加油站油气回收系统分析与关键技术研究

深入分析了加油站平衡式油气回收系统、真空泵辅助式油气回收系统的美国模式和德国模式的油气回收效率和关键技术问题,揭示了密封性是平衡式失败和美国模式低效的根本原因,解决了困扰业界的罐压不高、罐压保持、后处理装置是否必要等困惑和争议,提出高效率、低密封性要求的"低罐压真空泵辅助式油气回收系统"技术方案和实施方案。     

Antimicrobial activity of thin metallic silver flakes, waste products of a manufacturing process

The aim of the research was to develop new products and processes from a manufacturing waste from an Italian metallurgic company. The company produced thin silver metallic films and the production scraps were silver flakes. The possibility to use the silver flakes in water disinfection processes was studied. The antimicrobial activity of the flakes was investigated in batch using Escherichia coli as Gram-negative microorganism model. The flakes did not show any antimicrobial activity, so they were activated with two different processes: thermal activation in reducing atmosphere and chemical activation, obtaining, respectively, reduced flakes (RF) and chemical flakes (CF). The flakes, activated with either treatment, showed antimicrobial activity against E. coli. The kill rate was dependent on the type of activated flakes. The chemical flakes were more efficient than reduced flakes. The kill rate determined for 1 g of CF, 1.0 ± 0.2 min⁻¹, was greater than the kill rate determined for 1 g of RF, 0.069 ± 0.004 min⁻¹. This was confirmed also by the minimum inhibitory concentration values. It was demonstrated that the antimicrobial capability was dependent on flakes amount and on the type of aqueous medium. Furthermore, the flakes maintained their properties also when used a second time. Finally, the antimicrobial activities of flakes were tested in an effluent of a wastewater treatment plant where a variety of heterotrophic bacteria were present.     

诱导结晶磷回收技术处理低浓度含磷废水研究

诱导结晶技术是近年发展的新型废水处理技术。采用自设计的诱导结晶反应器,反应器形式与Phosnix相似,但结构相对简单,无Phosnix反应器的内外同心筒结构,并增加了过渡区。研究了HRT、[PO43-]、[Ca2+]/[PO43-]对诱导结晶处理低浓度含磷废水的影响规律,并以实验室双泥系统厌氧上清液为原水,考察了结晶反应器长期运行效果。研究表明,在一定范围增加HRT、[PO43-]或[Ca2+]/[PO43-]均可提高磷酸盐去除率,但超过一定数值后,再继续增加对提高磷酸盐去除效果的贡献很小,[PO43-]或[Ca2+]/[PO43-]过高还会导致均相结晶出现,使磷酸盐去除率下降;研究给出了一定条件下的最佳HRT、[PO43-]或[Ca2+]/[PO43-];运行效果试验表明,诱导结晶反应器在进水平均磷酸盐浓度仅为23.6 mg/L的情况下,磷酸盐的平均去除率仍可达到55.2%,该技术在处理低浓度含磷水方面较具应用前景。     

Enhanced struvite recovery from wastewater using a novel cone-inserted fluidized bed reactor

The feasibility of struvite recovery at low （12.5 mg/L） and high （120 mg[L） phosphorus concentrations was studied by constructing a novel fluidized bed reactor with cones （FBRwc） and without cones （FBRwoc）. The crystallization process was continuously operated for 133 days under different hydraulic retention times （HRT = 1-10 hr）, pH （7.5-10）, and molar ratios of Mg/P （0.75-1.75）, N/P （1-10） and Ca/Mg （0-2）. The optimum operating conditions of HRT, pH, Mg/P and N/P molar ratios were found to be 2 hr, 9, 1.25, and 7.5, respectively. Under these optimum conditions, the phosphorus precipitation efficiencies of FBRwc were 93% for low and 98% for high phosphorus influent; however, the efficiencies were 78% and 81% for FBRwoc, respectively. Due to crystal losses at each junction （17%-31%）, the crystal recovery efficiency of FBRwoc was relatively low （47%-65%） for both influent concentrations. However, the losses were minimal in FBRwc, which showed 75% and 92% crystal recovery for low and high phosphorus concentrations, respectively. At low calcium concentration, crystal chemical analysis showed the product to be pure struvite （〉 99%）. The scanning electron microscope and X-ray diffraction results further confirmed that the crystal recovered from FBRwc contained pure struvite, which could be considered a high quality fertilizer. Except HRT, all parameters （pH, Mg/P, N/P and Ca/Mg） were found to be influencing factors for FBRwc performance. Overall, inserting cones in each part of the reactor played a significant role in enhancing struvite recovery from a wide range of phosphorus-containing wastewater.     

Ultrasonic preparation of nano-nickel/activated carbon composite using spent electroless nickel plating bath and application in degradation of 2,6-dichlorophenol

Ni was effectively recovered from spent electroless nickel （EN） plating baths by forming a nano-nickel coated activated carbon composite. With the aid of ultrasonication, melamine- formaldehyde-tetraoxalyl-ethylenediamine chelating resins were grafted on activated carbon （MFT/AG）. PdC12 sol was adsorbed on MFT/AC, which was then immersed in spent electroless nickel plating bath; then nano-nickel could be reduced by ascorbic acid to form a nano-nickel coating on the activated carbon composite （Ni/AC） in situ. The materials present were carefully examined by Fourier transform infrared spectroscopy, X-ray diffraction, field emission scanning electron microscopy, X-ray photoelectron spectroscopy and electro- chemistry techniques. The resins were well distributed on the inside and outside surfaces of activated carbon with a size of 120 ± 30 nm in MFT/AC, and a great deal of nano-nickel particles were evenly deposited with a size of 3.8 ± 1.1 nm in Ni/MFT. Moreover, Ni/AC was successfully used as a catalyst for ultrasonic degradation of 2.6-dichloronhenol.     

磷回收对厌氧/好氧交替式生物滤池蓄磷/除磷的影响

为能提高生物除磷系统的除磷/回收磷效率,研究采用厌氧/好氧交替式生物滤池(AABF)处理低碳磷比废水,观察利用周期性扩增进水碳源进行磷回收时,生物滤池除磷效率及生物膜内微生物特性的变化.通过分析生物滤池除磷效率变化,生物膜多聚物染色、扫描电镜(SEM)观察以及荧光原位杂交(FISH)技术分析生物滤池系统实施周期性磷回收对生物膜内微生物菌群形态与组成的影响.结果发现,生物滤池在先后经历3次生物蓄磷-磷回收(PB-PR)的运行操作过程中,生物滤池除磷效率分别由磷回收前的60.3%、82.9%、86.6%提高到磷回收后的87.2%、91.2%、93.5%;生物滤池生物膜内优势菌群形态逐渐由大球菌演变为小球菌、杆菌与丝状菌;经过连续3个周期的PB-PR操作,生物滤池底部生物膜中聚磷菌所占比例由43%提高至70%;聚磷菌群在生物膜内混合菌群中的比例随着上流式生物滤池高度的增加而不断提高.结果表明,采用周期性的碳源扩增与回收磷的操作,可以提高生物滤池除磷效率;引起生物滤池生物膜内微生物菌群形态与组成发生变化,促进聚磷菌成为优势菌群.     

中国矿山地质环境恢复治理激励机制探索研究

目前,中国矿山地质环境恢复治理形势依然严峻,国家高度重视矿山地质环境恢复与治理工作,财政部、国土资源部不断加大矿山地质环境治理资金,但目前资金缺口仍然很大。文章通过梳理中国矿山地质环境恢复治理激励机制建设创新做法,总结各省开展矿山地质环境恢复治理"五结合"激励模式实践探索,并针对我们矿山地质环境治理目前存在的主要困难和问题提出了引入市场机制出台土地使用权,及尽快出台国家层面的鼓励政策等多方面的优惠政策等建议。     

王坡井田煤层气井采出水处理方法研究

针对王坡井田煤层气井采出水中污染物含量低,仅CODcr超出国家一级排放标准(GB 8978-1996)的特点,采用活性炭吸附处理,然后通过絮凝沉降迅速回收采出水中悬浮活性炭。结果表明:活性炭投加量为3g/L、吸附时间为40 min,PAM投加量为2 mg/L,沉降时间为5 min,活性炭回收率为98.35%,处理后采出水CODcr为45.45 mg/L、SS为7 mg/L,达到国家一级排放标准(GB 8978-1996)。     

水质测定中高锰酸盐指数(酸性法)影响因素的研究

探讨了水质测定中酸性法高锰酸盐指数的影响因素:加热时间、加热温度、溶液浓度、滴定速度、水样酸度,掌握了最佳试验条件,使测定结果更准确。     

印染废水中铬的活性炭吸附及资源化研究

在实验室条件下利用活性碳柱对印染废水进行了铬的吸附,对活性碳柱进行逐级加热、逆流漂洗再生,达到了较好的处理效果,同时还回收了铬盐。