PTG测定油脂与高压氧气的反应

介绍说明几起氧气瓶内附油脂充氧过程中爆炸事故。介绍高压氧气与油脂的反应,论述了空压机润滑油燃烧基本特性,采用热重天平进行了空压机润滑油在不同压力的气体氛围内的燃烧试验,建立起空压机润滑油的热重和微商热重曲线,得到空压机润滑油在不同压力的氧气氛围内的自燃点。放入加压热重分析仪内的润滑油,接触高压氧气后迅速被氧化,氧气压力越高,氧化程度越深。随着氧气压力的升高,润滑油的着火点降低。这表明氧气瓶中油脂,随着充氧压力的增加,着火点降低,即压力越大,油脂越容易自燃,释放热量,导致爆炸。提出安全措施。     

矿井火区启封安全性分析及判别准则

矿井火区启封时火区状态判断失误会导致火区复燃或火区内瓦斯爆炸。为此,本文在分析矿井火区启封的安全性的基础上,从气体信息采集和火区燃烧状态的判断技术两方面,提出了相关准则。气体信息采集准则含气样代表火区状态真实性、提高气样代表火区大气状态的真实性、正确的气样采集方法十六项内容,主要论及钻孔取样、孔内测压、火区气体采样地点、倾斜巷道密闭取样、取样地点对气样准确度的影响、气样采集时间、采集钻孔封堵、混合气样分段采集方法、取样时间间隔、气样分析方式等。火区燃烧状态的判断技术准则含十二项内容,主要论及不同火区气体浓度条件和环境条件下正确判断火区燃烧状态技术。准则可为矿井火区治理中正确分析判断火区状态和启封条件提供参考。     

钙钛矿型催化剂La_（0.8）M_（0.2）CoO_3（M=Sr、Ce、Ba、Ca）催化燃烧VOCs的活性与抗硫性研究

用柠檬酸溶胶-凝胶法制备了La0.8M0.2CoO3（M=Sr、Ce、Ba、Ca）4种钙钛矿型复合氧化物催化剂.甲苯催化燃烧活性测试表明,4种催化剂均具有很好的催化活性,转化率达到90%时反应温度都在340℃以下,比LaCoO3下降20℃—70℃,催化性能依次为：La0.8Sr0.2CoO3〉La0.8Ce0.2CoO...     

生物质燃烧的二噁英排放特性

通过室内模拟燃烧5种生物质,分别采集燃烧排放的烟气作为样品,然后分析生物质和燃烧产物的二噁英含量,得到玉米秸秆、稻草、松树、桉树、松针燃烧的二噁英排放因子分别为2.59、16.78、1.44、5.15、34.12 n.gkg-1,对应的I-TEQ浓度为0.26、1.04、0.10、0.31、1.49 n.gkg-1.O...     

Investigation of the propensity of sulfide concentrates to spontaneous combustion in storage

Spontaneous combustion of sulfide concentrates can cause many serious problems during storage. In this study, two representative samples (sulfur-rich sulfide concentrate and iron-rich sulfide concentrate) were investigated for the self-heating behavior using the crossing-point temperature (CPT) method. The corresponding apparent activation energies were determined, 13.7366 kJ/mol for iron-rich sulfide concentrate and 21.3817 kJ/mol for sulfur-rich sulfide concentrate. Furthermore, the surface temperatures of sulfide concentrate stockpiles in different seasons were also measured by a thermal image apparatus. It was found the temperature for iron-rich sulfide concentrate stockpile was higher than that for rich-sulfur sulfide concentrate stockpile. These research results show iron-rich sulfide concentrate exhibits stronger propensity to spontaneous combustion than sulfur-rich sulfide concentrate. Particular attention should be paid to the fire hazard of iron-rich sulfide concentrate in daily safety check work. The combination of the CPT method with the infrared thermal image measurement provides a new approach for the risk assessment on the propensity of sulfide concentrates to spontaneous combustion during the production, storage and transportation. The useful data and experience achieved in this investigation can be also referenced in similar cases later.     

油罐喷射火燃烧模拟

针对由一定压力的单相或两相介质泄漏或压力泄放系统排放引起的喷射火,利用gambit生成计算区域网格,得到相应的计算模型.再利用Fluent软件中的离散相模型计算气体流动,采用Realizable k-epsilon湍流模型和部分预混燃烧模型来预测燃料的燃烧,模拟了戊烷燃料燃烧和湍动多相流场,给出了燃烧速度矢量、温度和组...     

Mercury emissions and partitioning from Indian coal-fired power plants

In India coal combustion is the single largest source of emission of mercury which is a wide-spread persistent global toxicant, travelling across international borders through air and water. As a party to the Minamata convention, India aims to monitor and reduce Hg emissions and stricter norms are introduced for mercury emissions from power plants (30 μg/Nm³for flue gas in stack).This paper presents the results obtained during the experimental studies performed on mercury emissions at four coal-fired and one lignite-fired power plants in India. The mercury concentration in the feed coal varied between 0.12–0.27 mg/Kg. In the mercury mass balance, significant proportion of feed coal mercury has been found to be associated with fly ash, whereas bottom ash contained very low mercury. 80%–90% of mercury was released to air through stack gas. However, for circulating fluidised bed boiler burning lignite, about 64.8% of feed mercury was found to get captured in the fly ash and only 32.4% was released to air. The mercury emission factor was found to lie in the range of 4.7–15.7 mg/GJ.     

海州露天矿采空区地表CO2通量的试验研究

为探究海州露天矿东邦废弃采空区自然发火状态,基于采空区遗煤自燃特性和气体扩散理论,采用智能土壤气体通量监测系统,以月为单位,对东邦自燃采空区上覆地表CO₂通量开展长周期、多测点连续性监测试验;根据试验区域内地表CO₂通量和土壤温度分布特征,探究地下火区释放CO₂的地表涌出范围和变化情况;同时,着眼于温室气体排放的评估,计算试验区域内的CO₂涌出量,并分析其随时间的变化特征。结果表明:地表CO₂通量与土壤温度有明显正相关性;试验区域地表CO₂高通量区域呈逐月扩大和递增的趋势;CO₂涌出量随月份逐渐递增,试验区域年CO₂涌出量约为3.6×10⁶ m³。     

典型三床RTO设备燃爆危险性数值模拟研究*

为研究苯、甲苯、二甲苯混合废气在三床蓄热式废气焚烧炉内部的燃烧过程,基于FLUENT软件建立典型的三床蓄热式废气焚烧炉的物理模型和数值模型,重点分析进气风量和混合可燃气体-空气摩尔占比对其内部压力变化规律的影响,以期可为其安全设计提供借鉴。研究结果表明:燃烧室内的温度变化与燃烧速度变化保持一致,可通过监测RTO燃烧室内的温度来定性评估气体燃烧速度,随着进气风量的增加,混合废气燃烧速度先升高后下降后再升高;从能源损耗和安全生产2个方面综合考虑,得出RTO运行的最佳进气风量为15 000 m3/h到30 000 m3/h,最佳的混合可燃气体-空气摩尔占比为0.15~0.2,这与RTO实际工况相符合,解释RTO装置内废气积聚导致爆炸事故的原因,燃烧过程中压力出现2次峰值超压,实际生产中需在2个时间节点多加防范。     

基于产业调整的太湖流域生态环境优化探讨

以流域为单元进行水资源综合管理,是实现资源、环境与经济社会协调发展的重要途径. 产业调整能控制污染源的数量和种类,是区域环境治理的关键环节和有效手段. 从湖泊流域产业的特有结构分析出发,以太湖为例,分析了当前太湖流域环境问题、产生的原因及其存在的产业不合理性,探讨了点源污染、线源污染和面源污染的成因及其对污染总量的贡献、治理方案并加以对比分析;探讨了湖泊流域产业调整和优化对区域生态环境的改善及污染控制治理中的作用,基于污染总量恒定或稳步下降、经济发展速度不变的情况下,对流域产业升级和优化调整提出了具体的产业结构和政策,这对指导湖区流域可持续发展具有一定的理论意义和实践价值.