿素分解效率可达81%左右;NO的氧化效率基本维持在45%~60%,系统具有很好的低温催化性能,200℃时NOx催化效率可达76.6%;当氨氮比为1.0时,大多数工况下NOx催化效率均高于90%,最高可达98.7%。通过台架实验验证了模拟结果与实验数据绝对误差在5%以内,表明模拟计算结果可靠,可为后处理系统的设计提供理论指导。     

Emissions of intermediate volatility organic compound from waste cooking oil biodiesel and marine gas oil on a ship auxiliary engine

Ship auxiliary engines contribute large amounts of air pollutants when at berth.Biodiesel,including that from waste cooking oil(WCO),can favor a reduction in the emission of primary pollutant when used with internal combustion engines.This study investigated the emissions of gaseous intermediate-volatile organic compounds(IVOCs) between WCO biodiesel and marine gas oil(MGO) to further understand the differences in secondary organic aerosol(SOA) production of exhausts.Results revealed that WCO ex...     

生物柴油发动机颗粒排放物粒径及其分布试验研究

为获取燃用不同比例生物柴油的发动机排放颗粒物粒径及其分布特性,对1台增压直喷式车用柴油机进行了台架测试.用80 L/min定量泵和装有直径90 mm的玻纤滤膜采样器在排气管内采样10 min,用激光粒度仪测量与分析颗粒粒径和分布.结果表明,随着发动机转速提高,排放颗粒粒径变小且分布更集中.干法众数对应的粒径级较大（约10～12 μm）且较集中,湿法众数的较小（约4～10 μm）且分散.用干法分析,发动机低速时,B100的Sauter平均直径d₃₂最大,纯柴油最小,而B20的结果介于二者之间.而高速时B20的粒径最大,纯柴油次之,B100最小.中数粒径d(0.5)的结果也反映这一趋势.用湿法分析,除了2?000 r/min点外, B20的d₃₂最大,B100次之,柴油最小.湿法众数比干法分散,因而d₃₂也较大.