Experimental study on explosion inhibition by heptafluoropropane and its synergy with inert gas

The inhibition effect of heptafluoropropane (CF₃CHFCF₃) on methane explosions under different inhibitor concentrations in a closed vessel was studied. A high-speed camera and a pressure sensor were adopted respectively to record flame propagation characteristics and pressure data. Results indicate that the relationship between flame propagation and pressure rising was correlated. As the equivalent ratio (ϕ)≤1, the pressure presented a trend of rising firstly and then decreasing with increasing CF₃CHFCF₃ concentration, and it was found that there existed a critical concentration for pressure decrease. As ϕ > 1, the pressure exhibited a decreasing trend. Although the pressure appeared to seemingly increase, the moment that the pressure began to rise (t_rise) and the moment that the maximum explosion overpressure appeared (t_Pmax) were obviously delayed. The average rate of pressure rise ((dP/dt)_ave) was decreased as the concentration of CF3CHFCF3 increased. It indicates that CF₃CHFCF₃ can effectively reduce the explosion reaction rate. The critical concentration of CF₃CHFCF₃ for complete inhibition was determined. Meanwhile, the synergy of CF₃CHFCF₃-inert gas can improve the inhibition effect. Compared with CF₃CHFCF₃–N₂, the synergy of CF₃CHFCF₃–CO₂ presented a better inhibition effect, and the inhibition effect was increased with increasing inert gas concentration. And the mechanisms of physical and chemical effects on explosion inhibition were analyzed.     

煤矿火灾烟气流动传播过程仿真研究

煤矿发生火灾后会生成大量有毒气体并产生火风压,烟气在火灾动力的影响下出现状态紊乱,研究煤矿火灾烟气流动传播过程对控制火情有着重要意义。基于国内外研究现状,对燃烧及风流特点进行分析,建立了煤矿火灾烟气流动数学模型,并利用CFD软件进行仿真。研究表明:无通风工况下的烟气为对称流动;随着风速增加,出口处温度降低,烟气向风流入口处的流速减小。     

Effects of particle thermal characteristics on flame microstructures during dust explosions of three long-chain monobasic alcohols in a half-closed chamber

To reveal clearly the effects of particle thermal characteristics on flame microstructures during organic dust explosions, three long-chain monobasic alcohols, solid at room temperature and similar in physical-chemical properties, were chosen to conduct experiments in a half-closed chamber. In the experiments, the dust materials were dispersed into the chamber by air to form dust clouds and the hybrids were ignited by an electrical spark. A high-speed optical schlieren system was used to record the flame propagation behaviors. A fine thermocouple and an ion current probe were respectively used to measure the flame temperature profile and the reaction behaviors of the combustion zone. Based on the experimental results, combustion behaviors and flame microstructures in dust clouds with different thermal characteristics were analyzed in detail. As a result, it was found that the dust flame surfaces were completely covered by cellular structures that significantly increased the flame frontal areas. Flame propagated more quickly and the number of the cellular cells increased as increasing the volatility of the particles. On the contrary, maximum temperature and the thickness of the preheated zone decreased as increasing the volatility of the particles. According to the ion current profile, the particles in the preheat zone were pyrolyzed to intermediate radicals and the radicals' fraction in the higher volatile dust flame was higher than that in the lower volatile dust flame.     

爆炸空气冲击波在巷道转弯处的传播特性

为了探索爆炸空气冲击波在巷道内的传播规律,进行了数值计算和理论分析,讨论了爆炸冲击波通过45°弯曲巷道后的压力变化过程.研究结果表明: 爆炸空气冲击波通过45°弯曲巷道后的压力分布复杂,空气冲击波逐渐恢复为平面波需经过4倍等效巷道直径的距离传播.在该4倍等效距离内,冲击波反射叠加,在巷道外侧壁面Mach反射点取得超压最大值,恢复平面波以后超压随距离呈单调衰减.     

第二松花江中下游沉积物汞的时空变化规律

将1973、1976、1983、1991年和本次的研究结果进行对比分析,得出了第二松花江中下游表层沉积物汞含量的时间变化规律.1976年以前汞含量处于增加趋势;1976～1982年汞含量有所下降;1982年汞污染源被切断,汞含量骤降;随后,汞污染浓度处于缓慢净化时期.将本次采集的沉积物样品分为3个粒度等级,最后以63 μm粒级的沉积物汞含量为代表分析了汞的水平变化规律,总体趋势是,排污口处汞含量最高;哨口至朝阳桥断面汞含量增加;朝阳桥至五家站断面,汞含量骤降,在五家站断面汞含量达到最小值;五家站至泔水缸断面汞含量又略有增加.并给出了本次研究中各断面沉积物汞的垂直变化规律.     

水平管内不同煤质煤尘爆炸火焰传播特性实验研究

为研究水平管道空间不同煤质煤尘爆炸火焰传播特性,选取褐煤、长焰煤、不粘煤、气煤4种煤尘,对爆炸火焰焰峰特性、火焰加速传播特性、火焰传播距离与持续时间展开研究。研究结果表明:褐煤在500 ms内焰峰的形状由尖锐向平滑再向钝化不断演变,长焰煤与不粘煤在375 ms时焰峰前端出现明显焰体分离现象,分析认为这与管体冷壁效应、空间尺度效应及空间氧气消耗直接相关;气煤在375 ms时焰峰出现大面积火焰碎纹,说明气煤爆炸火焰猛烈传播的持续时间相对较短,整体爆炸强度相对较弱;褐煤与长焰煤爆炸火焰存在2次间断性加速,分析认为这与管体空间受限、常温管壁散热、局部助燃氧气瞬间不足等因素有关;褐煤在爆炸后400～600 ms内火焰2次加速完全,火焰传播距离达740 mm,明显大于长焰煤、不粘煤与气煤,说明低变质褐煤爆炸火焰持续时间更长,火焰传播距离更远且传播更剧烈;虽然气煤火焰最远传播距离比长焰煤大30 mm,但由于气煤火焰在375 ms左右出现大片火焰碎纹,因此气煤整体的爆炸强度小于长焰煤。     

西昌高原鳅人工繁殖技术研究

对西昌高原鳅(Triplophysa xichangensis)人工繁殖中的催产药物及其剂量、受精方式、孵化方法和仔鱼水花培育方法等一系列关键技术进行了详细研究。结果表明,对性腺发育至Ⅳ+~Ⅳ++期的雌鱼分二次注射LRH-A2 0.1μg/g(鱼体重)和HCG 20 IU/g(鱼体重),雄鱼剂量减半,注射量0.1 mL,能很好地促进雌雄鱼发情并产卵排精,在水温19±0.5℃时的效应时间为30.5~31 h;在一个特制的塑料盆中完成了亲鱼培育、打针催产、发情、自然产卵受精、孵化以及仔鱼培育等全部人工繁殖过程,受精率、孵化率和仔鱼水花培育20 d的成活率平均分别为97.2%、85%和85%。本研究成果可应用于西昌高原鳅规模化繁育,对长江上游鱼类生物多样性保护有着积极意义。     

含磷酸盐对聚乙烯粉尘爆燃的抑制影响实验研究

为了揭示含磷酸盐(KH₂PO₄,NH₄H₂PO₄,Ca(H₂PO₄)₂)对聚乙烯粉尘爆炸的抑制作用,通过哈特曼管实验装置和20 L球形爆炸罐,研究含磷酸盐对聚乙烯粉尘爆炸火焰和压力传播特性的抑制效果。采用高速摄影方法记录含磷酸盐对聚乙烯粉尘爆炸火焰传播的影响;采用20 L球形爆炸罐,收集压力传感器数据,分析含磷酸盐对聚乙烯粉尘爆炸压力的影响;采用同步热分析仪研究聚乙烯粉尘和含磷酸盐的热解行为。研究结果表明：含磷酸盐对聚乙烯粉尘爆炸火焰传播特性参数和爆炸压力特性参数均有显著的影响,通过对比得到NH₄H₂PO₄抑制效果相对最好。研究结果可为含磷酸盐在抑爆剂工程应用提供理论基础。     

Numerical study on premixing characteristics and explosion process of starch in a vertical pipe under turbulent flow

Fire and explosion accidents are frequently caused by combustible dust, which has led to increased interest in this area of research. Although scholars have performed some research in this field, they often ignored interesting phenomena in their experiments. In this paper, we established a 2D numerical method to thoroughly investigate the particle motion and distribution before ignition. The optimal time for the corn starch dust cloud to ignite was determined in a semi-closed tube, and the characteristics of the flame propagation and temperature field were investigated after ignition inside and outside the tube. From the simulation, certain unexpected phenomena that occurred in the experiment were explained, and some suggestions were proposed for future experiments. The results from the simulation showed that 60–70 ms was the best time for the dust cloud to ignite. The local high-temperature flame clusters were caused by the agglomeration of high-temperature particles, and there were no flames near the wall of the tube due to particles gathering and attaching to the wall. Vortices formed around the nozzle, where the particle concentration was low and the flame spread slowly. During the explosion venting, particles flew out of the tube before the flame. The venting flame exhibited a “mushroom cloud” shape due to interactions with the vortex, and the flame maintained this shape as it was driven upward by the vortex.     

金属丝网对甲烷/空气预混火焰管道内传播的影响

为研究管道内金属丝网对甲烷/空气预混火焰传播的影响,通过实验和三维数值模拟研究安装金属丝网的管道内火焰传播特性以及流场、温度场的变化。结果表明:40目4层的金属丝网可以使火焰淬熄,30目4层的金属丝网无法淬熄,但可以使火焰停滞3 ms;大涡模型可以很好地对管道内火焰淬熄现象进行模拟;当火焰穿过30目4层金属丝网时,速度增大,在Kelvin Helmholtz不稳定和Rayleigh Taylor不稳定的耦合作用下形成湍流;金属丝网的目数会影响热量在丝网层中的扩散,当金属丝网为30目4层时,火焰热量扩散快,而当金属丝网为40目4层时,火焰热量扩散慢且温度大幅度衰减,衰减率达到83%。