某污水处理厂活性污泥沉降脱水性能的研究

以污泥沉降特性的参数及各参数之间的规律为研究目标,结果表明当活性污泥的SVI和MLSS分别在110-150,1500-2000mg/L时,污泥沉降速度在2-6min内有很明显的峰值,污泥界面高度变化明显.且在维持污泥沉降性能的前提下,随着污泥SVI(污泥指数)的增大,污泥的MLSS(污泥浓度)值呈递减趋势.具有相同污泥...     

Application of a new type of moving bio-film in aerobic sequencing batch reactor (aerobic-SBR)

A moving bio-film (MB), made from the inner tube of used tyres was applied in a conventional-aerobic-SBR for increasing the system efficiency and quality of bio-sludge due to good sedimentation (the density of 1.925+/-0.21 g/cm(3)), non-biodegradability and re-usability of the media without any regeneration. The total bio-sludge mass of the MB-aerobic-SBR was about 30% higher than that of the conventional-aerobic-SBR resulting in a reduction of the F/M value of the system and amount of suspended bio-sludge waste. The amount of suspended bio-sludge waste, SVI and SRT of the MB-aerobic-SBR under a low organic loading of 80+/-9.3g BOD(5)/m(3)-d were 1,485+/-146 mg/d, 51+/-3.7 ml/g and 10.1+/-5.1 days, respectively while they were 1,800+/-152 mg/d, 69+/-4.0 ml/g and 8.3+/-5.3 days, respectively in the conventional-aerobic-SBR. The BOD(5), TKN and TP removal efficiencies of the MB-aerobic-SBR were about 1-2, 2-3 and 10-12% higher, respectively, than that of the conventional-aerobic-SBR. Also, the BOD(5) and COD removal efficiencies of the MB-aerobic-SBR were higher than 95% even when the system was operated with synthetic wastewater containing 800 mg/l BOD(5) under a very low HRT of 1.5 days (organic loading of 528+/-50.8 g BOD(5)/m(3)-d). The effluent BOD(5), COD, total kjeldahl nitrogen, total phosphorus and suspended solids of the MB-aerobic-SBR under a high organic loading of 528+/-50.8 g BOD(5)/m(3)-d were 45+/-5.1, 37+/-3.6, 4.1+/-1.0, 1.5+/-0.80 and 41+/-2mg/l, respectively.     

水流紊动特性对活性污泥沉降性能的影响

为优化活性污泥处理系统的设计和运行,在SBR反应器中通过改变搅拌浆的转速,调整水流的紊动条件,借助粒子图像测速技术分析了反应器内水流的紊动特性,研究了反应器内不同区域紊动强度对活性污泥沉降性能的影响.结果表明,搅拌浆叶周围15mm的范围内,紊动强度远高于距桨叶更远的区域,距离浆板5mm的1-1断面和距离浆板60mm的3-3断面搅拌轴心处的紊动强度值分别反映了反应器搅拌主体区和其他区的紊动特征.随搅拌浆转速的增加,反应器内各区域的紊动强度逐渐增加,活性污泥的沉降性能表现出先改善后恶化的规律.当反应器搅拌主体区紊动强度1.51%,其他区紊动强度0.31%时,本试验条件下形成的活性污泥沉降指数(SVI)达到最小值67mL/g,界面沉降速率(ZSV)达到最大值0.20mm/s,活性污泥的沉降性能最佳.搅拌主体区范围较小,紊动强度较高,增强该区的紊动强度会加剧污泥的侵蚀破坏;其他区范围较大,紊动强度较低,增强该区的紊动强度对改善污泥的沉降效果作用明显.工程中可通过降低搅拌主体区的紊动强度,选择其他区适当的紊动强度,改善活性污泥的沉降性能.     

微膨胀对好氧颗粒污泥脱氮过程中N2O产生量的研究

采用控制低溶解氧(DO)在SBR反应器内,研究了好氧颗粒污泥微膨胀的实现;考察了微膨胀颗粒污泥对COD和氨氮去除效能以及温室气体N2O产生量.结果表明,在低DO条件下可以获得微膨胀颗粒污泥,污泥容积指数(SVI)大都在150～250 mL.g-1之间.微膨胀颗粒污泥对COD和氨氮去除量影响不大,COD去除率从89.45%上升到90.99%;氨氮去除率从77.29%降至68.29%;硝化速率从38.95×10-3 mg.(g.min)-1降至33.46×10-3 mg.(g.min)-1.微膨胀颗粒污泥对N2O产生量影响很大,微膨胀颗粒污泥N2O产生量为2.42 mg.m-3是没有发生微膨胀颗粒污泥N2O产生量的1.26倍.微膨胀颗粒污泥N2O释放速率由3.63×10-3mg.(L.min)-1上升到4.72×10-3mg.(L.min)-1.     

不同盐度下活性污泥中微生物群落变化规律及其处理模拟染料废水

通过逐渐提高SBR反应器中活性污泥的盐度,探索不同盐度下活性污泥的活性、性质及其微生物群落变化,并研究结晶紫废水以及纳米四氧化三铁对微生物群落的影响.结果表明,随着盐度的增加,活性污泥的COD、氨氮去除率以及污泥体积指数SVI值均降低,在质量分数2%的盐度下,COD、NH_4~+-N的去除率为80%和75%,SVI值不足35 mL·g~(-1);随着盐度的增加微生物的多样性逐渐减少,系统中革兰氏阴性菌优势菌种的位置逐渐被真菌和放线菌取代,而革兰氏阳性菌依然为优势菌;加入结晶紫染料的活性污泥与盐度为2%的活性污泥样品相比发现:红细菌属、丽水菌属含量有所增加,产黄杆菌、农杆菌属含量减小.加入MNPs的结晶紫-活性污泥与不加MNPs的结晶紫活性污泥对比:酸胞菌属、产黄杆菌含量增加,红细菌属、农杆菌属含量减小.     

活性污泥表面性质对絮凝沉降性能与出水悬浮物的影响

为了研究污水处理厂活性污泥表面性质对絮凝性能(flocculation ability,FA)和出水悬浮物(effluent suspend solid,ESS)的影响,测定了北京市7个不同污水处理厂活性污泥的表面性质,包括污泥容积指数(sludge volume index,SVI)和胞外聚合物(extracellular polymeric substance,EPS)中的蛋白质/多糖(protein/carbohydrate,P/C)比例、Zeta电位以及二维分形维数(twodimensional fractal dimension,D2f),并且通过相关性分析和拟合,探讨了这几个参数与活性污泥的FA和ESS的关系.结果表明,SVI与活性污泥的FA和ESS并不存在明显的相关关系,但FA和ESS存在明显的负线性相关关系(R_2=0.787);当EPS中的P/C从1.28增加到25.34时,FA可从0.19增加到0.73,ESS从14.89 mg·L~(-1)降低到6.08 mg·L~(-1),蛋白质中的氨基带有正电荷能够中和絮体表面的负电荷,其在EPS中所占的比例越大,有利于降低表面Zeta电位的绝对值和形成更稳定的絮体结构,进而提高絮凝能力.而且,Zeta电位与活性污泥的FA和ESS分别存在负线性相关(R_2=0.883)和正线性相关(R_2=0.902),当Zeta电位的绝对值每减小1 m V,FA提高0.059,ESS减少0.934 mg·L~(-1).此外,活性污泥的D2f与FA基本上呈现指数关系(R_2=0.935,P0.01),当D2f从1.10增加到1.45,FA提高了4.3倍,而同时D2f与ESS具有较好的负线性相关(R_2=0.868).     

Low intensity ultrasound stimulates biological activity of aerobic activated sludge

This work aims to explore a procedure to improve biological wastewater treatment efficiency using low intensity ultrasound. The aerobic activated sludge from a municipal wastewater treatment plant was used as the experimental material. Oxygen uptake rate (OUR) of the activated sludge (AS) was determined to indicate the changes of AS activity stimulated by ultrasound at 35 kHz for 0–40 min with ultrasonic intensities of 0–1.2 W/cm². The highest OUR was observed at the ultrasonic intensity of 0.3 W/cm² and an irradiation period of 10 min; more than 15% increase was achieved immediately after sonication. More significantly, the AS activity stimulated by ultrasound could last 24 h after sonication, and the AS activity achieved its peak value within 8 h after sonication, or nearly 100% higher than the initial level after sonication. Therefore, to improve the wastewater treatment efficiency of bioreactors, ultrasound with an intensity of 0.3 W/cm² could be employed to irradiate a part of the AS in the bioreactor for 10 min every 8 h. Translated from Environmental Science, 2005, 26(4): 124–128 [译自: 环境科学]     

SBR法处理啤酒废水DO对丝状菌污泥膨胀的影响

溶解氧(DO)浓度是影响丝状菌污泥膨胀最重要的因素之一。选用具有代表性的啤酒废水为处理对象,研究了SBR工艺中DO浓度对丝状菌污泥膨胀的影响。结果表明:高DO浓度(4～6.5mg/L)不会导致丝状菌污泥膨胀;低DO浓度能引起丝状菌污泥膨胀,当DO浓度降低至0.4mg/L时,SVI升高到210mL/g,会导致污泥膨胀发生。低DO浓度下污泥膨胀发生后,在较高的DO浓度条件下运行一定的周期数后,污泥膨胀能得到有效控制,使污泥沉降性能恢复到正常水平。     

A2O工艺好氧末段溶解氧变化对脱氮除磷影响

采用连续流A2O工艺处理实际的生活污水,研究好氧末段在不同溶解氧（DO）浓度条件下对污泥沉降性能、系统脱氮除磷的影响,同时考察了DO对污泥硝化活性、厌氧释磷速率和反硝化脱氮速率的影响。结果表明,随着末段溶解氧的提高,污泥容积指数SVI从140降至100左右,后又升高到120~170;系统的硝化效果提高,氨氮的去除率从60%升高到80%以上再到90%以上;总氮的去除效果也有显著提高,平均去除率从54%升高到63%再到67%;虽然磷的去除效果有所加强,总磷的平均去除率从41%升高到59%再到69%,但仍难达标。     

SVI在生物铁MBR与普通MBR中的变化分析

污泥指数SVI可反映出污泥的凝聚和沉降性能,因此可通过分析系统的SVI值来分析和判断系统运行的情况。文章通过分析生物铁MBR与普通MBR中污泥SVI值的变化情况,得出:生物铁MBR系统的污泥沉降性能良好,且SVI值均低于普通MBR,不会随进水负荷的变化发生很大的波动,系统的净水头压差也没有发生很大的波动;而普通MBR系统污泥SVI值随进水负荷增加变化迅速,且容易发生污泥膨胀,系统的净水头压差迅速攀升,而为了保证处理流量,必须提升净水头压差,说明膜污染比较严重。