楚雄德胜钢铁公司烧结机尾除尘改造实践

介绍楚雄德胜钢铁公司19·6m2烧结机尾除尘系统改造工程中使用三电极电除尘器的工艺及有关设计技术问题,并根据使用效果进行分析总结。结果表明,在设计参数选择恰当的情况下,三电极电除尘器对烧结烟气有较好的除尘效果,这些经验和操作中存在的问题供烧结机尾除尘工程设计参考。     

厌氧-好氧生物滤池处理城市污水试验

研究了生物滤池处理城市污水的性能特点,结果表明:厌氧-好氧生物滤池去除城市污水中的CODCr、SS和NH4+-N等具有较好的效果,当进水CODCr、SS和NH4+-N分别为23、112mg/L和56mg/L时,水力停留时间8h,曝气强度在0·5~0·6L/(m2·s)时,CODCr、SS和NH4+-N的去除率分别在90%、80%和75%以上。     

肉类加工废水生物脱氮工艺的工程应用

采用ABRSBR组合工艺开展了大量现场模拟试验及动力学理论研究,最终获得了进一步提高肉类加工废水脱氮效率的措施途径。通过对已建成、正调试、正设计3种情况下肉类加工废水脱氮工艺的研究,表明此脱氮工艺具有良好的工程应用价值。     

赣南小流域的水文地球化学特征和主要风化过程

对赣南花岗岩小流域进行采样、测试及分析,发现其河水含有较低的矿化度,水化学组成以Na ,Ca2 ,Cl-1和HCO-3为主,溶解性Si的含量明显较高,代表了典型硅酸盐地区河流的相应化学组成.通过Gibbs图分析,赣南流域大部分地区受大气降水的影响比较显著,"蒸发-浓缩"类型的小流域也较多.根据主成分分析和因子分析的结果,定量地估算了大气中CO2和三类岩石对河水中各种离子的贡献比例.与黄河相比,赣南流域受硅酸盐岩风化作用强烈,但主要影响因素仍是碳酸盐和蒸发盐岩,二者对赣南流域溶解质的贡献率分别为42.8%和29.2%,大气中CO2对河水溶解质的贡献率为21.4%,低于世界平均水平.主要风化反应以岩盐和方解石的溶解为主,Si/(Na* K)比值较低,说明风化反应在表生环境中进行,其产物是富含阳离子的次生矿物.     

折光率法和电导率法测定稀土废水中氯化铵

阐述了折光率法与电导率法测定稀土废水中高浓度氯化铵的原理和方法.在恒温和低悬浮物浓度条件下,折光率与氯化铵质量浓度线性关系良好;当保持外界条件不变时,氯化铵质量浓度在5 000 mg/L～60 000 mg/L与电导率显著相关.经t检验,两种方法与银量法差异均不显著,且操作简单,准确快速,适用于水处理过程中的现场实时监测.     

Degradation of polycyclic aromatic hydrocarbons by combined chemical pre-oxidation and bioremediation in creosote contaminated soil

The ability of pre-oxidation to overcome polycyclic aromatic hydrocarbons (PAH) recalcitrance to biodegradation was investigated in creosote contaminated soil. Sand and peat artificially spiked with creosote (quality WEI C) were used as model systems. Ozonation and Fenton-like treatment were proved to be feasible technologies for PAH degradation in soil. The efficiency of ozonation was strongly dependent on the water content of treated soil samples. The removal of PAH by Fenton-like treatment depended on the applied H2O2/soil weight ratio and ferrous ions addition. It was determined that the application of chemical oxidation in sand resulted in a higher PAH removal and required lower oxidant (ozone, hydrogen peroxide) doses. The enhancement of PAH biodegradability by different pre-treatment technologies also depended on the soil matrix. It was ascertained that combined chemical and biological treatment was more efficient in PAH elimination in creosote contaminated soil than either one alone. Thus, the combination of Fenton-like and the subsequent biological treatment resulted in the highest removal of PAH in creosote contaminated sand, and biodegradation with pre-ozonation was found to be the most effective technology for PAH elimination in peat.     

Ultrasound and enzyme assisted biodegradation of distillery wastewater

Irradiation with ultrasound (US) and use of an enzyme (E) as pretreatment techniques were carried out to treat a complex effluent (distillery wastewater). These two techniques have been used alone as well as in combination and the efficacy of these techniques was tested by subjecting the effluent to subsequent aerobic biological oxidation (AO). When used alone, US exposure for 30 min and 2 h yielded the best COD reduction during the aerobic oxidation step (US+AO). For the enzyme when used alone, a pH value of 4.8 (corresponding to the optimum pH of the enzyme), a dose of 50 U and a pretreatment time of 24 h yielded better COD removal efficiency as compared to untreated effluent (aerobic oxidation alone). When used in combination, ultrasound followed by enzymatic pretreatment (US+E+AO) yielded the best COD removal efficiencies during aerobic oxidation as compared to the other combinations tested for the treatment of the distillery wastewater. A 4-fold increase in the initial oxidation rate was observed over the untreated batch for the integrated technique (US+E+AO). On the basis of the variation in the values of the biokinetic parameters it can be concluded that the type of pretreatment scheme affects the subsequent rate of the aerobic oxidation significantly.     

污水处理系统剩余污泥碱处理融胞效果研究

研究了碱处理对污水生物处理系统剩余污泥的融胞效果及其影响因素.结果表明,碱处理能够使污泥细胞中有机物溶出,成为溶解性物质,从而使污泥液相的溶解性化学需氧量增加.pH值高于11.0时,污泥的絮体和细胞2种结构被破坏,而pH值低于11时,仅能破坏其絮体结构.碱处理过程中,起作用的是OH^-离子,但同时加入的金属离子也会影响污泥融胞的效果.碱处理能减小污泥的重量,VS的最大去除率可达48.01%(TS约为40.40%,pH值13.0左右时).污泥粒径随着碱处理pH值的升高而减小.污泥浓度、pH值和处理时间均是影响碱处理效果的重要因素,正交试验表明,在高pH值下,污泥浓度越高,碱处理污泥融出的SCOD总量越多,但折算为相同pH值下,单位污泥融出的SCOD基本不变.     

乳化液废水均相催化湿式氧化动力学

在2L高压间歇反应釜中,以高浓度难降解乳化废水为处理对象,研究了温度对铜盐均相湿式氧化的影响和动力学特征.结果表明:升高温度对加快后期反应速度更为有利,催化剂有利于中间产物氧化,在200℃催化活性最高,在进水COD48 400mg/L,反应2h去除率为86.6%;催化剂在不同温度作用下机制有所差别:200℃时3个途径反应速度均加快,中间产物加速氧化更明显;220～240℃时反应向生成中间产物方向偏移,活性降低;通用模型能较好地预测均相催化过程.     

低强度超声波强化污水生物处理机制

研究发现低强度的超声辐照可以有效促进微生物的活性,可将其用于强化污水的生物处理,通过增强反应器内微生物的活性来提高污水的处理效率.本文综述了超声波在生物工程和生物学上的国内外研究成果,对低强度超声波的生物效应以及在促进生物活性中的主要作用机制进行了探讨,并分析了其在强化污水生物处理中的应用前景.