Stabilization effects of surplus soft clay with cement and GBF slag

Utilization of industrial waste and surplus construction soft clay as construction material was recommended, and many attempts at geotechnical waste utilization were undertaken. This study aimed at the application of cement and a kind of industrial wastes, i.e. granulated blast furnace slag, on stabilization of surplus soft clay. The results showed that the cement and slag can successfully stabilize Ariake clays even though this high organic clay fails to be stabilized by lime and cement. Addition of slag in cement for stabilization induces higher strength than cement alone for longer curing time. The application of the cement with slag is more suitable than cement alone for stabilization because of economical consideration.     

测控系统及组态软件在危险环境中的应用

为了及时有效地监测与控制危险环境中的易燃易爆危险品,设计并组建了实验室条件下模拟监控应用系统,通过组态软件完成实时监测与控制.对模拟试验中数据处理方法和参数设计也进行了相关研究.     

两种复合早强剂对煤矿封孔水泥早强效果影响的研究

基于矿井复杂环境对封孔水泥提出的要求,引入２-丙烯酰胺基-２-甲基丙磺酸（AMPS）并复合聚羧酸减水剂,三乙醇胺（TEA）作为有机组分,氯化钠（氯化钙）为无机组分,模拟井下高湿环境,通过正交试验,考察了两种有机无机复合早强剂的制备。并通过SEM,TG和XRD等手段着重研究了两种复合早强剂水化3d对封孔水泥抗压强度的影响。结果表明,当氯化钠复合早强剂组分为氯化钠3%,三乙醇胺0.05%,聚羧酸0.3%,AMPS1%时;氯化钙复合早强剂组分为氯化钙1.5%,三乙醇胺0.04%,聚羧酸0.2%,AMPS1%时早强效果最好,抗压强度比基准组分别提高了328%和217%。     

稳定剂对电解锰废渣中高浓度可溶性锰稳定效果的影响

为满足大宗废渣经济性处理的需要,从碱性物质、磷酸盐、碳酸盐类药剂筛选出“物美价廉”稳定剂,考察了CaO、MgO和Ca10(PO4)6(OH)2及其与NaHCO3和Na3PO4的组合对电解锰废渣中的可溶性锰的稳定化效果,并采用矿物组成分析、锰价态分析和形态变化探讨可溶性锰固定机理.结果表明:投加10%MgO锰渣中可溶性锰固定率达到100%,9%CaO+5%NaHCO3和9%CaO+5%Na3PO4的组合实现可溶性锰固定率95%以上.上述3组稳定剂将可溶性Mn2+先转变为沉淀态锰进一步转变为高价态含锰物相.后两组中NaHCO3或Na3PO4的加入促进了Mn2+向Mn3+、Mn4+的转化.     

水泥窑共处置过程中水泥生料对Pb与Cd的吸附/冷凝特性

为了研究水泥窑共处置过程中水泥生料对Pb、Cd的吸附/冷凝特性,采用氮吸附仪和SEM(场发射扫描电镜)对水泥生料的基本物理性质(比表面积、孔径和微观表面积)进行研究;同时,利用小型试验装置对重金属Pb、Cd的氧化物(PbO、CdO)展开了吸附/冷凝研究. 结果表明:水泥生料的比表面积(2.49 m2/g)较小,微观表面结构致密无孔,因此,在水泥窑共处置过程中水泥生料对重金属的吸附/冷凝作用以冷凝为主. 进入控温立式炉的重金属可分为三部分:①冷凝在管壁上,其中Pb、Cd分别占各自入炉总量的67%～72%、58%～65%;②吸附/冷凝在水泥生料上,其中Pb、Cd分别占各自入炉总量的13%～17%、16%～21%;③随烟气释放到空气中,其中Pb、Cd分别占各自入炉总量的10%～18%、14%～26%. 水泥生料对Pb、Cd的吸附/冷凝特性均可用双常数方程拟合,线性拟合的相关系数均在0.95以上. 动力学方程拟合得到水泥生料对Pb、Cd的吸附/冷凝活化能,二者分别为5.827、6.050 kJ/mol,由此可预测水泥生料对Pb和Cd的吸附/冷凝量.      

水泥灰三相泡沫的形成机理与稳定性试验研究

针对高硫矿石容易发生氧化自燃的危险,通常的灌浆、注砂、注惰气和喷洒阻化剂等技术还存在一些不足,提出一种以水泥灰为基料的三相泡沫来预防硫化矿石自燃的新技术。该技术是将水泥灰和水按一定的比例混合,同时加入一定比例的发泡剂和稳泡剂后,经物理机械方式发泡形成,集固、液、气三相材料的防灭火性能与一体。理论分析了水泥灰三相泡沫的形成与衰变机理,并通过正交试验,对三相泡沫的发泡倍数与半衰期进行研究,最后采用单因素实验,定量分析灰水质量比,发泡剂和稳泡剂浓度对三相泡沫稳定性能的影响,得到最佳泡沫配方。结果表明:当灰水质量比为1:5,发泡剂浓度为5g/L,稳泡剂浓度为8g/L时,制得的三相泡沫发泡倍数达到6倍,半衰期达到6h以上。     

Validation of the UN test method N.5

Many substances react with water in such a way that flammable gases are formed. For transport issues this reaction may possess a considerable hazard especially if the cargo is wetted by rain or by water from other sources. In the UN Recommendations on the Transport of Dangerous Goods these kinds of problems are addressed. The UN test N.5 “Test method for substances which in contact with water emit flammable gases” corresponds to this hazard. Classification according to the test method is done by measurement of the gas evolution rate of the flammable gas by any suitable procedure. At BAM a gravimetric approach is used to measure the gas evolution rate. In this paper we present the evaluation of the apparatus by means of an absolute calibration routine utilizing a reaction where a known amount of gas is produced as well as the evaluation of important parameters influencing the gas evolution rate using different substances. It can be shown that the apparatus is capable of measuring absolute gas volumes as low as 6 mL with an acceptable error of about 17% as determined from the reaction of Mg with demineralized water.     

Air pollution protection by waste amorphous SiO2 utilization in Portland cement production

This papers deals with waste amorphous silica obtained from AlF₃ production. This is a waste material that could be used as additive in cement production. Results are encouraging although there are no large quantities of this material available (about 4000 t/yr). Experiments were performed with the addition of 2.5%, 5.0%, 7.5% and 10.0% mass of amorphous silica obtained from AlF₃ production. Flexural and compressive strengths of the prepared mortar samples with w/c = 0.50 and with the constant flow were determined. Experiments show that optimal quantity for the amorphous silica addition is 5% of the cement mass.     

浸取方式对废物水泥窑共处置产品中Pb,Cd和Ni浸出的影响

模拟煅烧试验制取含Pb,Cd和Ni的水泥熟料,并将其制成混凝土样品,通过水槽浸出试验研究间歇浸取方式对混凝土中Pb,Cd和Ni释放的影响. 结果表明:间歇碳化保存处理浸出液的pH为9.5～10.4,低于连续浸取处理浸出液的pH(10.3～11.0),而间歇自然保存处理的浸出液pH则与连续浸取处理浸出液的pH相近;间歇浸取过程的碳酸化作用增加了混凝土中Pb和Cd的释放,表现为间歇浸取碳化保存处理的累积浸出量最大(Pb和Cd分别为686和332 mg/m2),连续浸取处理的累积浸出量最低(Pb和Cd分别为480和203 mg/m2);间歇处理对Ni的释放影响与Pb和Cd的不同,连续浸取处理的累积浸出量最大,为155 mg/m2,而间歇碳化保存处理的累积浸出量(85 mg/m2)最小.      

氢氧化镁-壳聚糖复合絮凝剂对印染废水的脱色研究

使印染废水脱色是废水处理的重要问题,利用无枳／有机复合絮凝剂可取得优良的脱色效果。采用氢氧化镁一壳聚糖复合絮凝剂对印染废水进行脱色处理,研究了pH值、壳聚糖投加量、复合絮凝剂加入量等对脱色效果的影响。结果表明氢氧化镁一壳聚糖复合絮凝剂比单独使用氢氧化镁絮凝剂脱色效果好。壳聚糖是一种天然高分子化合物,是甲壳素的脱乙基产物。来源丰富,且具有无毒副作用、易降解等优点。利用壳聚糖作为复配剂制备的复合絮凝减少了镁盐的使用量,有效降低了废水处理成本,避免引起二次污染。