超声吹脱-次氯酸钠氧化工艺处理酮连氮法制肼废水

采用超声吹脱-次氯酸钠氧化工艺处理酮连氮法制肼废水,优化了工艺条件,并进行了尾水处理与盐分回收。实验结果表明:在超声声能密度0.08 W/mL、吹脱气量2 000 L/h、次氯酸钠溶液(有效氯10%)投加量15mL/L、反应时间20 min的最优条件下,COD、氨氮和肼类物质去除率分别达到96.97%、99.02%和96.60%,处理成本约为30元/t(以废水计);尾水经蒸馏处理后可满足GB 8978—1996《污水综合排放标准》的一级B标准,回收NaCl纯度为98.92%,达到GB/T 5462—2015《工业盐》的精制工业盐一级标准。     

催化湿式过氧化法处理蒽醌-2-磺酸钠废水

以过渡金属Cu为主活性组分,通过加入第2活性组分Mn和稀土元素Ce,研制出适用于催化湿式过氧化法(CWPO)处理含高浓度蒽醌-2-磺酸钠有机废水的复合催化剂。考察了活性组分配比对催化剂的催化活性和稳定性的影响,并利用SEM和XRD表征手段,研究了掺杂Ce对催化剂表面微观结构的影响。结果表明,当Cu、Mn和Ce的质量比为-时,催化剂的催化性能最佳,在100 min内,废水COD的去除率能达到95.3%;掺杂Ce能有效提高活性组分在催化剂表面的分散程度从而改善催化剂的催化活性,并能有效抑制Cu的溶出。通过LC-MS分析该催化剂催化氧化蒽醌-2-磺酸钠降解过程中的代谢产物,推断出了催化氧化降解蒽醌-2-磺酸钠的途径。     

中空纤维膜超滤聚丙烯酸钠溶液

研究聚丙烯酸钠（PAAS）溶液的超滤行为,考察各操作参数对膜通量（J）和截留系数（R）的影响,结果表明,J随运行时间延长衰减不明显,随压差增大呈线性递增,随温度升高而增大,pH高于5时J基本不变;R随压差增大或温度升高均下降,随pH增大而增大。建立膜阻力（rf）模型,研究影响rf的主要因素,发现,rf随压差增大而增大,随温度升高而减少,pH低于5时rf随pH增大而迅速下降。研究PAAS溶液浓缩过程,当体积浓缩因子为16时,J衰减明显,截留液PAAS浓度（Cr）呈线性递增,渗透液PAAS浓度（Cp）在较长时期内基本不变,至浓缩后期,Cp轻微下降。以去离子水对浓缩液予以洗涤,随着洗涤液体积增大,Cr轻微下降,Cp逐渐趋于零。     

两性高分子重金属螯合絮凝剂的合成及其对Cu(Ⅱ)的去除性能

合成了一种新型两性高分子重金属螯合絮凝剂聚(氯化二烯丙基甲基羟丙多胺基铵)基二硫代甲酸钠(PDAMHACDTC),采用元素分析、红外光谱、紫外光谱和核磁共振谱对其结构进行表征。考察了其对含Cu2+废水的处理效果,以及絮体的沉降速度;测定了微絮体的ζ电位,采用扫描电镜考察了絮体的形貌。结果表明,当PDAMHACDTC中—CSS-与Cu2+的物质的量之比接近2∶1,对Cu2+的去除率大于99.7%,残余Cu2+浓度远低于国家污水综合排放一级标准0.5 mg/L;在相同—CSS-投加量时,形成的微絮体的ζ电位和絮体沉降速度分别比以聚(二甲基二烯丙基氯化铵-丙烯酰胺)为母体合成的两性高分子螯合絮凝剂(ACPF)形成絮体大,说明PDAMHACDTC比ACPF更利于中和絮体上过剩负电荷,促进絮体的形成和生长。     

The proton exchange membrane fuel cell systems using methanolysis of sodium borohydride as a hydrogen source with cobalt catalysts

Constant hydrogen generation via a hydrogen generator is evaluated from the methanolysis of sodium borohydride (NaBH₄) using Co/Al₂O₃ and MnO_x/Al₂O₃ catalysts. Chemical borohydrides coupled with catalysts can be used for compact storage and to create efficient generation systems. Thus, we first report the catalytic activity of MnO_x/Al₂O₃, which is synthesized using the simple wet-impregnation method, for the methanolysis reaction. The results indicate that both catalysts can effectively accelerate the methanolysis reaction and provide constant hydrogen generation rates. Thus, we integrate this hydrogen generation system into a proton exchange membrane fuel cell stack (PEMFC) to determine whether it can be used as a portable power supply. As a result, this fuel cell system operates at 40 W for 1 hr using the hydrogen source supplied from the catalytic methanolysis reaction.     

Ethanol production from alkali-pretreated oil palm empty fruit bunch by simultaneous saccharification and fermentation with mucor indicus

Oil palm empty fruit bunch (OPEFB) is a potential raw material for production of lignocellulosic bioethanol. The OPEFB was pretreated with 8% sodium hydroxide (NaOH) solution at 100°C for 10 to 90 min. Enzymatic digestion was carried out using cellulase and β-glucosidase at 45°C for 24 h. It was then inoculated with Mucor indicus spores suspension and fermented under anaerobic conditions at 37°C for 96 h. Sodium hydroxide pretreatment effectively removed 51–57% of lignin in the OPEFB and also its hemicellulose (40–84%). The highest glucan digestibility (0.75 g/g theoretical glucose) was achieved in 40-min NaOH pretreatment. Fermentation by M. indicus resulted in 68.4% of the theoretical ethanol yield, while glycerol (16.2–83.2 mg/g), succinic acid (0–0.4 mg/g), and acetic acid (0–0.9 mg/g) were its by-products. According to these results, 11.75 million tons of dry OPEFB in Indonesia can be converted into 1.5 billion liters of ethanol per year.     

模拟氯化钠盐渣的高温处理

采用高温处理法对模拟氯化钠盐渣（简称盐渣）进行处理,研究了加热过程中气体有机物产生量随加热时间的变化规律以及加热温度对气体有机物产生量的影响,并分析了盐渣的高温处理效果。实验结果表明：含苯盐渣、含异丁醇盐渣、含氯苯盐渣、含二甲苯盐渣和混合盐渣在高于盐渣中所含有机物沸点30 ℃的条件下加热120 min,盐渣中的有机物去除率均大于99.99%;混合盐渣的加热温度越高,气体有机物的产生速率越快,相同时间内有机物的去除率也越大;盐渣中有机物的气化分离可分为3个阶段,初始阶段有机物气化速率较小,中间阶段气体有机物产生量迅速增加,最后阶段大部分有机物从盐渣中气化分离;盐渣中的有机物在高温气化时,会发生一定的化学反应,有微量的新物质生成。     

海藻酸钠-聚乙烯醇-聚乙二醇复合膜的制备及其对Cu2+的吸附

采用聚乙烯醇（PVA）、聚乙二醇（PEG）对海藻酸钠（SA）进行改性,制备了一种新型高效SA-PVA-PEG复合膜。研究了该复合膜对Cu²⁺的吸附效果。用IR和SEM等手段对复合膜进行了表征。表征结果显示,复合膜内部存在孔状结构,有利于吸附Cu²⁺。实验结果表明：在初始Cu²⁺质量浓度50 mg/L、复合膜加入量1 g/L、废水pH=5、吸附温度30 ℃、吸附时间60 min的最佳条件下,吸附率最高可达90.1%,吸附量达25.3 mg/g;复合膜吸附Cu²⁺的动力学过程可用二级动力学方程和Elovice方程进行拟合,吸附过程符合Langmuir单层吸附理论。采用浓度为1 mol/L的HCl溶液对吸附后的复合膜进行解吸,当解吸时间为2 min时,解吸率可达80.0%。     

硫化物沉淀法处理含铅废水

采用硫化物沉淀化处理含铅废水,考察了Na2S投加量、反应初始pH等操作条件对铅离子去除效果的影响,以及硫化铅沉淀反应过程的动力学特征,并采用激光粒度分析仪对反应生成的硫化铅沉淀的粒径分布进行了测定。实验结果表明,S2-与废水中Pb2+之间的沉淀反应能较好地符合一级反应动力学特征;Na2S与Pb2+的最佳物质的量之比为3;最佳的反应初始pH为6～9。在最佳操作条件下,Pb2+的平均去除率为99.60%,反应出水中Pb2+平均浓度为0.13 mg/L,低于污水综合排放标准(GB8978-1996)中铅的排放浓度限值。反应生成的硫化铅沉淀的平均粒径为2.62μm,具有较好的沉淀性能,能够通过沉淀的方式与废水分离。     

Extracellular antimutagenic activities of selected probiotic Bifidobacterium and Lactobacillus spp. as a function of growth phase

The capabilities of selected strains from genera Lactobacillus and Bifidobacterium to produce extracellular bioactive compounds with antimutagenic properties against benzo[a]pyrene (BaP) and sodium azide (SA) were tested as a function of growth phase. The bacterial supernatants from exponential and stationary phases were characterized with different patterns of antimutagenic activity against the two mutagens. All lactobacilli exhibited either no effect or low antimutagenicity against BaP during exponential growth. Higher antimutagenic activities of lactobacilli supernatants were observed in the stationary phase against SA as well. An exception was Lactobacillus sakei 23K which expressed a relatively low percent of inhibition of mutagenesis (PI = 28.14 ± 7.41) in the exponential phase and no antimutagenic activity in the stationary phase. Of the bifidobacteria, only Bifidobacterium adoleascentis ATCC 15703 exhibited higher antimutagenecity against BaP in the exponential phase. The same bacterial supernatants however, did not possess any antimutagenicity against SA in either the exponential or stationary phases. B. bifidum ATCC 11863 did not express any significant differences in its activity against either BaP or SA in the exponential or stationary phases. Only B. breve ATCC 15700 expressed a high antimutagenic effect against SA in the stationary phase but exhibited no effect during exponential growth. Overall, bacterial antimutagenic responses were associated with growth phase and type of mutagen.