Wastewater management in small- and medium-size enterprises: case studies

Wastewater management in small and medium-sized enterprises representing the chemical and food industries was investigated. The results showed that wastewater discharged from an ink-production factory was highly contaminated with organic pollutants. Anaerobic biological treatment followed by chemical coagulation using ferric chloride aided with lime proved to be very effective and produced an effluent that complied with national regulatory standard for wastewater discharge into public sewage network. Also, management of wastewater from a confectionery factory representing the food sector was carried out. Aerobic biological treatment using plastic-packed trickling filter proved to be an effective treatment method. However, application of in-plant control measures alleviated the requirement for the construction of a wastewater treatment plant. The applied pollution prevention and cleaner production measures involved good housekeeping, recovery of spent chocolate, modification of floor cleaning and installation of suction devices for the removal of sugar and starch powders. All improvement measures were documented by cost/benefit analysis.     

PPS滤料在SO2气体作用下的耐腐蚀性研究

采用气体实验法对PPS滤料在SO2气体中腐蚀失效的过程进行了研究.通过实验前后PPS滤料的机械特性、微观特征和化学结构的分析,认为PPS对SO2气体具有良好的耐腐蚀性.但是,随着SO2气体温度的升高,时间的延长及气体体积比提高,PPS 针刺毡滤料的性能有所下降,尤其是高温能加快腐蚀效果.为了延长使用寿命,应使其工作参数在限定的范围内: 在SO2体积比高于700 mL/m3时,应对烟气进行预处理使其体积比低于实验值,或者使烟气的温度控制在170 ℃以下; 如果烟气中SO2体积比超过预定值,烟气温度又高于170 ℃,则PPS针刺毡滤料连续使用时间应不超过96 h.     

二维平流扩散模型下的集合卡尔曼滤波模拟同化研究

为提高环境数值预报水平,构建了一个针对污染物扩散的模拟数据同化系统。采用集合卡尔曼滤波方法对二维平流扩散模型的状态变量进行了实时校正,实现污染物浓度的实时模拟预报,完成了敏感性实验中集合数目变化、观测方差变化和同化窗口长度变化研究。比较考察观测点位置与污染源距离不同时的预报效果,探讨了优化条件下的同化策略,提出一种根据距离远近动态调节卡尔曼增益权重的方法。在集合数目较小时,可降低计算代价,得到优化的同化效果。     

低温浓缩-气相色谱/质谱法分析固定污染源废气中的丙烯腈

建立了固定污染源废气中丙烯腈的气袋采样-低温浓缩-气相色谱/质谱分析方法。结果表明,该法在丙烯腈质量浓度16.1~4 050μg/m~3范围内具有良好的线性,相关系数R~20.999,检出限为9.54μg/m~3,回收率、日内与日间精密度均符合质控要求,能够满足废气中丙烯腈分析的要求。     

Estimating marine biogeochemical rates of the carbonate pH system—A Kalman filter tested

Oxygen (O₂), nitrate (NO₃), dissolved inorganic carbon (DIC) or pCO₂, and pH or total alkalinity (TA), are useful indices of marine chemical, physical and biological processes operating on varying time-scales. Although these properties are increasingly being monitored at high frequency, they have not been extensively used for studying ecosystem dynamics. We test whether we can estimate time-evolving biogeochemical rates (e.g. primary production, respiration, calcification and carbonate dissolution, and nitrification) from synthetic high frequency time-series of O₂, NO₃, DIC, pCO₂, TA or pH. More specifically, a Kalman filter has been implemented in a very simplified biogeochemical model describing the dynamics of O₂, NO₃, DIC and TA and linking the concentration data to biogeochemical fluxes. Different sets of concentration data are assimilated and biogeochemical rates are estimated. The frequency of assimilation required to get acceptable results is investigated and is compared with the frequency of sampling in the field or in controlled experimental settings.Smoothing of the data to remove data noise before assimilation improves the estimation of the biogeochemical rates. The best estimated rates are obtained when assimilating O₂, NO₃ and TA although the assimilation of DIC instead of TA also gives satisfactory results. In case pH or pCO₂ is assimilated rather than DIC or TA, the linearization of the (now nonlinear) observation equation introduces perturbations and the Kalman filter behaves suboptimal. We conclude that, given the resolution of data required, the tool has potential to estimate biogeochemical rates of the carbonate system under controlled settings.     

KALMAN FILTER CALCULATION OF SAMPLING FREQUENCY WHEN DETERMINING ANNUAL MEAN SOLUTE CONCENTRATIONS

ABSTRACT: A linear filter (Kalman filter) technique was used with a Streamflow-concentration model the minimize surface water quality sampling frequencies when determining annual mean solute concentrations with a predetermined allowable error. The Kalman filter technique used the stream discharge interval as a replacement for the more commonly used time interval. Using filter computations, the measurement error variance was minimized within the sample size constraints. The Kalman filter application proposed here is applicable only under several conditions including: monitoring is solely to estimate annual mean concentration; discharge measurement errors are negligible; the Streamflow-concentration model is valid; and monthly samples reflect the total variance of the solute in question.     

降低布袋除尘器阻力与节能问题的探讨

根据多年来多事布袋除尘器的管理工作和现场调试经验，提出了除尘系统节能运行的思想和方法。并对布袋除尘系统的节能运行进行了认真的分析，特别是对降低除尘器阻力后如何进行节能调节问题进行了深入的探讨。     

USE OF X-RAY FLUORESCENCE TO DETERMINE TRACE METALS IN WATER RESOURCES1

ABSTRACT. The X-ray fluorescence method was used to analyze trace metals collected in particulate form on filter papers and from the ionic state by ion exchange filter papers. The samples were prepared by allowing water to pass through these filter papers. The procedures necessary for using the X-ray fluorescence method are described. A number of samples were taken from the Great Miami River in Dayton, Ohio over one year showing the presence of the following metals, Ca, Ti, Cr, Fe, Cu, Zn, Sr, and Cd. Elements in the periodic table between Ti and Cs were detectable to a sensitivity limit of the order of 30 ppb for metals in the particulate form and 0.4 ppm for metals in the ionic form.     

表面过滤技术在焚烧厂烟气脱酸净化中的作用

随着城市垃圾焚烧工程的发展，国家对焚烧后尾气的处理技术提出了越来越高的要求。基于“表面过滤”理论的Gore过滤技术，不但为粉尘排放达到欧洲标准提供了技术保障，而且为脱酸／硫的后续反应提供了反应界面，在实际应用中可以有效节约反应剂。     

应用于高温干态过滤的三聚氰胺纤维过滤材料

ＬＦＢ是Ｂａｓｏｆｉｌ纤维与Ｍｅｔｍａｘ纤维混合制成的针刺毡，本文主要介绍Ｂａｓｏｆｉｌ纤维和ＬＦＢ的物理和化学特性。