改性油页岩灰渣对水中DNBP吸附去除效果

采用PDMDAAC改性方法对油页岩灰渣进行改性,确定最佳改性方案,并研究了环境因素对改性油页岩灰渣吸附DNBP的影响。实验研究结果表明,油页岩灰渣经20 g/L 的PDMDAAC处理时,对DNBP的吸附能力最强。在吸附温度为30℃,初始溶液pH值为4的条件下,0.3 g 的改性油页岩灰渣对30.0 mg/L DNBP溶液50 mL,吸附120 min时,其吸附率达到94.48%以上。在实验条件下,改性油页岩灰渣对DNBP的吸附符合Langmuir和Freundlich等温吸附方程,相关系数分别为0.9985和0.9776,其对DNBP的理论饱和吸附量达到6.196 mg/g。改性油页岩灰渣对DNBP的吸附主要归因于离子交换和表面吸附作用。     

CaCl2高温热处理垃圾焚烧飞灰中重金属的挥发特性

以深圳市某垃圾焚烧厂飞灰为原料,采用高温管式电阻炉,研究了在0.6 L/min N₂气氛下,CaCl₂在不同添加量、处理温度及处理时间下对飞灰中重金属Pb、Cd、Zn和Cu挥发特性的影响,并对收集到的二次飞灰进行成分及物相分析。结果显示,X射线衍射仪和EDS分析表明,二次飞灰主要是由NaCl、KCl和部分SiCl₄组成,Zn主要以K₂ZnCl₄形式挥发,而Pb则主要以氧化物PbO和Pb₃SiO₅的形式挥发。最终得到CaCl₂热处理飞灰的最佳二次气化条件:以0.6 L/min N₂为载气,添加14 wt%的CaCl₂,在1 100℃高温下处理2.5 h。经CaCl₂热处理后的剩余飞灰,其浸出毒性达到了《生活垃圾填埋场污染控制标准》要求。     

铝灰酸溶法制备聚合氯化铝

以铝灰为原料采用酸溶法制备了聚合氯化铝（PAC）,并通过正交实验优化了PAC制备的最佳工艺参数,并考察了自制PAC对废水COD的去除效果。制备PAC的最佳工艺条件为：m（铝灰）∶V（HCl）∶V（H₂O）=10∶20∶40,反应温度85℃,反应时间2.5h,搅拌转速80r/min,熟化时间30h,熟化温度60℃。采用生石灰可高效、经济地调节产品的盐基度,且产品在处理印染废水时COD去除率达64.7%,高于市售同类产品。     

粉煤灰两步水热法制备人工沸石

以粉煤灰为原料,采用两步水热法制备人工沸石。SEM、XRD、X射线荧光光谱分析结果表明:制得的人工沸石纯度较高,主要为Na-A型沸石和少量13X型沸石,主要化学成分为SiO2和Al2O3。说明采用两步法制备人工沸石克服了传统水热法杂质含量高的缺陷。采用人工沸石处理初始Mn2+质量浓度为50.00mg/L的模拟含锰废水,吸附125min后,Mn2+去除率达98.19%,模拟废水中剩余Mn2+质量浓度为0.90mg/L。     

粉煤灰的改性、成型及深度除磷应用

选择合适的改性剂对粉煤灰进行改性,通过有机高分子交联方法对改性粉煤灰进行成型处理,并采用静态吸附法评价改性粉煤灰的深度除磷效果。采用1 g氢氧化铝改性粉煤灰处理100 mL磷质量浓度为10.0 mg/L的模拟废水,磷去除率可达99.70％,处理后模拟废水中磷质量浓度低于0.50 mg/L, 达到GB8978-1996《污水综合排放标准》。成型处理可提高粉煤灰的沉降速率,改善灰水分离效果。经超声再生后的成型氢氧化铝改性粉煤灰的磷去除率仍可达67.9％。     

Fluid bed gasification – Plasma converter process generating energy from solid waste: Experimental assessment of sulphur species

Often perceived as a Cinderella material, there is growing appreciation for solid waste as a renewable content thermal process feed. Nonetheless, research on solid waste gasification and sulphur mechanisms in particular is lacking. This paper presents results from two related experiments on a novel two stage gasification process, at demonstration scale, using a sulphur-enriched wood pellet feed.Notable SO₂ and relatively low COS levels (before gas cleaning) were interesting features of the trials, and not normally expected under reducing gasification conditions. Analysis suggests that localised oxygen rich regions within the fluid bed played a role in SO₂’s generation. The response of COS to sulphur in the feed was quite prompt, whereas SO₂ was more delayed. It is proposed that the bed material sequestered sulphur from the feed, later aiding SO₂ generation. The more reducing gas phase regions above the bed would have facilitated COS – hence its faster response. These results provide a useful insight, with further analysis on a suite of performed experiments underway, along with thermodynamic modelling.     

脱硫灰用作钙质材料制备蒸压加气混凝土砖块

为实现半干法脱硫灰的资源化利用,采用半干法脱硫灰作为蒸压加气混凝土砖块中的钙质材料。对脱硫灰进行预处理,使其在含水量20%条件下消化2 h后,烘干。在其他条件不变情况下,掺入经过预处理后的脱硫灰,砖块的抗压强度会有明显的提高。增加经过预处理后的脱硫灰的掺入量,可以在不影响砖块的抗压强度性能的基础之上,降低砖块的干燥收缩值和导热系数,同时提高砖块的抗冻性能和保温隔热性能。     

粉煤灰微波改性及其对Cr~（6＋）的吸附特性

将粉煤灰（fly ash,FA）微波辐照制得微波改性粉煤灰（MFA）,选择用H2SO4、NaOH和Ca（OH）2对MFA进行化学改性制得微波化学改性粉煤灰（MMFA）,结果表明,用2 mol/L NaOH并按与MFA的质量体积比为1∶4制得的MMFA对Cr6＋的吸附去除效果最好,与原灰相比,去除率显著增强。研究了NaOH改性MMFA对废水中Cr6＋的吸附性能。动力学研究结果表明,MMFA对Cr6＋的吸附动力学符合二级吸附动力学速率方程,吸附受颗粒内扩散过程控制。热力学研究结果表明,在25、35和45℃下MMFA对Cr6＋的等温吸附行为均可用Langmuir方程、Freundlich方程和线性方程描述,所得热力学参数吸附自由能（ΔG）、吸附焓（ΔH）和吸附熵（ΔS）均为负值,说明MMFA对Cr6＋的吸附过程为自发进行的放热吸附过程。     

Wood pellet fly ash and bottom ash as an effective liming agent and nutrient source for rye grass (Lolium perenne L.) and oats (Avena sativa)

Fly ash (FA) and bottom ash (BA) from a softwood pellet boiler were characterized and evaluated as soil amendments. In a greenhouse study, two plant species (rye grass, Lolium perenne L. and oats, Avena sativa) were grown in three different treatments (1% FA, 1% BA, non-amended control) of a silty loam soil. Total concentrations of plant nutrients Ca, K, Mg, P and Zn in both ashes were elevated compared to conventional wood ash. Concentrations of Cd, Cr, Pb, Se and Zn were found to be elevated in the FA relative to BA and the non-amended soil. At 28 d, oat above-ground biomass was found to be significantly greater in soil amended with FA. Potassium and Mo plant tissue concentrations were significantly increased by addition of either ash, and FA significantly increased Zn tissue concentrations. Cadmium and Hg tissue concentrations were elevated in some cases. As soil amendments, either pellet ash is an effective liming agent and nutrient source, but high concentrations of Cd and Zn in FA may preclude its use as an agricultural soil amendment in some jurisdictions. Lower ash application rates than those used in this study (i.e. <1%) may still provide sufficient nutrients and effective neutralization of soil acidity.     

改性粉煤灰处理低浓度含磷废水的研究

以酸改性粉煤灰为吸附剂,处理低质量浓度(1 mg/L左右)磷酸盐溶液,探讨了改性剂的种类、改性剂用量、吸附剂用量、反应时间、pH以及温度对除磷效果的影响.结果表明:(1)经过酸改性后粉煤灰的磷去除率显著提高,而且硫酸改性粉煤灰的除磷效果更好,磷去除率最高可达97.68％.(2)最佳条件:选择硫酸用量为5 mL/g进行改性,硫酸改性粉煤灰投加量为2.0g,反应时间为60 min,pH为7.2～10.8,温度为25℃(即室温).(3)改性粉煤灰对磷的吸附更符合Freundlich吸附等温模型,既有物理吸附,也有化学吸附,并以Ca、Mg氧化物与磷形成磷的沉淀物为主.