立体抽采条件下高瓦斯采空区煤自燃危险性预测

为准确预测高瓦斯采空区煤自燃的状况,通过分析发现高抽巷是监测采空区遗煤自然发火的最有效地点。推算出采空区气体在高抽巷中所占的体积分数,进而确定采空区遗煤不同的燃烧阶段所对应的CO体积分数和CO指数。结果表明:当高抽巷中的CO体积分数Chdr CO<30×10-6或CO指数ICO<0.5%时,采空区的遗煤处于低温氧化阶段;当高抽巷中的CO体积分数Chdr CO≥30×10-6或CO指数ICO≥0.5%时,采空区遗煤进入自然发火危险阶段,此时必须采取措施控制采空区自燃氧化的进一步发展。对80501工作面的采空区煤自燃成功地进行预测预报,实现了安全生产。     

干燥条件下高硫煤低温氧化特性研究

为进一步揭示不同环境条件下高硫煤的低温氧化特性,选取含硫量较低、自燃倾向性较高的褐煤,向其添加不同比例的FeS2,配制成含量分别为3%,5%,7%的混合高硫煤样,利用中国矿业大学自行研制的煤氧化模拟试验系统,测试分析干燥混合煤样在低温氧化过程中,交叉温度和指标气体CO产生量体积的变化。试验结果表明,在低温干燥的条件下,随着FeS2含量的增加,煤样的氧化特性受到抑制:交叉点温度升高;指标气体CO产生量在相同温度时体积降低。因此,在高硫煤层自燃火灾防治过程中,应尽量控制煤层周围环境的干燥度。     

可燃气体燃爆特性综合试验装置构建与甲烷试验

为研究半开敞空间内可燃气体爆炸过程,设计带有泄压面的气体爆炸室,并在此基础上构建一套可燃气体燃爆特性综合试验装置。运用该试验装置,研究预混塔内甲烷气体分层现象以及甲烷爆炸浓度与最小点火能之间的变化规律。甲烷分层试验结果表明:静置一段时间后,预混塔中甲烷浓度随高度的增加而增大。最小点火能试验结果显示,当甲烷的试验爆炸体积分数在10%～13%时,其浓度与点火能之间呈现比较平缓的变化关系,而当其体积分数小于10%或大于13%时,浓度稍微变化,其点火能将发生明显变化。     

基于重要性分析的甲烷/乙烯混合燃烧框架机理构筑

建立了基于重要性分析的详细化学机理分析平台,利用耦合组分化学存活时间和敏感性系数的重要性参数,确定详细机理中的准稳态组分,通过移除这些组分及其相关反应,得到了计算精度较高的框架机理。针对目前燃烧学界较为关注的混合燃烧问题,以甲烷、乙烯这两种典型低碳碳氢燃料为研究对象,对其详细化学反应机理进行了分析,利用重要性分析法构筑框架机理,并对甲烷/空气和甲烷/乙烯/空气预混火焰进行了数值计算。与详细机理相比,框架机理所涉及的组分数与基元反应数都得到了大幅度的降低,计算时间明显减少,但对火焰温度及反应物、生成物、中间组分浓度的预测与采用详细机理得到的结果吻合良好,证明了重要性分析法的有效性与可靠性。     

约束空间可燃气体燃烧爆轰特性的数值研究

在可燃气体的输送、贮存、加工和使用过程中,容易发生可燃气体的燃烧和爆炸事故。文中基于有限体积方法,采用五阶WENO格式进行左右状态量的重构后,利用ROE格式进行空间离散,自行开发程序对甲烷氧气的气相爆轰波传播过程进行了数值研究。计算结果表明:在CH4质量分数为10%的混合气体中,高温高压气团可诱导气相发生爆轰,爆轰波以2133.3 m/s的速度传播。在带有障碍物的约束空间内,文中分析了障碍物不同高度、不同间距条件下爆轰波传播时波的绕射、马赫反射等现象,给出障碍物表面压力随时间变化历程和冲量值,揭示波与障碍物的相互作用机理以及由此引发流场的变化规律,为有效地控制可燃气体的燃烧速率、防治爆炸灾害的发生提供理论依据。     

Reaction mechanism of arsenic capture by a calcium-based sorbent during the combustion of arsenic-contaminated biomass: A pilot-scale experience

Pilot-scale combustion is required to treat arsenic-enriched biomass in China. CaO addition to arsenic-enriched biomass reduces arsenic emission. CaO captures arsenic via chemical adsorption to form Ca₃(AsO₄)₂. Large quantities of contaminated biomass due to phytoremediation were disposed through combustion in low-income rural regions of China. This process provided a solution to reduce waste volume and disposal cost. Pilot-scale combustion trials were conducted for in site disposal at phytoremediation sites. The reaction mechanism of arsenic capture during pilot-scale combustion should be determined to control the arsenic emission in flue gas. This study investigated three Pteris vittata L. biomass with a disposal capacity of 600 kg/d and different arsenic concentrations from three sites in China. The arsenic concentration in flue gas was greater than that of the national standard in the trial with no emission control, and the arsenic concentration in biomass was 486 mg/kg. CaO addition notably reduced arsenic emission in flue gas, and absorption was efficient when CaO was mixed with biomass at 10% of the total weight. For the trial with 10% CaO addition, arsenic recovery from ash reached 76%, which is an ~8-fold increase compared with the control. Synchrotron radiation analysis confirmed that calcium arsenate is the dominant reaction product.     

Sources of underground CO: Crushing and ambient temperature oxidation of coal

As a harmful gas in underground coal mine, CO seriously threatened the safety of miners. Currently, the spontaneous combustion of residual coal in goaf is generally considered as the main source of underground CO. CO gas is also widely used as an indicator gas in fire prediction in mines. However, high concentrations of CO are also detected in some mines without spontaneous combustion of coal. Therefore, in the paper, with four ranks of coal, we studied other two potential CO sources: crushing and oxidation at ambient temperature. The more completely crushed coal produces more CO. The concentration of generated CO is inversely proportional to moisture content in coal. Therefore, the addition of water can inhibit the generation process of CO during the crushing process of coal. Lignite with low metamorphic grade can be oxidized to produce CO at ambient temperature (25 °C), and anthracite with high coal rank can be only oxidized to produce CO at 60 °C. Infrared spectra indicated that the coal with rich aliphatic hydrocarbons and oxygen-containing functional groups are more susceptible to oxidation at room temperature. Moreover, the smaller particle size of coal is more beneficial to the oxidation at ambient temperature to generate CO. CO generation during coal oxidation is also closely related to the ventilation rate.     

采空区注超临界CO2防灭火试验研究

为研究超临界CO₂注入采空区防灭火的规律,自主研制了产生超临界CO₂和模拟采空区遗煤自燃升温试验系统,得到了不同温压条件下超临界CO₂注入采空区前后不同监测点的温度、O₂和CO浓度变化数据信息。试验结果表明:注入采空区的超临界CO₂发生相变,有序结构急速失序,大量吸收热量,采空区内的煤体、空气温度随时间呈线性快速下降规律,其降温能力是气态N₂的10倍;超临界CO₂在自燃发火煤体中的强渗透扩散特性,使自燃煤体快速惰化,防灭火效率高;停止注入后,小范围回温符合反二次函数特征;高压力超临界CO₂相对于低压条件,防灭火性能更佳;超临界CO₂是1种降温降氧能力显著,且输送性能优良的采空区新型防灭火材料,超临界CO₂防灭火效果优于气态N₂。     

从节能角度谈住宅建设的现状与发展趋势

通过对节能住宅与一般住宅的成本比较分析,结合目前国内外能源状况和中国已有住宅房屋能耗现状及国家政策法规对节能住宅的建设支持,阐述建设节能住宅的重要意义、建议及未来住宅建设的发展趋势.     

燃煤电厂排放颗粒物中重金属形态的研究

本文分析用模拟酸雨浸提和Ｔｅｓｓｉｅｒ形态分离法，对燃煤电厂排放颗粒物中重金属形态进行了研究。结果表明，痕量金属绝大部分以稳定态存在，微米级飞灰中有较大活性的形态高于灰渣，煤燃烧高温条件使颗粒物中活性较大的形态含量减小。