活性炭纤维净化印刷过程产生的VOCs废气

介绍了应用局部排气的方法,收集印刷过程的挥发性有机化合物（VOCs）废气,应用活性炭纤维（ACF）吸附脱附有机废气回收净化装置,进行印刷厂VOCs废气的回收与治理,详细描述了印刷车间VOCs废气的收集与处理工艺过程及其效果.测试结果表明,应用此工艺和设备可以有效地进行印刷过程大风量的VOCs废气的回收和治理.     

海洋柴油溢油油水快速分离的应用研究

针对海洋柴油溢油,采用破乳剂对油水快速分离进行了研究.分别对油水比、温度、破乳剂量及存在Ca2 、Mg2 的影响因素,进行了系列油水快速分离试验,并测定了破乳剂作用下乳液的界面张力.试验结果表明,柴油溢油形成的乳液稳定性较差,油水分离较容易,但分离后的水中含油量较高.加入聚醚类非离子型破乳剂FA、FB、FC和FD,可达到油水低温、快速分离的目的,且分离后的水中含油量较低.随着破乳剂浓度的增加,界面张力降低,当破乳剂浓度达到临界胶束浓度(CMC)时,界面张力最小,脱水效果最好.Ca2 、Mg2 对聚醚类非离子型破乳剂的影响很小.     

基于不同基质的强化生物除磷系统中生化反应机理研究进展

阐述了3种不同基质(乙酸盐、丙酸盐和葡萄糖)在强化生物除磷系统中的生化模型反应机理.重点介绍了聚磷菌(PAOs)、聚糖菌(GAOs)和产乳酸菌在厌氧/好氧条件下对能量及还原力(NADH2)的利用方式;聚-β-羟基链烷酸盐(PHA)的合成方式及存在形式,糖原、乳酸(L型)的代谢途径等.虽然控制基质条件可以实现稳定的强化生物除磷效果,但目前的生化模型并不能完全解释所有的代谢过程,今后要在分离纯种的PAOs及相关生化代谢过程中酶的活动等方面进行深入研究.     

Baseline study of methane emission from open digesting tanks of palm oil mill effluent treatment

Anthropogenic release of greenhouse gases, especially CO₂ and CH₄ has been recognized as one of the main causes of global warming. Several measures under the Kyoto Protocol 1997 have been drawn up to reduce the greenhouse gases emission. One of the measures is Clean Development Mechanisms (CDM) that was created to enable developed countries to cooperate with developing countries in emission reduction activities. In Malaysia, palm oil industry particularly from palm oil mill effluent (POME) anaerobic treatment has been identified as an important source of CH₄. However, there is no study to quantify the actual CH₄ emission from the commercial scale wastewater treatment facility. Hence, this paper shall address the CH₄ emission from the open digesting tanks in Felda Serting Hilir Palm Oil Mill. CH₄ emission pattern was recorded for 52 weeks from 3600 m³ open digesting tanks. The findings indicated that the CH₄ content was between 13.5% and 49.0% which was lower than the value of 65% reported earlier. The biogas flow rate ranged between 0.8 l min⁻¹ m⁻² and 9.8 l min⁻¹ m⁻². Total CH₄ emission per open digesting tank was 518.9 kg day⁻¹. Relationships between CH₄ emission and total carbon removal and POME discharged were also discussed. Fluctuation of biogas production was observed throughout the studies as a result of seasonal oil palm cropping, mill activities, variation of POME quality and quantity discharged from the mill. Thus only through long-term field measurement CH₄ emission can be accurately estimated.     

砷华生产废渣中硫的回收利用研究

高温下氧化焙烧细磨后的砷华生产废渣，利用软锰矿浆吸收产生的SO2气体，吸收液经净化除杂、浓缩结晶等工序可制备工业产品硫酸锰。适宜的焙烧条件如下：焙烧温度为650℃，焙烧时间为60min，废渣粒度为-97μm。选择合适的吸收工艺，Mn的浸出率可达96．20％，此时SO2脱除率为87．20％。     

固体废弃物轮胎的热解技术

综述了国内外对废轮胎的处理状况，并详细地讨论了废轮胎热解技术的发展、分类以及典型工艺流程。热解技术主要包括油化技术、气化技术和炭化技术三种，并可制得衍生油、燃料气、碳黑等产品。分析了废轮胎热解工艺存在的问题，指出了如何开发环境友好的集成工艺是废轮胎热解工艺的发展方向。     

Toxic Effects of Crude Oil Combined with Oil Cleaner Simple Green on Yolk-sac Larvae and Adult Rainbow Trout Oncorhynchus mykiss (4 pp)

Background, Goal and Scope Cleaner CRYSTAL Simple Green (SG) was used for the cleanup of the oil spill in the Baltic Sea near Lithuania in 2001. No scientific data are available on the effects and consequences of its application for local aquatic life. The aim of this study was to determine and compare sublethal effects of a) solution SG; b) crude oil alone; c) SG in combination with oil on rainbow trout Oncorhynchus mykiss at different stages of its development in laboratory conditions.Methods Laboratory studies were performed on adult rainbow trout (4-day duration) and on yolk-sac larvae (25-day duration) evaluating their biological parameters. Concentrations of water-soluble and thin-dispersed fractions of petroleum hydrocarbons were measured using gas chromatography.Results and Discussion SG solution (0.5 mg/l) did not affect the survival of larvae and adult fish, and no significant changes were determined in respiratory parameters of the exposed larvae and adult fish. The most expressed alterations were found in morphological parameters (a decrease in the average body mass) of larvae and in haematological indices (a decrease in the leukocyte count) of adult fish at the end of the tests. Crude oil (1610 mg/l) did not affect the survival of adult fish during the 4-day exposure. An increase in larvae mortality rate (~ 36%) was recorded at the end of the tests. A significant decrease in the average body mass and heart rate of larvae as well as in gill ventilation frequency of larvae and adult fish were determined. SG combined with oil induced an increase in larval mortality  46% of individuals died at the end of the tests. No mortality was recorded in adult fish. The average body mass and heart rate of larvae were significantly decreased. Marked changes were also found in respiratory parameters (gill ventilation frequency of larvae and adult fish significantly decreased, while “coughing” rate increased). A 1-day, 2-day exposure of fish to SG combined with oil induced a significant decrease in the leukocyte count of adult fish, which was also determined at the end of the tests. The augmentation of adverse impact could be explained by the data obtained from our studies. When SG was added into dilution water with crude oil the concentration of petroleum hydrocarbons in the mixture increased 3 ~ 4.5 times after 24 h and 96 h, respectively. Conclusions The comparative study of the effects of crude oil alone, SG and SG combined with oil showed that their toxic effects on fish differed. Oil combined with SG was found to be more toxic to fish (larvae and adults) than SG alone and oil alone. Fish at early stages of development (yolk-sac larvae) were more sensitive to the effects of the compounds studied than adults.Recommendations and Outlook To diminish the negative impact of oil spill cleanup using chemicals on aquatic ecosystems, it is recommended to carry out more comprehensive studies of their effects and after-effects in laboratory conditions using a wide scale of local aquatic organisms. The selected species of the most sensitive aquatic organisms should include those which are unable to escape the impact of combined action of oil and cleaners. Special attention should be directed to the research of effects of these pollutants on studied organisms at their most sensitive stages of life (reproduction, hatching, early stages of development), as after-effects of exposure to pollutants may be observed in future generations.     

桐油水解制备咪唑啉缓蚀剂及其量子化学研究

目的 开发原料价廉易得、能实际应用的缓蚀剂。方法 以桐油为原料,水解后得到桐油酸,然后与二乙烯三胺经过酰胺化和环化反应,生成桐油咪唑啉缓蚀剂。在模拟现场环境的条件下对所合成的桐油咪唑啉缓蚀剂进行电化学测试和高温高压性能评价。利用量子化学计算对桐油咪唑啉缓蚀剂的分子动力学进行模拟,探讨其在Fe表面的吸附作用。结果 红外光谱显示,桐油水解后可生成桐油酸,最终合成物为桐油咪唑啉。电化学测试表明,随着桐油咪唑啉缓蚀剂添加量的增大,20#测试钢片的自腐蚀电位逐渐提高,腐蚀电流降低。高温高压模拟实验显示,加入油酸咪唑啉后,腐蚀速率明显降低,由0.3181 mm/a降到了0.0392 mm/a。量子化学计算表明,桐油咪唑啉分子中的咪唑啉环会平行吸附于铁表面,形成一层缓蚀剂膜。结论 价廉易得的桐油经水解后可得桐油酸,再与二乙烯三胺经过酰胺化和环化反应最终合成了桐油咪唑啉缓蚀剂。该缓蚀剂添加量越大,对20#钢片的缓蚀效果越好,呈现出了较好的缓蚀效果,其分子结构中的咪唑环能平行吸附于铁表面,属于抑制阳极型缓蚀剂。     

长期侧流提取对EBPR系统除磷及其磷回收性能的影响

实验采用交替厌氧/好氧(An/O)运行模式的SBR反应器,考察310 d内分3个批次提取侧流比为0、1/4、1/3、1/2的厌氧放磷上清液后EBPR系统的脱氮除磷效果及相应的磷回收性能.结果表明,整个实验阶段系统对COD和氨氮的去除较为稳定,出水均能满足《城镇污水处理厂污染物综合排放标准》一级A标准,总氮去除因厌氧阶段反硝化不断增强有所提升,达标率由88.2%显著上升至98.6%.然而,随着厌氧上清液提取次数的增多,系统释磷能力整体下降,但前两个批次中系统除磷均稳定高效,去除率在90%以上,相应地出水磷达标率大于75%,仅第3批次实验中侧流比为1/2时系统除磷率出现大幅波动,最低降为54.2%,并贡献该批次出水磷不达标率的60%,说明长期提取1/2侧流比不利于主流工艺出水稳定维持.研究还发现,长期进行侧流磷回收实验有利于污泥减量,且对污泥沉降性能影响不大.因此,在EBPR系统内长期提取适当侧流比的厌氧上清液以进行磷回收与主流工艺同步高效脱氮除磷具有可行性.     

不同基质浓度对ANAMMOX菌短期储存的影响

在15℃±1℃条件下,将厌氧氨氧化菌混培物分别置于基质浓度为0、60、120 mg·L~(-1)添加比例为1∶1的NH+4-N和NO-2-N环境中短期(15 d)储存,探究不同基质浓度对厌氧氨氧化污泥短期保存及恢复的影响.经过短期储存后进行恢复实验,结果表明,1、2、3号反应器(分别对应0、60、120 mg·L~(-1)基质浓度中储存的厌氧氨氧化菌混培物)中的厌氧氨氧化活性分别下降41. 8%、17. 4%、33. 4.%,1、3号分别由于过度内源呼吸和高基质浓度抑制,导致活性下降较大,2号反应器由于基质浓度相对合适,避免了过度内源呼吸和高基质浓度抑制,使得菌种活性在该基质浓度下保留较好;储存期间,3个反应器内均发生内源呼吸消耗自身有机物的情况,导致EPS含量下降50. 9%、41. 7%、23. 7%和粒径下降31. 6%、16. 7%、8. 2%,表明在基质匮乏期菌体通过内源呼吸的方式维持自身的活性,较高的基质浓度可以在一定程度上延缓内源呼吸过程;在恢复期间,3个反应器分别经过15、10、7 d实现脱氮性能和厌氧氨氧化活性的恢复,表明同菌种增殖富集相比,原系统通过菌种活性增强的方式脱氮性能恢复更快.