综合防尘技术在开元公司的应用

主要介绍了采煤机高压引射降尘系统、液压支架自动喷雾、粉尘浓度在线检测超限自动喷雾等综合防尘技术在开元公司矿井中的应用。通过对降尘系统效果监测和分析,降尘效率达到84．1％,降尘效果明显,改善了作业场所的劳动卫生条件。     

罐采样-加压进样-气相色谱法测定环境空气中非甲烷总烃研究

建立了罐采样-气相色谱法测定环境空气中非甲烷总烃的分析方法。用罐采集环境空气样品至微负压状态,经除烃空气加压后,用气相色谱仪进行分析。并对氮气空白、除烃空气、样品保存期限、不同压力进样、不同正压压力进样、不同湿度、不同种类物质对总烃的贡献等进行了研究,在最佳实验条件下,非甲烷总烃的方法检出限为0.04μmol/mol,标准曲线相关系数均大于0.999 5,低、中、高浓度水平测定结果相对标准偏差均小于2.0%,低、中、高浓度的质控样品相对误差均小于2.0%。利用该方法对环境空气样品进行了检测分析,该法完全满足国家标准质控的要求,适用于环境空气和污染源无组织废气中非甲烷总烃的准确测定。     

Numerical and experimental study of the explosions caused by residual pressure in quick actuating vessels

The explosion accident caused by residual pressure is one of the most common kinds of accidents in quick actuating pressure vessels. And it is important to provide some reliable methods, which can give reasonable analysis of the explosion. In this study, experiments of the explosion are preformed by using two quick actuating pressure vessels with residual pressure, and a new mathematical model is presented. The model is based on the combination of the Spalart-Allmaras turbulence fluid model and Newton’s second Law for the solid motion. And the model is solved with local remeshing method. By performing the simulation with the same parameters of experiments, the results of the simulation confirm the accuracy of the model. And the results shows the crucial factor of vessel structure, which the maximum ejected speed of the lid highly depends on. Based on that, the optimal design of the structure is presented, which can provide better security.     

玉米淀粉粉尘爆炸危险性研究

为研究玉米淀粉粉尘爆炸危险性,采用哈特曼管式爆炸测试装置和20 L球爆炸测试装置对200目(<75μm)以下的玉米淀粉粉尘爆炸危险性进行评估,基于静电火花和粉尘质量浓度对粉尘爆炸的影响,对玉米淀粉的静电火花最小点火能量、爆炸下限质量浓度、最大爆炸压力和爆炸指数进行了研究,根据试验结果对玉米淀粉爆炸危险性进行分级。试验结果表明:温度在25℃,喷粉压力为0.80 MPa,粉尘质量浓度在250～750 g/m3范围内,粉尘的最小点火能量随着粉尘质量浓度增加而降低,其最小点火能量在40～80 mJ之间;在点火能量为10 kJ时,粉尘爆炸下限质量浓度在50～60 g/m3之间;在粉尘质量浓度为750 g/m3时,爆炸压力达到最大,为0.66 MPa;在粉尘质量浓度为500 g/m3时,爆炸指数达到最大,为17.21 MPa.m/s,其粉尘爆炸危险性分级为Ⅰ级。     

爆炸形成过程中火焰加速的试验研究

为预防和控制工业爆炸事故,并为脉冲爆轰发动机的研究提供理论指导,分析火焰加速导致的燃烧转爆轰过程的影响因素。采用爆轰管探讨障碍物的阻塞比、混合物的组成、初始压力和点火能等4个因素对爆炸性气体火焰速度和爆轰压力的影响规律。试验结果表明:障碍物的存在能大大提高火焰速度和爆轰压力;爆轰压力随管内障碍物阻塞比的增大先变大后减小,并在阻塞比为0.498,燃料种类为天然气,化学当量比为1时达到最大;爆轰压力还随混合气体初始压力的增大和点火能的提高而增大。选择适宜的条件可大大提高火焰加速速率,促进燃烧向爆轰过程转变。     

矿井避难硐室防护系统研究

根据避难硐室的防护功能,确定防护系统由防火防爆、密闭、供氧、制冷除湿、监测监控、动力、通讯、定位、照明、医疗、食品、水、卫生几大系统组成;通过理论分析,确定防火防爆密闭系统抗爆压力影响因素为反射压力、入射压力、静压载荷、门体材料及安全系数;通过计算,可得100人避难硐室压风供氧系统总供风量不得低于36m3/min,其他供氧方式的最小供氧量不得低于60L/min。为避难硐室防护系统研究提供了科学依据及可靠数据,为矿井紧急避险系统的研究奠定了基础。     

次声实验系统及其声学性能分析

为了从环境保护和劳动卫生学的角度研究次声对人的影响 ,本研究基于亥姆霍兹谐振器的基本原理研制了一个次声试验系统。该系统由亥姆霍兹谐振器、电声驱动部分和测控分析部分组成 ,通过对该系统的声学性能进行测试和分析 ,确定了系统所能发出的次声频率和次声级范围 ,讨论了系统发出次声时所产生的高次谐波对系统性能的影响及系统的频响特性 ,检验了谐振腔内部次声场空间分布的均匀性 ,结果表明该系统的声学性能是令人满意的 ,能够满足研究次声及其对人影响的实验要求。     

邢台煤矿矿井水的综合治理及利用

随着开采深度及范围的扩大，邢台煤矿井下高压出水点越来越多，既浪费了大量的排水费用，又对岩溶水环境和水资源造成了严重破坏。针对上述情况，用四种不同的方法分别进行了封堵和重新利用，使矿井减少了４８０ｍ＾３／ｈ的无效排水，经济效益和环保效益均十分明显。     

Water saving effect on integrated water resource management

This study proposes an improved integrated water resource management (IWRM), in which water conservation was analyzed for the entire water use process. A multi-objective optimization method was applied to optimize the IWRM, which investigated the reduction of freshwater consumption and the total water supply cost. Customer's preference for saving water and an end use analysis (EUA) was applied in the water conservation analysis. Taking Tianjin as the study area, a reduction in customer's economic pressure (EP) was utilized to evaluate the degree of the customer's preference for saving water. The results revealed that agriculture had a greater preference for saving water than other sectors, where as the public had the weakest motivation for saving water. Improving the transportation method could contribute 62.1% of the total water savings in the agriculture sector. The optimization of the IWRM demonstrated that the local freshwater savings would be 21.5%, and the total cost for water supplies would decrease by 13%. However, a government subsidy of 87.5 million Yuan would be needed. Additionally, by analyzing the change in the amount of water savings affected by water price, the appropriate water price increase range was suggested to be 1.5–1.7 times the original price.     

一种高压油管焊接质量评价方法

阐述了高压油管疲劳破坏的原理及危害,建立高压油管焊接质量评价力学模型,通过有限元分析技术对其许用位移输入进行计算,并结合应变测量技术,利用电动振动台,对高压油管焊接处的疲劳特性进行了试验验证。结果表明,此高压油管焊接质量评价方法是可行的,有限元分析技术和应变测量技术的结合使用,保证了试验的安全性和结果准确性,此外,利用电动振动台进行疲劳耐久试验,操作方便简单,成本相对较低,具有通用性。