Thermal cracking of oils from waste plastics

Thermal cracking of decomposed waste plastic oil produces a good yield of olefins. The solvent extraction of such waste plastic oil seems to be efficient for increasing gas yields and recycling monomers. To assess the potential of monomer recovery from municipal waste plastics, the oils were cracked using a laboratory-scale quartz-tube reactor. The waste plastic oils were provided by two commercial plants of the Sapporo Plastic Recycle Co. and the Dohoh Recycle Center Co. in Japan. A model waste plastic oil made in a laboratory was also examined. Yields of ethene, propene, and other products were measured at different temperatures. Two-step pyrolysis reduces coking compared with the direct thermal degradation of plastics. The raffinates from waste plastic oils extracted by sulfolane were also cracked. The primary products were almost the same as those from nontreated oils. The maximum total gas yield was 78wt%–85wt% at 750°C, an increase of about 20wt% compared with that of nonextracted oil. Solvent extraction removes stable aromatic hydrocarbons such as styrene, which is more coked than cracked.     

黄腐酸的萃取和性质研究

黄腐酸是腐植酸中最具活力的组成部分,蕴藏量丰富,萃取方法简便。研究了从红原1#泥炭中萃取黄腐酸和降解物。它的分子量较小,易溶于水,抗絮凝性能好,分子内含有较多的活性官能团,具有很高的化学活性和生物活性,用途广泛。     

用烧结法从沸腾炉渣中提取铝和铁的研究

把沸腾炉渣和石灰及精煤混合制成小球,然后在大约1 000 ℃下烧结.取不同烧结时间的样品用硫酸浸取,得到含有铝离子和铁离子的溶液.试验表明,采用浓度为4 mol/l的硫酸,在80 ℃下浸取烧结球样品(50%沸腾炉渣∶40%精煤∶10%石灰)24 h,可以得到铝和铁的最大提取率,分别为86.50%和94.60%.滤渣可以作为固化材料用于高速公路的路基建设或水泥生产中的添加剂.     

响应面法优化养殖水体中炔雌醇的固相萃取条件

在单因素试验、Plackett-Burman设计试验基础上,采用Box-Behnken响应面法对养殖水体中炔雌醇(EE2)的固相萃取条件进行优化。结果表明,洗脱液体积、洗脱液组成和淋洗液体积是影响EE2固相萃取回收率的3个主要因素;EE2的最佳固相萃取条件为:水样pH值为3,进样流量为3.0 mL/min,淋洗液为体积分数为10%的甲醇水溶液,淋洗液体积7.0 mL,洗脱液为乙酸乙酯-正己烷混合溶液(体积比为9∶1),洗脱液体积12.0 mL。该条件下养殖水样中EE2固相萃取回收率为81.6%～86.7%。     

Direct supercritical fluid extraction from water

Abstract

This paper describes the development of apparatus suitable for direct supercritical fluid extraction of organics from water. Results are presented for the extraction of pentachlorophenol present in water at concentrations of the order of 0.1 ppm. The effect of changes in apparatus design and supercritical fluid flow rate on recovery are discussed.     

Microwave extraction of incurred salinomycin from chicken tissues

Abstract

A rapid, accurate, environmentally friendly and cost‐effective microwave extraction technique was developed for the extraction of spiked and incurred salmomycin from chicken tissues (kidney, liver, muscle, ovarian yolk and fat). Extraction of salinomycin from various tissues was achieved by irradiating the sample in absolute ethanol and 2‐propanol (15+2) for 9 sec. in a common household microwave oven. The extract was analysed without further cleanup by HPLC on a C₁₈ column (5 μm) and detected at 592 nm via post‐column reaction with 4‐dimethylaminobenzaldehyde (DMABA) in a heated reactor coil at 86° C. Recoveries of salinomycin from spiked tissues at 30 ng/g level ranged between 87 and 100%. The limit of quantitation was found to be 10 ng/g. The developed method was applied for the analysis of incurred tissues and ovarian yolk of laying chickens given sodium salinomycin in feed at different levels for 14 consecutive days followed by withdrawal periods. Residues were detected in all tissues and ovarian yolk at 0 withdrawal time but declined during the withdrawal period. Highest residue were found in fat and ovarian yolk.     

泄漏检测与维修技术在芳烃抽提装置的应用研究

采用泄漏检测与维修（ LDAR）技术进行了全面检测和统计分析，分析泄漏的原因并通过维修减少泄漏。结果表明：芳烃抽提装置容易泄漏的元件主要为连接件和阀门，主要分布在泵区；SV≥5000μmol／mol的泄漏密封点占总密封点数的0.57％，对总泄漏量的贡献达到了82％，是造成泄漏排放的主要部分。设备管阀件泄漏造成的加工损失率为0.0009％，泄漏点停工维修修复率为83％，停工维修后整体泄漏率为0.03％；VOCs减排率为71％。     

铬渣中铬的浸出行为

采用BCR法连续浸提研究铬渣中铬的存在形态,结果表明:铬渣中总铬和六价铬主要以残渣态和可氧化态形式存在;通过铬渣动态连续浸提实验与静态浸提实验研究了浸提剂和活性炭对铬渣中铬浸出行为的影响,研究发现p H值为3.1的醋酸浸提剂浸出液中铬浓度最低,且添加活性炭后的静态浸出液中铬的浓度有不同程度降低。     

超高“Z型”中庭高度对自燃排烟特性影响的数值模拟研究

超过12m的超高中庭发生火灾时,常规排烟方法不能完全满足实际需求。通过FDS软件对某超高"Z型"中庭进行数值模拟,研究中庭高度对自然排烟特性的影响。该"Z型"中庭底层南面是自然进风口,顶层北面是自然排烟口,以烟气最先到达指定楼层人员危险时间值为到达危险时间。实验条件下模拟结果表明:无风情况下,中庭高度增加,到达危险时间增加,自然排烟效果增强。到达危险时间t与中庭高度h之间满足一定指数增长关系:t=y0+Aexp(h/α),中庭火源位置和中庭宽度对y0、A和α有一定影响。有风情况下,外界风向与进风口方向一致时,中庭自然排烟效果优于无风状况,中庭越高效果越强。在外界风向与排烟口方向相反时,烟气倒灌进中庭,自然排烟效果较弱。     

基于探采对比的煤层瓦斯含量分析及预测

针对新建矿井地勘瓦斯含量测值偏低和井下实测瓦斯含量较少的特点,结合工程和科研实践,提出了利用大量的工作面瓦斯涌出量反演煤层原始瓦斯含量技术和基于探采对比的煤层瓦斯含量预测方法。以邹庄井田32煤层为研究对象,在考虑瓦斯抽采情况下计算3204工作面瓦斯涌出量,并反演该工作面煤层原始瓦斯含量。通过对比采掘过程中获得的瓦斯含量和地勘瓦斯含量,得到不同钻孔深度时的地勘瓦斯含量修正系数,并采用瓦斯地质研究方法对32煤层分3个单元进行瓦斯含量预测。结果表明:32煤层瓦斯含量整体呈现"东部大于西部,北部大于南部"的规律,与临近矿井具有相似的瓦斯赋存规律。这表明利用探采对比的方法预测煤层瓦斯含量是可靠的。