Fe2O3 particles as superior catalysts for low temperature selective catalytic reduction of NO with NH3

Fe203 particle catalysts were experimentally studied in the low temperature selective catalytic reduction （SCR） of NO with NH3. The effects of reaction temperature, oxygen concentration, [NH3]/[NO] molar ratio and residence time on SCR activity were studied. It was found that Fe203 catalysts had high activity for the SCR of NO with NH3 in a broad temperature range of 150-270℃, and more than 95% NO conversion was obtained at 180℃ when the molar ratio [NH3]/[NO] = 1, the residence time was 0.48 seconds and 02 volume fraction was 3%. In addition, the effect of SO2 on SCR catalytic activity was also investigated at the temperature of 180℃. The results showed that deactivation of the Fe2O3 particles occurred due to the presence of SO2 and the NO conversion decreased from 99.2% to 58% in 240 min, since SO2 gradually decreased the catalytic activity of the catalysts. In addition, X-ray diffraction, Thermogravimetric analysis and Fourier transform infrared spectroscopy were used to characterize the fresh and deactivated Fe2O3 catalysts. The results showed that the deactivation caused by SO2 was due to the formation of metal sulfates and ammonium sulfates on the catalyst surface during the de-NO reaction, which could cause pore plugging and result in suppression of the catalytic activity.     

复合催化膜生物反应器处理一氧化氮废气研究

采用溶胶-凝胶法以聚砜(PSF)中空纤维膜为载体制备了Fe-Ti O_2/PSF复合催化膜,以此构建新型复合催化膜生物反应器(HCMBR),实现膜催化与硝化反硝化耦合烟气脱硝,进一步提高NO去除能力.采用Fe-Ti O_2/PSF复合催化膜生物反应器(HCMBR)处理一氧化氮废气,实现了180 d长时间高效稳定运行,NO去除效率可达93.2%,去除能力可达167.1g·(m~3·h)~(-1).适宜运行条件为:气体停留时间9 s、自然光光照强度670 lx,p H为6.8~7.2,n C/n N=3.7.Fe-Ti O_2/PSF复合催化膜加入,复合催化膜生物反应器去除NO的效率比膜生物反应器提高了1.4%~13%,在Fe-Ti O_2/PSF复合催化膜附着稳定的生物膜后,复合催化膜生物反应器去除NO的效率比湿式膜催化反应器提高了59.5%~66%.     

Numerical evaluation of the effectiveness of NO2 and N2O5 generation during the NO ozonation process

Wet scrubbing combined with ozone oxidation has become a promising technology for simultaneous removal of SO₂ and NO_x in exhaust gas. In this paper, a new 20-species, 76-step detailed kinetic mechanism was proposed between O₃ and NO_x. The concentration of N₂O₅ was measured using an in-situ IR spectrometer. The numerical evaluation results kept good pace with both the public experiment results and our experiment results. Key reaction parameters for the generation of NO₂ and N₂O₅ during the NO ozonation process were investigated by a numerical simulation method. The effect of temperature on producing NO₂ was found to be negligible. To produce NO₂, the optimal residence time was 1.25 sec and the molar ratio of O₃/NO about 1. For the generation of N₂O₅, the residence time should be about 8 sec while the temperature of the exhaust gas should be strictly controlled and the molar ratio of O₃/NO about 1.75. This study provided detailed investigations on the reaction parameters of ozonation of NO_x by a numerical simulation method, and the results obtained should be helpful for the design and optimization of ozone oxidation combined with the wet flue gas desulfurization methods (WFGD) method for the removal of NO_x.     

疏水型H-ZSM-5分子筛上NO氧化反应的研究

针对NO低温氧化催化剂的抗水汽性差的问题,以疏水型高硅H-ZSM-5分子筛为NO氧化催化剂,在温度为10~90℃、NO进口浓度为0.05%~0.08%,及相对湿度为0~100%条件下,考察了NO的氧化反应.结果表明,H-ZSM-5分子筛的硅铝比由50提高至300时,湿气条件(水汽含量1.18%)下,NO氧化率由20%升高至56%;干气下,低温有利于NO氧化;湿气下(水汽含量1.18%),NO氧化率随着温度的升高先增加后减少,最佳反应温度为20℃,与NOx工业废气的排放温度相近.200h的稳定性试验结果显示,在30℃、NO进口浓度0.08%、空时0.5s、保持相对湿度为50%或100%时,NO氧化率可维持在60%和50%,催化剂具有良好的稳定性.     

利用LUR模型模拟天津市大气污染物浓度的空间分布

针对传统监测方法无法满足对大气污染物空间分布高分辨率的要求,以Arcgis为平台,利用LUR模型模拟天津市PM10和NO2年均浓度的空间分布.选取的回归变量为1~4km半径缓冲区内的道路总长度、不同土地利用类型的面积、人口密度、风向指数及距海距离,选取3个监测点的监测数据对方程进行了验证.结果表明,对PM10年均浓度影响最大的因素是缓冲区为1km的道路总长度(R2为0.560),而对NO2年均浓度影响最大的因素是人口密度(R2为0.414).多元线性回归方程计算结果显示,PM10和NO2的R2分别达到0.946和0.691;如果考虑风向的影响,R2可分别提高到0.980和0.849.对天津市中心城区建立5km′5km网格嵌套,根据多元线性回归方程计算每个网格交点的污染物浓度模拟值.通过kriging插值得到2种污染物在天津市中心城区的空间模拟分布图.PM10年均浓度分布以研究区中心最高,向四周逐渐降低;NO2的年均浓度以研究区中心最低,向四周逐渐升高.模拟结果与实际情况相符.     

2006─2010年环保重点城市主要污染物浓度变化特征

利用2006─2010年全国环保重点城市的空气质量日报数据,分析了大气ρ(SO2)、ρ(NO2)和ρ(PM10)的变化特征. 结果表明:从年际变化看,ρ(SO2)和ρ(PM10)呈下降趋势,ρ(NO2)变化不显著.从季节变化看,ρ(SO2)、ρ(NO2)和ρ(PM10)均呈冬季高、夏季低的特征.从浓度谱分布看,全国大气中ρ(SO2)、ρ(NO2)和ρ(PM10)分别集中在0～0.150、0～0.100和0～0.250 mg/m3范围内,ρ(SO2)和ρ(PM10)谱峰区间逐渐向低浓度范围偏移,高浓度事件逐渐减少,表明SO2和PM10污染得到较明显的控制,而ρ(NO2)谱峰变化不大.从浓度变化看,山西ρ(SO2)、ρ(NO2)和ρ(PM10)下降最明显,年变化率分别为-11.2、-3.6和-14.2 μg/m3;青海ρ(SO2)、山东ρ(NO2)和ρ(PM10)的上升趋势最明显,年变化率分别为4.4、2.7和4.5 μg/m3.      

船舶柴油机NOx后处理技术的进展

根据国内外的降低NOx排放方面最新的成果和科研动态，主要介绍了当前正在研究或者已经应用于实际的有效降低柴油机NOx排放的技术措施，并分析了各种技术方法的特点和在实际应用过程中面临的问题。     

北京转河河岸带生态修复对河流水质的影响

以北京转河为例,探讨一系列河岸带生态修复措施(尤其是河漫地和护岸的改造)对河流水质的影响.于2009年7～9月进行实地调查,沿河岸选取13个采样点,并定期采集水样,测定其中营养物质和溶解氧(DO)等的浓度.结果表明,转河氨氮(NH4+-N)、硝氮(NO3--N)、总磷(TP)和DO的浓度均有非常明显的季节变化.在居民用...     

NO在分子筛ZSM-5催化剂上催化氧化动力学研究

研究了常温下NO在疏水型高硅分子筛ZSM-5上的氧化反应. 结果发现,NO在分子筛ZSM-5表面氧化的同时,伴随着明显的吸附过程,待吸附饱和后释放出NO2.相比于活性炭,高硅分子筛ZSM-5上NO氧化受水汽影响较小,303K饱和湿气下,NO稳态转化率只比干气下降低6%.在排除内、外扩散影响的条件下,于等温积分反应器中研究了稳定阶段NO氧化的本征动力学,根据不同温度下X~W/FA0及NO分压数据,计算了反应速率,建立简化的动力学模型并获得了反应速率方程,结果表明其拟合复相关系数较高.     

“W型低NOx环保燃烧器”特点及应用状况

“W型低NOx环保燃烧器”采用先进的复合多级混合式雾化技术，强化喷射、混合和扩散，燃烧充分从而控制NOx生成。