污水处理厂污泥细菌总数和粪大肠菌群的检测

分别采用《城市污水处理厂污泥检验方法》（CJ／T221—2005）中平皿计数法和多管发酵法检测分析呼和浩特市周边7个城镇污水处理厂、2个制药企业以及2个乳制品企业污泥中的细菌总教和粪大肠菌群茵值。结果显示：供试样品的细菌总数为1．0×10^6～1．3×10^8个／g,其中细菌含量最高的是乳制品企业l污泥样品,最低的是污水处理厂4污泥样品。粪大肠菌群菌值为2．0×10^5-5．4×10^8个／g,其中粪大肠茵群菌值最高的是污水处理厂2和污水处理厂5污泥样品,最低的是污水处理厂4和制药企业1污泥样品,乳制品企业污泥样品的粪大肠菌群茵值居中。     

城市污泥中重金属有效态分布特征研究

以沈阳市北部污水处理厂剩余活性污泥为研究对象,对污泥中重金属Cd,Pb,Cu,Zn的含量及其形态分布特性进行分析。结果表明:污泥中4种重金属的含量基本符合国家相关控制标准(GB 18918-2002和CJ248-2007)。采用8种提取剂(0.05 mol/L EDTA,0.01 mol/L CaCl2,0.01 mol/LCa2(NO3)2,0.1 mol/L NaNO3,1 mol/L NH4OAC,0.43 mol/LHAC,0.05mol/L NaHCO3和0.05 mol/L Tris-HCl)分别对污泥中重金属的螯合态,中性交换态,酸溶态,碱溶态和蛋白质结合态进行分离分析。结果表明:4种重金属螯合态存在的比例较大,分别占各重金属总量的5.9%~27.2%,其次为酸溶态和中性交换态,而以碱溶态和蛋白质结合态形式存在的比例较少,除Cd外均低于1%。污泥中Cd和Pb具有较高的活性,而Cu,Zn在碱性污泥中主要以稳定态存在。     

猪粪秸秆高温堆肥过程中碳氮转化特征与堆肥周期探讨

将猪粪与秸秆以7：1（质量比,以鲜重计）的比例,在自制的强制通风静态堆肥反应箱中进行高温堆肥试验,研究了堆肥过程中碳氮转化特征及其腐熟时间.同时,在堆制的23d中,根据堆温变化采样6次,分析了堆肥样品中各种氮素和碳素含量及其它性质的变化情况.结果表明：堆肥结束时,硝态氮含量增加了103.0%,铵态氮、有机氮、总氮含量分...     

搅拌-序批式活性污泥反应器(WSBR)中好氧颗粒污泥的特性研究

为研究搅拌-序批式活性污泥反应器(WSBR)中好氧颗粒污泥的特性,利用WSBR反应器与传统SBR反应器对好氧活性污泥颗粒化的过程进行了比较.结果表明,在添加同量的聚炳烯酰胺(PAM)条件下,具有合理二次流场的WSBR反应器在4d就可见好氧颗粒污泥,而SBR反应器则在第10d才出现好氧颗粒污泥,且WSBR反应器中好氧颗粒...     

Effect of C/N ratio, aeration rate and moisture content on ammonia and greenhouse gas emission during the composting

Gaseous emission (N₂O, CH₄ and NH₃) from composting can be an important source of anthropogenic greenhouse gas and air pollution. A laboratory scale orthogonal experiment was conducted to estimate the effects of C/N ratio, aeration rate and initial moisture content on gaseous emission during the composting of pig faeces from Chinese Ganqinfen system. The results showed that about 23.9% to 45.6% of total organic carbon (TOC) was lost in the form of CO₂ and 0.8% to 7.5% of TOC emitted as CH₄. Most of the nitrogen was lost in the form of NH₃, which account for 9.6% to 32.4% of initial nitrogen. N₂O was also an important way of nitrogen losses and 1.5% to 7.3% of initial total nitrogen was lost as it. Statistic analysis showed that the aeration rate is the most important factor which could affect the NH₃ (p = 0.0189), CH₄ (p = 0.0113) and N₂O (p = 0.0493) emissions significantly. Higher aeration rates reduce the CH₄ emission but increase the NH₃ and N₂O losses. C/N ratio could affect the NH₃ (p = 0.0442) and CH₄ (p = 0.0246) emissions significantly, but not the N₂O. Lower C/N ratio caused higher NH₃ and CH₄ emissions. The initial moisture content can not influence the gaseous emission significantly. Most treatments were matured after 37 days, except a trial with high moisture content and a low C/N ratio.     

挥发回转窑处置钢丝绳行业污泥的污染物排放研究

通过利用挥发回转窑处置钢丝绳行业污泥的工业化试验,测定了烟气排放参数及污染物排放指标,分析了污泥添加对挥发回转窑烟气排放的影响程度及各项污染物指标之间的相关性。结果表明,污泥添加量18%～22%,对挥发回转窑烟气排放无影响,烟尘、SO2、氮氧化物、Zn、Pb、HCl等各项污染物指标均符合国家控制标准;烟尘排放浓度与Pb、Zn排放浓度呈显著正相关;SO2排放浓度与烟气含氧量、空气过剩系数、排放浓度呈显著负相关。通过控制烟气中烟尘浓度可减少Zn、Pb的排放,在满足SO2排放浓度达标的同时,还应加强工艺供氧量的管理,控制的产生,减少烟气对生产设备的腐蚀。     

造纸污泥综合利用热电项目验收监测难点及对策

近年来,随着环境监测技术规范化建设的不断发展,国家环保部相继出台了包括火力发电、水泥制造、汽车制造、造纸工业在内的12个不同行业类型的建设项目竣工验收技术规范。然而,造纸污泥综合利用热电项目验收监测尚未列入规范编制日程,其中工程调查、标准制定、点位布设和报告编制等环节仍存在一定误区和难点。文章例从上述薄弱环节入手,对常见难点问题提出了相应的解决办法,可供广大环境监测工作者参考和借鉴。     

应用新型好氧堆肥反应器连续投加处理人粪便的研究

针对间歇式堆肥反应器处理效率低、不便移动、单次投加所需物料量大等不足,以及为更有效地处理分散型人粪便,使人粪便资源化,开发了梨形筒式好氧堆肥反应器。在获得该反应器的最佳通风与搅拌频率分别为3.0 L/min,5 min/h以及最佳m（粪便）︰m（锯末）为1︰2.5的条件下进行连续投加人粪便好氧堆肥。在不接种微生物的30 d堆制过程中,升-降温周期为36 h,平均温度为51.44℃,第15天时COD降解率达到63.99%并趋于稳定,TN损失率第17天时达到56.68%,GI于第21天时达到106.25%,堆肥完全腐熟,稳定期处理效率为23.81 g/（L·d）。接种土著菌种时,升-降温周期缩短至24 h,平均温度为53.96℃,COD降解率8 d可达65.28%,TN 损失率仅为25.75%,GI于第8天达到108.22%,稳定期处理效率可达35.71 g/（L·d）,比不接种时提高1.5倍,同时节约能耗50%。     

SBR法处理低C/N污水的工程应用——以某基地污水处理站改造工程为例

低C/N污水的生化处理过程中,由于碳源不足,不能满足硝化和反硝化的要求,造成出水NH3-N超标。采用SBR工艺对某基地污水处理站厌氧处理后的低C/N污水进行改造,处理后出水COD去除率达到97%以上,NH3-N去除率达到93%以上。     

Metabolic uncoupler, 3,3′,4′,5-tetrachlorosalicylanilide addition for sludge reduction and fouling control in a gravity-driven membrane bioreactor

• Effects of metabolic uncoupler TCS on the performances of GDMBR were evaluated. • Sludge EPS reduced and transformed into dissolved SMP when TCS was added. • Appropriate TCS increased the permeability and reduced cake layer fouling. • High dosage aggravated fouling due to compact cake layer with low bio-activity. The gravity-driven membrane bioreactor (MBR)system is promising for decentralized sewage treatment because of its low energy consumption and maintenance requirements. However, the growing sludge not only increases membrane fouling, but also augments operational complexities (sludge discharge). We added the metabolic uncoupler 3,3′,4′,5-tetrachlorosalicylanilide (TCS) to the system to deal with the mentioned issues. Based on the results, TCS addition effectively decreased sludge ATP and sludge yield (reduced by 50%). Extracellular polymeric substances (EPS; proteins and polysaccharides) decreased with the addition of TCS and were transformed into dissolved soluble microbial products (SMPs) in the bulk solution, leading to the break of sludge flocs into small fragments. Permeability was increased by more than two times, reaching 60–70 L/m²/h bar when 10–30 mg/L TCS were added, because of the reduced suspended sludge and the formation of a thin cake layer with low EPS levels. Resistance analyses confirmed that appropriate dosages of TCS primarily decreased the cake layer and hydraulically reversible resistances. Permeability decreased at high dosage (50 mg/L) due to the release of excess sludge fragments and SMP into the supernatant, with a thin but more compact fouling layer with low bioactivity developing on the membrane surface, causing higher cake layer and pore blocking resistances. Our study provides a fundamental understanding of how a metabolic uncoupler affects the sludge and bio-fouling layers at different dosages, with practical relevance for in situ sludge reduction and membrane fouling alleviation in MBR systems.