厌氧平板膜生物反应器连续处理猪场废水研究

本研究以实际猪场废水为原料,在中温（37±1）℃条件下利用浸没式平板膜生物反应器进行180d连续厌氧发酵试验,以水力停留时间5,3和2d的梯度变化逐渐增加容积负荷,研究反应器运行性能,污泥比产甲烷活性,膜过滤特性和膜的清洗效果.试验结果表明,随水力停留时间的缩短,反应器的容积产沼气率分别达到0.68,1.03和1.12L/（L·d）,稳定运行期间出水的总挥发性脂肪酸分别为（169±41）mg/L,（15±3）mg/L和（114±45）mg/L,以乙酸为主.反应器中厌氧污泥的乙酸比产甲烷活性测试表明,以2000mg/L的乙酸为基质,HRT 3d时具有最大比产甲烷活性1.127g-COD/（g-VSS·d）.本试验发生膜污染的周期约4个月.采用2%的柠檬酸浸泡3h,可以恢复膜的过滤性能.在较低通量下,反应器中7~32g/L的污泥浓度并不会明显的影响平板膜的过滤性能.本研究结果显示,厌氧膜生物反应器有处理猪场废水的可能性.     

进料浓度对鸡粪长期高温甲烷发酵的影响

通过固定水力停留时间（HRT）为20d,逐步提高进料总固体（TS）浓度为5.0%,7.5%和10.0%的方式提高有机负荷（OLR）,在高温（55±1）℃条件下开展鸡粪长期甲烷发酵实验并测定了各阶段污泥的比产甲烷活性（SMA）,探究氨氮浓度对鸡粪高温甲烷发酵的影响.结果显示,当进料TS由5.0%增至10.0%,出料氨氮浓度由（2.5±0.3）g/L增至（6.1±0.2）g/L,挥发性脂肪酸（VFAs）由（0.4±0.1）g/L增至（26.1±1.5）g/L,pH值由（8.3±0.2）降至（6.9±0.1）,产气率由（267.2±12.5）mL/g TS_in降至49.8±8.2mL/g TS_in,甲烷浓度由（67.2±1.3）%降至（36.0±1.7）%.长时间采用TS 10.0%的进料浓度,发酵系统中氨氮浓度最高达到7.5g/L,VFAs浓度达到27.0g/L,产气下降明显.氨氮抑制鸡粪高温甲烷发酵产气的初始浓度为2.5~3.0g/L.进料TS大于7.5%,鸡粪高温甲烷发酵会受到氨氮抑制.氨氮浓度的升高导致高温发酵体系利用乙酸产甲烷的能力降低,氨氮浓度达到5.5g/L,SMA降低60.0%;氨氮浓度达到7.0g/L,污泥利用乙酸产甲烷的活动几乎停止.     

不同微生物菌剂对畜禽粪便堆肥效果的温度指标研究

温度是堆料中微生物生命活动的重要标志,它直接影响堆肥反应速率,是堆肥能否顺利进行的主要因素。通过在畜禽粪便（鸡粪、猪粪、牛粪）中加入辅料和不同微生物菌剂,进行好氧堆肥并测定堆料温度,根据温度结果明确不同微生物菌剂对不同粪便的堆肥效果。     

活化赤泥去除猪场废水生化处理出水中的磷和重金属

以铝矿工业废渣赤泥为原材料,采用焙烧活化方法进行活化处理,并将其用于畜禽废水生化处理出水中磷和重金属的吸附去除.同时,研究考察了吸附剂除磷、除重金属的能力以及投加量、pH值和反应时间对去除效果的影响.结果表明,赤泥和活化赤泥对磷、铜、锌、砷吸附规律符合Langmuir吸附等温方程;焙烧改性后,赤泥对磷、铜、锌、砷的去除能力显著提高,900℃焙烧活化饱和吸附量可分别由46.26、18.18 、15.45、18.83 mg·g-1提高至149.00、65.17、99.20、27.51 mg·g-1;pH显著影响除磷、除重金属的效果,高pH条件有利于磷、铜、锌、砷的去除;赤泥和活化赤泥除磷、铜、锌、砷的作用机理包含金属氧化物表面的表面络合作用机理,其对砷和磷的去除机理还包括共沉淀作用.     

猪粪污厌氧发酵沼液SS、COD的混凝预处理效果研究

通过混凝沉淀试验,运用无机、有机高分子混凝剂对猪粪污厌氧发酵沼液进行预处理,考察其悬浮物(SS)和COD的去除效果,探索混凝沉淀工艺对降低该类沼液后续处理难度的可行性。研究表明,投加2.6 g/L混凝剂N可去除沼液SS为44.9%~67.6%,同时添加5.0 mg/L阳离子型助凝剂,SS去除率最高,并同时可去除COD为33.3%,添加阳离子型助凝剂对SS和COD的去除均具有较好的促进作用,混凝沉淀处理后沼液SS与COD呈极显著正相关,说明可通过对SS进行优化去除的方式进一步协同削减沼液COD。     

膨润土对鸡粪序批式厌氧消化特性的影响

为考察外源添加物——膨润土对鸡粪厌氧消化特性的影响,在中温〔(35±1)℃〕条件下,采用L₈(23)正交试验设计,考察了膨润土添加量(w,以干基计,下同)、鸡粪VS(挥发性固体)添加量、厌氧消化污泥接种量对鸡粪厌氧消化过程中产气、pH、氨氮形态、EC(电导率)等的影响. 结果表明:添加1.5%和3.0%的膨润土均能显著提高鸡粪VS产CH₄量,并且在高鸡粪添加量情况下达到极显著水平(P<0.01);当膨润土添加量为3.0%、厌氧消化污泥接种量为20%时,VS累积产CH₄量达到301.92 mL/g,比对照组(160.76 mL/g)提高了87.80%;当鸡粪VS添加量相同时,添加1.5%和3.0%的膨润土均能极显著地降低消化料液的ρ(TAN)(TAN为总氨氮)(P<0.01),并且可以减少鸡粪厌氧消化过程中ρ(FAN)(FAN为游离氨)的剧烈变化;添加膨润土还能极显著地降低鸡粪厌氧消化料液的EC. 研究显示,添加膨润土有利于缓解鸡粪厌氧消化过程中氨氮抑制,提高系统稳定性,并可显著改善厌氧消化整体性能.      

鸟粪石法回收养猪废水中磷时pH对沉淀物组分的影响

采用鸟粪石沉淀法对养猪废水中的磷进行回收,应用红外光谱和X射线衍射法,并结合物料衡算研究pH变化对沉淀物组分的影响.结果表明,当pH由8.0升至9.0时,磷去除率从85%增加到94%;pH在9.0～11.0范围,磷去除率稳定在94%左右;当pH升高至12.0,磷去除率急剧下降至70％.沉淀物组分为鸟粪石(MgNH₄PO₄·6H₂O)、 钾型鸟粪石(MgKPO₄·6H₂O)、 Ca₃(PO₄)₂·xH₂O和Mg(OH)₂,不含有硫酸盐和碳酸盐.当pH<9.0,沉淀物组分主要为鸟粪石;pH在9.0～10.0范围时,鸟粪石含量降低,钾型鸟粪石、 Ca₃(PO₄)₂·xH₂O含量呈逐渐增加趋势;pH由10.0升至12.0时,鸟粪石含量急剧下降,Ca₃(PO₄)₂·xH₂O和Mg(OH)₂含量快速增加,而钾型鸟粪石快速增加并在pH 11.0达到最大后急剧下降.因此,回收养猪废水中的磷时要获得纯度高的鸟粪石产品,pH值应控制在8.0～9.0.     

BENEFITS FROM MANAGING FARM PRODUCED NUTRIENTS1

Manures and fertilizers are applied to agricultural lands in excess of recommended amounts, resulting in widespread pollution of surface and ground water and contributing a substantial source of greenhouse gases associated with global warming. By developing policies that exploit the value of farm produced nutrients, input costs can be minimized. Better accounting for or crediting of farm produced nutrients is leading to economically beneficial conservation of fertilizer. In addition, hog producers who own enough land may benefit from properly managing manure nutrients. Poultry litter is valuable as fertilizer and can be marketed by independent dealers to farmers in nutrient deficit areas, with very modest assistance from the government. Dairy producers may modify their past income support programs to finance central compost facilities. Although nutrient problems were neglected in the past, recent Federal initiatives and joint initiatives with states exploit many of these and other opportunities to avoid excessive application of nutrients to the land.     

RUNOFF OF METALS FROM ALUM-TREATED HORSE MANURE AND MUNICIPAL SLUDGE1

ABSTRACT: Land application of organic soil amendments can increase runoff concentrations of metals such as Fe and Zn, metalbids such as B and As, and non-metals such as P and S that have the potential for causing adverse environmental impacts. Aluminum sulfate, or alum (Al₂(SO₄)3*(14H₂O), can reduce concentrations of some materials in runoff from sites treated with organic amendments. The objectives of this study were to (a) quantify concentrations of selected constituents (Al, As, B, Ca, Cd, Co, Fe, K, Mg, Mn, Mo, Na, P, Pb, 5, Se, Ti, and Zn) in runoff from plots treated with horse manure (mixed with stall bedding) and municipal sludge, (b) assess runoff quality effects of alum addition to those treatments, and (c) determine time variations in concentrations of the constituents. Horse manure and municipal sludge were applied to twelve 2.4 by 6.1 m fescue plots (six each for the manure and sludge). Alum was added to three of the manure-treated and three of the sludge-treated plots. Simulated rainfall (64 mm/h) was applied to the 12 treated plots and to three control (no treatment) plots. The first 0.5 h runoff was sampled and analyzed for the constituents described above. Addition of manure or sludge had no effect on runoff concentrations of the majority of constituents. In some cases (e.g., Al, As, Fe, Zn), however, concentrations were near or in excess of threshold values recommended for marine wildlife protection. Alum addition increased runoff of Al, Ca, K, and 5, due likely to its composition and by the addition of lime to counteract the acidity of alum. Concentration decreases of more than 50 percent were noted for P for the horse manure treatment. No alum effect was detected for P in runoff from the sludge-treated plots, possibly due to relatively stable P forms in the sludge. Runoff concentrations of Al, As, Fe, K, Mn, and P followed an approximately first-order decline with respect to time. Runoff concentrations of Ca and 5, however, peaked during the second runoff sample (four minutes following initiation of runoff), suggesting that differences in mobility and/or transport mechanisms exist among the materials investigated.     

混合堆肥过程中挥发性固体含量的层次效应及动态变化

城市污泥与猪粪混合堆肥表明:升温期和高温期堆体上部有机物降解的差异较大,降温期堆体下部各层有机物降解的差异较大,且堆体内挥发性固体(VS)含量已形成明显的层次效应,腐熟期堆体中部有机物降解的差异较大,堆体内VS含量的层次效应仍很明显;不同堆肥期堆体内VS含量的差异由大到小分别为:降温期≥腐熟期>高温期>升温期,不同部位有机物降解程度由大到小为:上部>中部>下部;VS含量随时间的变化满足一级反应动力学方程,城市污泥和猪粪混合堆肥过程中VS的降解速率约为0.3kg·d^-1,VS含量降低了8.2%.