型煤燃烧固硫中的温度效应

以氧化钙作为固硫剂的型煤中适当加入Ｆｅ,Ｓｉ添加剂组分,燃烧生成新的固硫体系后进行了２种不同温度条件下的进样实验。１．型煤样品分成６份,进行逐渐升温实验,分别加热到１１７０℃－１２２０℃,温度间隔１０℃,恒温１／４ｈ,２．型煤样品分成７份,进行先升温后进样实验,将加热炉分别升温至要求温度１０００℃－１２２０℃＋后进样,温度间隔５０℃,恒温１／２ｈ,实验表明：在Ｆｅ,Ｓｉ体系的型煤燃烧过程中,当进样     

SBR法处理啤酒废水和味精废水进水方式的研究

采用SBR法处理啤酒废水和味精废水 ,研究了不同进水方式对SBR法处理效果的影响。试验结果表明 :啤酒废水采用限制曝气进水效果较好 ,瞬时进水和限制曝气进水效果相当 ;味精废水采用非限制曝气进水效果较好。通过动力学分析认为 :SBR反应器内的反应在限制曝气进水条件下以推流式进行 ,在非限制曝气进水条件下具有完全混合式的特点。     

废石粉渣制备混凝剂及其除浊净水效果研究

利用废石粉渣制备无机混凝剂,并研究所得初产品对硅藻土悬浮液和受污湖水样品进行处理的适宜操作条件以及除浊净水效果,结果表明,利用某些废石粉渣制备的混凝剂有较好效果,但制备工艺有待改善。     

Main particulate matter components in Saxony (Germany)

Aerosol filter samples have been collected nearby the industrialised basin of Leipzig in Saxony (Germany) at the research station Melpitz of the Institut für Troposphärenforschung e.V. (IfT). Time series (1992–1998) and a three year comparison (1995–1997) of two different aerosol filter sampling systems, the Sierra-Andersen-PM 10 high volume sampler (daily sample, PM 10 inlet) and the Rupprecht and Patashnik Co. Inc. Model Partisol 2000 (weekly sample, PM 10 and PM 2.5 inlet) are presented and discussed. The comparison of the different sampling systems and strategies yields small differences between the daily and weekly samples for mass and different ions, which may be influenced by sampling duration and flow rates. A general trend of change in aerosol composition was observed: Soot and Sulphate concentrations decreased whereas Nitrate and Ammonium concentrations increased. During summers the mass of coarse particles is higher than in other seasons. One reason could be found in the occurence of longer periods of dry ground surfaces enabling reemission of crustal and biological material. The time series have been integrated in a longer historical aerosol mass trend for Saxony and do show a good agreement. Since 1990 a significant downward trend in gravimetric mass concentration was found.     

测控系统及组态软件在危险环境中的应用

为了及时有效地监测与控制危险环境中的易燃易爆危险品,设计并组建了实验室条件下模拟监控应用系统,通过组态软件完成实时监测与控制.对模拟试验中数据处理方法和参数设计也进行了相关研究.     

混合药物粉尘输运过程静电特性实验研

兽药制药粉尘加工工艺过程中,由于粉尘颗粒之间或颗粒与设备、管壁之间的碰撞、摩擦,导致装置内部静电荷量积聚,激发静电放电,粉尘燃烧或爆炸的事故频发。实验主要通过包括粉尘与管材摩擦的漏电电流测试和静电放电火花对粉尘云点燃敏感性测试两部分。结果表明:单一药物药粉的静电漏电电流随着管材管径的增大,管长的增长,静电漏电电流逐渐变大;随着倾斜角的增大,静电漏电电流先增大后降低;镀锌铁管的漏电电流大于PVC管,电荷逸散速度更快。单一兽药粉的粉尘云放电火花最小点燃能量随质量浓度的变化,呈现二次曲线的变化趋势。混合兽药粉与单一兽药粉的漏电电流和粉尘云放电火花最小点燃能量的测试结果的变化趋势是一致的。     

稳定剂对电解锰废渣中高浓度可溶性锰稳定效果的影响

为满足大宗废渣经济性处理的需要,从碱性物质、磷酸盐、碳酸盐类药剂筛选出“物美价廉”稳定剂,考察了CaO、MgO和Ca10(PO4)6(OH)2及其与NaHCO3和Na3PO4的组合对电解锰废渣中的可溶性锰的稳定化效果,并采用矿物组成分析、锰价态分析和形态变化探讨可溶性锰固定机理.结果表明:投加10%MgO锰渣中可溶性锰固定率达到100%,9%CaO+5%NaHCO3和9%CaO+5%Na3PO4的组合实现可溶性锰固定率95%以上.上述3组稳定剂将可溶性Mn2+先转变为沉淀态锰进一步转变为高价态含锰物相.后两组中NaHCO3或Na3PO4的加入促进了Mn2+向Mn3+、Mn4+的转化.     

Validation of the UN test method N.5

Many substances react with water in such a way that flammable gases are formed. For transport issues this reaction may possess a considerable hazard especially if the cargo is wetted by rain or by water from other sources. In the UN Recommendations on the Transport of Dangerous Goods these kinds of problems are addressed. The UN test N.5 “Test method for substances which in contact with water emit flammable gases” corresponds to this hazard. Classification according to the test method is done by measurement of the gas evolution rate of the flammable gas by any suitable procedure. At BAM a gravimetric approach is used to measure the gas evolution rate. In this paper we present the evaluation of the apparatus by means of an absolute calibration routine utilizing a reaction where a known amount of gas is produced as well as the evaluation of important parameters influencing the gas evolution rate using different substances. It can be shown that the apparatus is capable of measuring absolute gas volumes as low as 6 mL with an acceptable error of about 17% as determined from the reaction of Mg with demineralized water.     

轧钢污泥综合利用的技术研究

阐述了一种轧钢污泥的回收处理技术,该技术可把轧钢污泥有效地分离成氧化铁粉和混合油,实现综合利用,减少铁素资源浪费,有良好的经济效益和环境效益.     

大豆蛋白粉喷雾干燥塔尾气余热的回收与利用

针对大豆蛋白粉生产过程中喷雾干燥塔尾气温度较高,有回收利用价值的现实,也针对目前的节能需求,对现有的喷雾干燥塔的尾气排放部分进行改造,设计一个片状空气预热器,以利用高温的尾气与系统的进气做热交换,实现热量再利用,降耗和提高蛋白粉产率的目的,并对投资收益进行了分析。