气相色谱法测定二硫化碳和甲硫醚

利用气相色谱(配火焰光度检测器,采用3mxφ2mm玻璃填充柱分离)对CS2和甲硫醚(DMS)两种含硫化合物进行了分离检测。该方法具有较高的灵敏度和良好的线性关系。结果表明:该分析对含硫气体的最小检测浓度在mg/m3级,在柱温为70℃,检测器温度为180℃,气化室温度为150℃,氮气流速为50mL/min时,CS2的回收率为98.66%,变异系数为2.12%;甲硫醚的回收率为98.66%,变异系数为1.56%。     

过滤捕集法处理含DEP雾废气的研究

为了探讨玻璃纤维过滤器处理含DEP雾废气的效率问题,在实验室进行了DEP雾去除实验。考查了不同气体入口浓度、过滤流速下玻璃纤维过滤捕集装置对含DEP雾废气的净化能力,结果表明:利用玻璃纤维过滤器去除DEP雾,在DEP雾粒径主要分布为0.48～3.4μm之间,DEP雾浓度小于220 mg/m3,过滤流速小于10 cm/s情况下,玻璃纤维过滤器对DEP雾的去除率大于99%,最大气体流量下的压力降小于1610Pa;同时对含油(酸)雾废气除雾效果好,特别是对于粒径特别细微的油(酸)雾,捕集效率也很高,还可回收利用,不会产生二次污染。     

玻璃纸生产废气中CS2和H2S的治理

阐述了玻璃纸生产中CS2和H2S废气产生的原理,介绍了该废气处理的现状,总结了目前普遍采用的冷凝法、活性炭吸附法、活性碳纤维吸附法、改性活性炭吸附法、螯合铁氧化法、吸收-吸附法等处理方法的特点和效果。介绍了一种先采用螯合铁氧化法、再采用冷凝法、最后采用活性炭吸附法的综合处理工艺,可使废气达标排放。     

Development of IC-ELISA for detection of organophosphorus pesticides in water

Diethyl (carboxymethyl) phosphonate (DECP) was used as the hapten to develop an indirect competitive enzyme-linked immunosorbent assay (IC-ELISA) for detecting organophosphorus pesticides (OPs). Conjugator of DECP with bovin serum albumin (BSA) was used as the immunogen for producing the polyclonal antibodies (PcAbs). Three antisera were obtained after the immune procedure. Characterization studies of the PcAbs indicated that the titer of antiserum-1 was highest in 3 antisera, and antiserum-1 had high affinity and specificity to the parathion, dichlorvos and pirimiphos. The IC-ELISA showed an IC₅₀ of 0.428 μ g/mL with a detection limit of 0.0125 μ g/mL to parathion. The assay also indicated that the IC₅₀ values of pirimiphos and dichlorvos were 0.331 μ g/mL and 1.25 μ g/mL respectively, and the detection limits of pirimiphos and dichlorvos were 0.0116 μ g/mL and 0.048 μ g/mL respectively. Recoveries of parathion, pirimiphos and dichlorvos spiked into water samples ranged from 90% to 160%. The results indicated that the ELISA could be a convenient and supplemental analytical tool for monitoring OPs residues in environmental water samples.     

一氯二乙基铝装置危险源辨识及预防措施

一氯二乙基铝装置为甲类火灾危险装置。通过对一氯二乙基铝装置工艺流程及各单元工艺特点的详细分析,危险源的辨识从物料危险性、工艺过程危险性、工艺操作危险性等角度展开,从而确定出该装置的重大风险因素。在对一氯二乙基铝装置危险源辨识和分析的基础上,对各工艺单元提出相应的控制措施,预防事故发生。     

催化裂化装置硫化氢腐蚀问题及防治对策

阐述了H2S对设备的腐蚀机理,具体分析了催化裂化装置MIP-CGP技术改造后硫分布的新情况,从选材、工艺防腐、表面防腐、焊接质量控制和检测技术等方面提出了防硫化氢腐蚀的对策措施.     

二硫化钼基杂化物对聚合物火灾安全性影响

为改善聚合物材料的火灾安全性,利用二硫化钼(MoS2)的独特性能,结合纳米复合、催化成炭等设计思路,采用共沉淀法制备CeMnOx-MoS2和CeFeOx-MoS2双金属氧化物-MoS2纳米杂化物,并将其分别应用到2种典型聚合物(聚氨酯和环氧树脂)中.结果 表明:2种杂化物均匀分散在聚合物基体中,可有效延缓聚合物材料的热...     

介质阻挡放电反应器中的二硫化碳降解特性

为了解CS₂(二硫化碳)在介质阻挡放电反应器中的降解特性,提高其去除率,设计并制作了同轴圆柱介质阻挡放电反应器,研究了介质层数、外施电压、中心电极材料及直径、背景气氛种类和RH(相对湿度)对CS₂去除率的影响. 结果表明:在外施电压(4.0～6.5kV)较低时,单介质反应器的CS₂去除率高于双介质反应器;而在外施电压(6.5～9.0kV)较高时,双介质反应器对CS₂的去除效果更好,增大外施电压有利于CS₂的降解. 铜丝比不锈钢丝更适合用作反应器的中心电极,此外,增加中心电极的直径也可提高CS₂去除率. 当中心电极直径从 3.2mm增至4.8mm时,CS₂平均去除率由63%增至75%,但平均质量能耗由510kJ/mg增至611kJ/mg. 同等条件下,CS₂在氧气中的平均去除率(74%)最大,空气(59%)中次之,氮气(48%)中最小;背景气氛中适量的RH(26%)有助于提高CS₂去除率,但RH太大(大于50%)反而会降低CS₂去除率.      

Coupling catalytic hydrolysis and oxidation for CS2 removal

CS2 removal was Obtained by coupling catalytic hyidation on bi-functional catalyst.On the hydrolysis active sites,CS2 is hydrolyzed to H2S,while on the oxidation active sites,H2S is oxidized to elemental S or sulfuric acid deposited on the porous support.The above process can be expressed as followsCS2→H2O COS →H2O H2S→O2 S/SO2- 4.H2S oxidation eliminates its prohibition on CS2 hydrolysis so that the rate of coupling removal CS2 is 5 times higher than that of CS2 hydrolysis.The same active energy of hydrolysis and coupling reaction also indicates that H2S oxidation does not change the reaction mechanism of CS2 hydrolysis.Temperature has obvious effect on the process while the mole ratio of O2 concentration to CS2 concentration (O/S) does not,especially in excess of 2.5.The formation of sulfuric acid on the catalyst surface poisons hydrolysis active sites and causes the decrease of left OH-1 concentration on the catalysts surface.Lower temperature is suggested for this bi-functional catalyst owing to the low yield ratio of S/SO4 2-.     

聚苯乙烯基硫代磺酸钾树脂的合成及其与卤代烃的反应

由聚苯乙烯基磺酰氯树脂与硫化氢钾反应制备聚苯乙烯基硫代磺酸钾树脂（Ｉ）,树脂Ｉ与亲电的卤代烃反应,生成聚苯乙烯基硫代磺酸酯树脂（Ⅱ）,树脂Ⅱ经过乙硫醇处理,使卤代烃结构部分以不对称二硫醚的形式游离下来,用ＧＣ／ＭＳ对其结构进行鉴定。从不对称二硫醚的结构可推导出原卤代烃的结构,所制备的聚苯乙烯基硫代磺酸钾树脂的转化效率为１．１１ｍｍｏｌ·ｇ＾－１。