袋式除尘器在沥青混凝土搅拌设备上的应用

分析了沥青混凝土搅拌设备的构成以及生产沥青混凝土的工艺及烟尘特点;通过应用工程实例,指出袋式除尘器是沥青混凝土搅拌设备最理想的除尘系统之一。     

膨润土接枝丙烯酸高吸水性树脂的抑尘性能研究

在微波辐射下制备了膨润土接枝丙烯酸高吸水性树脂(SAP)(一种加入聚乙烯醇(PVA),另一种不加入PVA)。结果表明:(1)红外光谱图表明,PVA与聚合网络形成了半互穿网络结构;X射线衍射图表明,膨润土与PVA、丙烯酸形成了具有无定形结构的复合产物。(2)不论是沙土堆还是尘土堆,喷洒膨润土接枝丙烯酸SAP溶液的抑尘效果明显比喷洒自来水好;喷洒膨润土接枝丙烯酸SAP溶液的尘土堆的抑尘效果好于沙土堆。(3)在温度为15℃时,考虑到节约成本的问题,首选不加入PVA的膨润土接枝丙烯酸SAP做抑尘剂;在温度为45℃时,加入PVA的膨润土接枝丙烯酸SAP适合做抑尘剂。(4)膨润土接枝丙烯酸SAP浓度越高,其耐蒸发性越高。     

电厂袋式除尘器滤袋故障分析及处理

以北京高井热电厂为对象,运用故障树分析的方法,对袋式除尘器及滤袋失效进行了故障树分析,并将之演变为成功树,提出了防止滤袋失效的措施。     

影响原油生物降解因素的实验研究

以原油为唯一碳源,从长期被石油污染土壤中筛选出6株原油降解菌SY1~SY6,通过单因素实验研究初始pH、温度、充氧量(摇床转数)、盐浓度、氮源和磷源等环境因素和营养条件对各菌株生物降解原油的影响。实验结果表明:6株原油降解菌在初始pH7~9,温度30℃,摇床转速180 r/min时生长良好,且能有效地降解石油类污染物,其平均降解率为50%以上。6菌株在盐浓度在1%时生长良好,SY3菌和SY4菌能在盐浓度10%以上生长,具有一定的耐盐能力。同时,6菌株以氯化铵(NH4Cl)为氮源,磷酸氢二钾(K2HPO4)和磷酸二氢钾(KH2PO4)的混合物(2∶1)为磷源时生长良好,因此可作为各菌生长的最适氮源和磷源。研究结果可以为含油废水的处理提供微生物基础。     

基于元素毒性赋值的模糊数学环境质量评价

利用模糊数学方法,根据元素毒性的大小进行权重赋值,对成都经济区近地表大气尘进行地球化学环境质量评价。结果显示：不同城市中,成都、乐山、眉山的大气环境质量较好,处于一级清洁级别;眉山、雅安的大气环境质量处于二级安全级别;德阳的大气环境质量已经处于三级警戒级。不同地区中,绵阳和眉山的大气环境质量较好,处于一级清洁级别;德阳和雅安处于二级安全级别,成都和乐山处于三级警戒级.     

Bioaccessibility of polychlorinated biphenyls in workplace dust and its implication for risk assessment

Human exposure to bioaccessible PCBs via indoor dust is limited around the world. In the present study, the workplace dust sample from commercial office, hospital, secondary school, shopping mall, electronic factory and manufacturing plant were collected from Hong Kong for PCBs analyses. Total PCBs concentrations ranged from 46.8 to 249 ng g⁻¹, with a median of 107 ng g⁻¹. Manufacturing plant showed the highest concentration among all of sampling sites. PCB 77 was found as the dominant congeners. The bioaccessibility of PCBs in small intestinal juice ranging from 8.3% to 26.0% was significantly higher than that in gastric condition, ranging from 4.8% to 12.4%. In addition, significant negative correlations (p < 0.05) were observed between K_OW and bioaccessibility for all workplace dust samples. Risk assessment indicated that the averaged daily dose of dioxin-like PCBs via non-dietary intake of workplace dust, considering the bioaccessibility of PCBs, were much lower than the TDI of dioxins (2.3 pg WHO-TEQ kg bw⁻¹ d⁻¹) established by Joint FAO/WHO Expert Committee on Food Additives.     

Identification of magnetic particulates in road dust accumulated on roadside snow using magnetic, geochemical and micro-morphological analyses

The aim of this study is to test the applicability of snow surveying in the collection and detailed characterization of vehicle-derived magnetic particles. Road dust extracted from snow, collected near a busy urban highway and a low traffic road in a rural environment (southern Finland), was studied using magnetic, geochemical and micro-morphological analyses. Significant differences in horizontal distribution of mass specific magnetic susceptibility (χ) were noticed for both roads. Multi-domain (MD) magnetite was identified as the primary magnetic mineral. Scanning electron microscope (SEM) analyses of road dust from both roads revealed: (1) angular-shaped particles (diameter ∼1-300 μm) mostly composed of Fe, Cr and Ni, derived from circulation of motor vehicles and (2) iron-rich spherules (d ∼ 2-70 μm). Tungsten-rich particles (d < 2 μm), derived from tyre stud abrasion were also identified. Additionally, a decreasing trend in χ and selected trace elements was observed with increasing distance from the road edge.     

固定床中粒状脱硫剂除尘效率的研究

建立了非稳态过滤下的固定床颗粒层除尘效率模型.该模型尽可能地包含了影响固定床颗粒层除尘的参数,反映了沉积粉尘对除尘效率的影响;研究了以粒状脱硫剂为滤料的固定床在不同颗粒层厚度、空床气速、粒径下的除尘效率.结果表明,在颗粒层厚度为400～800 cm、空床气速≤0.4 m/s的条件下,颗粒层的除尘效率可达90％以上.     

防风抑尘网设计要点及参数的确定

介绍了堆场起尘、防风抑尘网抑尘的机理和国内外防风抑尘网研究结果,结合实际工程设计的经验,分析了防风抑尘网设计要点和主要参数,提出防风抑尘网设计的意见和建议。     

300MW燃煤锅炉机组超细颗粒聚并器的实验研究

为了解决燃煤锅炉烟气中超细颗粒难以脱除的问题,基于流体动力学原理设计了一种超细颗粒聚并器,并在300 MW燃煤锅炉机组电除尘器的前置烟道中进行了实验研究。结果表明,聚并器内部存在超细颗粒之间以及超细颗粒与大颗粒之间的相互聚集行为,从而使超细颗粒数量显著减少。例如,对于粒径在2.65和10.48μm以下的颗粒,其体积比例在聚并器出口分别减少了56.7%和62.3%,在电除尘器出口的粉尘浓度减少了26.34 mg/Nm3,这表明,基于流体动力学原理的聚并器对超细颗粒的聚并作用明显,具有良好的应用前景。