微波技术在固体废弃物处理中的应用

介绍了微波加热的基本原理,综述了微波技术在工业污泥、医疗垃圾、废旧轮胎、电子垃圾以及建筑垃圾等固体废弃物处理中的应用现状,展望了微波技术在污染控制领域的应用前景.     

废水活性污泥生物处理中的丝状细菌

论述了丝状细菌在废水生物处理中的种类、生理特性及对生物处理系统有利与不利的一面;阐述了产生的原因及其控制措施.     

底泥中营养物质及其他污染物释放机理综述

水体底泥(沉积物)污染,是世界范围内的一个重要环境问题.其污染物主要通过大气沉降、废水排放、水土流失、雨水淋溶与冲刷进入水体,最后沉积到底泥中并逐渐富集,使底泥受到严重污染.总结了底泥中氨氮、重金属的影响因素及释放机理,也指明了持久性有机污染物释放机理研究不足的现状,提出对其释放机理研究的重要性.     

好氧颗粒污泥沉降选择实验研究与定量描述

以序批式反应器培养的成熟好氧颗粒污泥为对象,研究沉淀高度对颗粒数、比重、污泥浓度、粒径分布及选择系数的影响.结果表明,随着沉淀高度的增加,污泥浓度在沉淀时间为30 s时由0.24 mg.L-1明显增加至6.07 mg.L-1,平均粒径从450μm增加到550μm,颗粒圆形度增加12.67%,而复杂度减小13.47%,说明粒径较大、形状较规则的颗粒沉降较快,从而更易在沉降选择过程中得以保留.根据选择压原理,结合颗粒污泥沉降实验结果引入选择系数.实验和计算结果显示,在任意沉淀高度,选择系数随粒径和密度的增大而增加.随着沉淀高度的增加,直径>600～800μm的颗粒选择系数增加,小颗粒趋势与之相反,说明增大排水比有利于大颗粒保留而絮体被筛选出反应器,而低的排水比会使污泥颗粒化过程放缓.该研究结果可望对加速污泥颗粒化过程和提高其稳定性提供科学的理论依据和指导.     

南海海港疏浚淤泥悬浮物对海洋动物的急性毒性效应

为评价海港疏浚淤泥对倾倒海区海洋动物的影响,对疏浚淤泥悬浮相进行了生物急性毒性试验。研究结果表明：疏浚淤泥悬浮相对浮游甲壳类的致毒效应明显。22.0～24.0℃试验水温时,悬浮相对卤虫无节幼体和浮游挠足类的急性毒性试验结果分别为：96hLC₅₀为71.6mg/L（卤虫无节幼体）,48hLC₅₀为61.3mg/L（浮游挠足类）。低浓度和低温时,悬浮相对前鳞鲻（Mugilophuyseni）幼鱼的致毒效应不明显。随温度的升高,毒性效应亦增强。试验水温为18.8～20.0℃时,悬浮相对前鳞鲻幼鱼24h和96hLC₅₀分别为5801.3mg/L和5045.5mg/L;而当试验水温升至22.0～24.0℃时,悬浮相对前鳞鲻幼鱼24、48、72、96hLC₅₀分别为1996.4、769.9、592.8及556.3mg/L。     

Effect of organic matter on phosphorus recovery from sewage sludge subjected to microwave hybrid pretreatment

Microwave (MW) hybrid processes are able to disrupt the flocculent structure of complex waste activated sludge, and help promote the recovery of phosphorus as struvite. In this study, to optimize struvite yield, (1) the characteristics of matter released in MW-hybrid treatments were compared, including MW, MW-acid, MW-alkali, MW-H₂O₂, and MW-H₂O₂-alkali. The results showed that selective release of carbon, nitrogen, phosphorus, Ca^2 +, and Mg^2 + achieved by sludge pretreatment using MW-hybrid processes. MW-H₂O₂ is the recommended sludge pretreatment process for phosphorus recovery in the form of struvite. The ratio of Mg^2 +:NH₄⁺-N:PO₄^3 −-P was 1.2:2.9:1 in the supernatant. (2) To clarify the effects of organic matter on struvite recovery, the composition and molecular weight distribution of organic matters were analyzed. Low molecular weight COD was found to facilitate the removal rate of NH₄⁺-N and PO₄³-P via crystallization, and the amorphous struvite crystals (< 1 kDa) from the filtered solutions had high purity. Therefore, the present study reveals the necessity of taking into consideration the interference effect of high molecular weight organic matters during struvite crystallization from sewage sludge.     

污泥热水解技术研究进展

热水解可以改善污泥的生物降解性能和脱水性能,提高后续厌氧消化系统中有机物的去除率。本文阐述了热水解对污泥物理特性主要包括流变特性和脱水行为的影响;分析了热水解对污泥中氨氮浓度及对厌氧消化的作用;同时介绍了热水解技术对整个污泥处理系统能量需求的影响。指出：热水解改善了污泥的厌氧消化性能,提高了沼气等再生资源的产量,且厌氧消化产生的沼气量与热水解技术所需的能量基本平衡。     

Differences in rheological and fractal properties of conditioned and raw sewage sludge

Rheological tests for raw and conditioned activated sludge(AS) or anaerobic digested sludge(ADS) show that power-law relationships can be used to describe the evolution of several rheological parameters,i.e.,limiting viscosity(η∞),yield stress(τy),cohesion energy of the sludge network(Ec),and storage modulus(G’),with total suspended solid(TSS) content in raw and conditioned sludge.A gel-like structure that behaves similar to weak-link flocs/aggregates was observed in AS and ADS.As derived from the double-logarithmic plots of G’-TSS content,the mass fractal dimensions of the raw and conditioned AS or ADS flocs/aggregates were 2.70 and 2.53 or 2.85 and 2.79,respectively.The rheological tests also indicate that both polymer conditioning and increased TSS content led to improved elastic behavior,cohesion energy,and yield stress of the sludge network,as well as expanded the corresponding linear viscoelastic range.The porosity of AS or ADS flocs/aggregates will be improved by polymer conditioning.     

镍基催化剂对污泥微波热解制生物气效能的影响

为实现污水污泥减量化、无害化及资源化的目标,在微波热解污水污泥基础上,进行了镍基催化剂对制取生物气效能影响的研究。采用元素分析对污泥元素进行检测,气/质联用分析(GC-MS)和气相色谱(GC)对热解生物气的组成和含量进行测定。实验结果表明,镍基催化剂的添加对微波热解污水污泥制取生物气有较大促进作用。5%添加量与800℃热解终温条件下具有最佳催化效果:生物气中H2、CO产量最大,H2产量由29 g/kg增加到35.8 g/kg,提升23.4%,CO产量由302.7 g/kg增加到383.3 g/kg,提升26.6%;同时催化剂还能提高热能利用效率,降低热解终温,即5%添加量在700℃热解终温时可达到空白800℃时的产气效果;镍基催化剂主要在500~600℃时发挥催化作用,加快了H2和CO的释放。微波热解污泥制取的生物气具有产量大、富含H2与CO等优点,可推动污水污泥的资源化进程。     

印染污泥焚烧烟气污染控制案例分析

以广东省某两家印染厂的印染污泥焚烧项目为主要研究对象,从污泥处理技术路线、焚烧设备及烟气处理流程等各方面入手,对各厂印染污泥与煤混烧烟气中颗粒物、NOx、SO2、酸性气体(HF、HCl)和重金属等污染物的进行采样分析,并对各厂现有烟气污染物控制设施的运行效果进行调研,结果表明,布袋除尘的效果较为理想,除尘效率可达99%以上;使用印染废水作为吸收液的湿法脱硫技术对SO2及酸性气体的去除效果不理想;SNCR对NOx具有一定的去除效果,是一种较为经济、高效的脱硝技术;焚烧后,大部分重金属最终以飞灰的形式被除尘器去除,但仍有部分重金属如Hg在出口烟气中的浓度仍然很高,需要采取必要的措施控制烟气中的重金属. 此外,基于印染污泥焚烧实例分析,提出适于印染污泥与煤混烧烟气处理工艺流程.