Degradation of azo dyes in water by Electro-Fenton process

The degradation of the azo dyes azobenzene, p-methyl red and methyl orange in aqueous solution at room temperature has been studied by an advanced electrochemical oxidation process (AEOPs) under potential-controlled electrolysis conditions, using a Pt anode and a carbon felt cathode. The electrochemical production of Fenton's reagent (H₂O₂, Fe²⁺) allows a controlled in situ generation of hydroxyl radicals (^·OH) by simultaneous reduction of dioxygen and ferrous ions on the carbon felt electrode. In turn, hydroxyl radicals react with azo dyes, thus leading to their mineralization into CO₂ and H₂O. The chemical composition of the azo dyes and their degradation products during electrolysis were monitored by high performance liquid chromatography (HPLC). The following degradation products were identified: hydroquinone, 1,4-benzoquinone, pyrocatechol, 4-nitrocatechol, 1,3,5-trihydroxynitrobenzene and p-nitrophenol. Degradation of the initial azo dyes was assessed by the measurement of the chemical oxygen demand (COD). Kinetic analysis of these data showed a pseudo-first order degradation reaction for all azo dyes. A pathway of degradation of azo dyes is proposed. Specifically, the degradation of dyes and intermediates proceeds by oxidation of azo bonds and aromatic ring by hydroxyl radicals. The results display the efficiency of the Electro-Fenton process to degrade organic matter. Electronic Publication     

三硝基甲苯的γ-辐照降解实验研究

基于三硝基甲苯(TNT)溶液采用常规处理方法难以降解,采用60Co-γ射线对三硝基甲苯溶液进行辐照降解,研究了吸收剂量、初始浓度、溶液初始pH值、双氧水(H2O2)等因素对辐照降解效果的影响.实验结果表明,60Co-γ射线辐照能够有效地降解三硝基甲苯.三硝基甲苯溶液初始浓度为5—50 mg.L-1,当接受不超过15 kGy剂量时,三硝基甲苯的降解率可达100%,化学需氧量(COD)去除率可达55%;弱酸性和碱性环境更有利于三硝基甲苯的降解和COD的去除;加入少量H2O2时,三硝基甲苯降解率和COD去除速率均随之增加,但过高的H2O2加入量将会抑制三硝基甲苯的去除,并且加入H2O2的量愈大其抑制作用愈明显.     

Abating whey organic load through ethanol and lactic acid production by kefir

Abstract

The extent to which selected ethanol and lactic acid production bioprocesses contribute to whey waste abatement was examined. Alcoholic fermentation of whey was carried out by kefir cells immobilized on grape stalks, delignified cellulosic materials, or brewer's spent grains. Lactic acid fermentation was also performed by free kefir cells with or without addition of brewer's spent grains as promoting material. Since whey fermentation rate is affected by the lactose uptake rate, ¹⁴C-labeled lactose was used to study the fermentation ability of kefir. The highest reductions in biochemical oxygen demand and chemical oxygen demand of whey, about 68% and 52%, respectively, were achieved by lactic acid fermentation in 6 h at 37 °C and pH 5.5, in the presence of 120 g brewer's spent grains. Additionally, at the same conditions, the highest ¹⁴C-labeled lactose uptake rate by kefir and consequently the highest alcoholic fermentation rate were also recorded. However, greater reductions in biochemical oxygen demand and chemical oxygen demand of whey are required prior to final disposal.     

有效微生物(EM)处理食品废水的试验研究

针对有效微生物群(EM)中含有好氧和厌氧微生物的特点,采用SBR反应器,进行了用EM处理食品废水的试验研究.结果表明,当进水COD_Cr为2 000～4 000 mg/L,pH为5.5～6.5时,向废水中投加0.5%～0.7%的EM复壮液,曝气12 h,沉淀10 h,COD_Cr的质量浓度可降为700～2 000 mg/L,COD_Cr去除率可达83.0%.      

循环式活性污泥法中厌氧生物选择区的运行条件研究

研究了循环式活性污泥法中厌氧生物选择区的停留时间、进水有机物浓度和系统中泥龄、曝气时间等运行参数对选择区内厌氧释磷以及有机物的吸收贮存的影响。结果表明，选择区停留时间lh，系统泥龄5d，曝气2h，进水有机物浓度COD／TP=60--70，选择器中释磷效果及微生物的吸附性能最优，可去除进水中78％的COD。而且污泥沉降性能良好，试验运行过程中，SVI一直保持在30--40ml／g左右。     

前处理残余铝对曝气池活性污泥的影响规律研究

从活性污泥的絮凝特点、有机物与 NH 4-N 的微生物代谢过程等方面探讨前处理残余铝对曝气池活性污泥的影响规律.结果显示,随着进水Al3 浓度的不断增加,污泥瞬时沉降速度明显增加,而对污泥沉降比影响不大.Al3 对COD去除率基本上没有影响,而对废水中 NH 4-N 氧化过程的影响却非常明显,随着活性污泥中Al3 的逐渐增加, NH 4-N 去除率出现了先升后降的变化趋势. NH 4-N 去除率下降的趋势与Al3 对微生物细胞膜电解质透性的影响规律呈负相关关系,说明Al3 对氨氧化微生物种群的干扰作用最强.     

臭氧辅助UV/Fenton法处理电镀添加剂生产废水

采用臭氧辅助光芬顿法处理电镀添加剂生产废水,考察双氧水、FeSO₄·7H₂O、pH和反应时间等因素对废水COD和UV₂₅₄去除的影响。实验结果表明,pH=4,臭氧通入量为0.25 g,双氧水的投加量93.3 mL/L,FeSO₄·7H₂O投加量为5.3 g/L,最佳反应时间为30 min,COD和UV₂₅₄去除率分别达到92.64%和87.95%。这表明,臭氧辅助光芬顿法对电镀添加剂生产废水处理效果显著,处理时间大大减少。     

酸解破乳作用处理高含固率洗毛废水的研究

洗毛废水是一种高浓度有机废水,含固率高,主要成分是羊毛脂、羧酸盐和土杂,由于强极性物质的存在和胶体强的负电性,导致洗毛废水形成稳定的乳化体系.本试验通过加入硫酸改变洗毛废水的有机组成,降低体系的Zeta电位,破坏体系的稳定性,从而使得有机物发生凝聚沉降,达到去除COD的目的.硫酸加入量达到0.2%或以上时对洗毛废水中SS的自然沉降性、絮凝性和极性有很大影响,比阻从远大于9.81×1013m/kg,下降为5.54×1010m/kg,COD去除率达到86.8%,SS去除率达到98%.因此,洗毛废水加酸处理后通过机械脱水,实现固液分离,以降低原废水的色度和大幅降低COD的方式,是可供考虑的处理工艺.     

类Fenton氧化技术去除榨菜生产废水COD的研究

研究了紫外光照射下类Fenton试剂对榨菜生产废水COD的去除,考察了光照时间、初始pH值、过氧化氢用量、FeCl₃·6H₂O用量等因素对榨菜废水中COD去除率的影响。结果表明,光照时间60 min,初始pH值3,H₂O₂（30%）的用量为理论值的120%,c₀(H₂O₂)∶c₀［Fe(Ⅲ)］=11.6∶1.0时,COD去除率效果为最佳,达到79%。当H₂O₂投加总量不变时,去除率随着投加次数的增多而增大。     

印染废水污染物在曝气生物滤池中的沿程去除规律

主要研究了曝气生物滤池（BAF）对印染废水中污染物的沿程去除规律。研究表明：BAF对印染废水污染物的去除沿高程有着不同的变化规律：在BAF总高度为300 cm,填料层高度为200 cm,气水比3∶1,停留时间11.8 h,的情况下, BAF对COD的去除主要集中在<160 cm的填料层部分,在总的去除率为63.1%时,此区域去除率可达56.60%;对NH3N的去除主要集中在填料层100～160 cm段,在总NH₃-N去除率为85.09%时,此区域NH₃-N去除率达38.28%。BAF对浊度的去除主要集中在填料层小于100 cm的部分,在总去除率为94.04%,区域去除率达到61.90%。印染废水经过BAF的前100 cm填料层后,pH值由10降至7.6后基本维持不变。