驯化活性污泥SBR工艺处理乳制品废水研究

乳制品废水直接采用生物法处理在现有研究中较少,为验证处理效果,将4阶段驯化后的活性污泥投加到SBR中,进行了低浓度乳制品废水的直接生物降解试验,主要考察了对COD、NH4-N的去除效果,结果显示:活性污泥驯化期间,COD、NH4-N平均去除率分别为93%、90%;驯化后的活性污泥处理效果稳定,当进水COD为1654 mg/L、NH4-N为115 mg/L时,出水COD、NH4-N分别为66 mg/L、2 mg/L,达到《污水综合排放标准》(GB 8978-1996)一级排放标准,证明了用驯化活性污泥直接处理低浓度乳制品废水是可行的.     

不同温度下微生物和纤维素酶对发酵猪粪理化特性的影响

采用恒温发酵培养试验,研究了5℃和25℃时分别接种纤维素酶(X)、枯草芽孢杆菌(K)和EM菌(E)及其组合对新鲜猪粪发酵中的全氮、铵态氮、有机质、p H及微生物数量的影响.结果表明,5℃条件下,猪粪中微生物生长受抑制,细菌、真菌、放线菌数量均明显低于25℃,发酵终期猪粪有机质含量为70%~83%,p H值为7.16~7.36;25℃条件时,发酵终期猪粪有机质含量降至61%~72%,p H值升至8.09~8.94.与对照相比较,25℃下添加微生物和纤维素酶的处理有机质含量降低了2.95%~7.70%(除了K和XE处理),C/N值降低了4.04%~37.59%(除了XK处理),p H值增加了1.7%~26.8%.在总的添加量一致的条件下,发酵剂组合KE、XE、XK、XKE对猪粪发酵的效果优于单一发酵剂的X、K、E处理.     

连续施用发酵猪粪对土壤中四环素抗性基因数量的影响

为了研究连续施用发酵猪粪之后,土壤中抗性基因的数量以及发酵猪粪的施用量对土壤抗性基因的影响,采用实时荧光定量PCR方法,对稻麦轮作模式下连续6年施用4.5t/hm2和9.0t/hm2发酵猪粪的土壤进行了四环素抗性基因(TRGs)的检测和定量分析.在施用发酵猪粪的土壤中能够检测到9种TRGs.施用发酵猪粪显著增加了土壤中tet G、tet L、tet B(P)、tet O、tet W的绝对数量,其中tet B(P)、tet W、tet O的绝对数量受到了施肥用量的影响;而tet Z、tet C和tet S的绝对数量则没有受到施肥的影响.上述8种TRGs在同一施肥处理的0~5cm、5~10cm以及10~20cm土壤中的相对丰度分布均无显著差异.发酵猪粪的施用也显著增加了tet G、tet L、tet B(P)和tet O的相对丰度,但是仅有tet O的相对丰度受到了施肥用量的显著影响.本研究表明,在稻麦轮作模式下,农田土壤中的TRGs数量会受到发酵猪粪中残留TRGs的影响,连续施用该粪肥会显著增加土壤中tet G、tet L、tet B(P)和tet O的绝对数量和相对丰度.因此,需要优化畜禽粪堆肥发酵工艺,以减少抗性基因在粪肥中的残留.     

麦秆酸预处理后与猪粪混合发酵提高产气量的效应研究

为了研究不同水平的酸处理对麦秆混合发酵过程中各指标变化的影响,本试验通过测定不同醋酸浓度、时间处理后的麦秆与猪粪混合厌氧发酵进程中还原糖、挥发性脂肪酸(VFA)含量,以及p H值变化和甲烷产量,探究各指标的关系并优化得出最佳醋酸处理组合,以期为酸预处理混合发酵实现高甲烷产量提供可靠的理论依据.结果表明,醋酸处理后的麦秆通过与猪粪混合发酵可明显提高甲烷单位产量,增幅为124.28%~207.40%.发酵过程中还原糖、VFA、p H值间相互影响.通过响应面法建立模型,得到醋酸处理的最优组合为浓度3.35%、时间6.75d,最大甲烷单位产量751.97 m L·g-1(以VS计).     

Excretion of manure-borne estrogens and androgens and their potential risk estimation in the Yangtze River Basin

The Yangtze River is the longest river in China, and the river basin spans one fifth of the area of the whole country. Based on statistical data, the excretion of manure-borne steroid hormones, including steroid estrogens(SEs) and steroid androgens(SAs), in 10 provinces of China within the region has been estimated. The potential environmental and ecological risk of manure-borne steroid estrogens to the surface water in this region was also assessed. The manure-borne SE and SA excretions in the 10 provinces and municipalities vary in the order: Sichuan Hunan Hubei Yunnan Jiangsu Anhui Jiangxi Chongqing Qinghai Shanghai. The highest increase of manure-borne SEs(1434.3 kg)and SAs(408.5 kg) was found in Hunan and Hubei provinces, respectively, and the total excretion in 2013 was 65% more than 15 years earlier in these two provinces. However, the emissions in Anhui and Shanghai decreased in this 15 year period of time. Swine urine,chicken feces, cattle urine, and laying hen feces were considered the dominant sources of manure-borne E1, βE2, αE2, and SAs, respectively. Although Jiangsu province did not have the largest excretion of manure-borne SEs, it had the highest level of predicted17β-estradiol equivalency(EEQs) value of 16.65 ng/L in surface water because of the limited surface water resources. According to the lowest observable effect level of 10 ng/L for17β-estradiol, the manure-borne SEs in Jiangsu province might potentially pose ecological risk to its wild aquatic organisms.     

Investigation of physico-chemical properties and microbial community during poultry manure co-composting process

Co-composting of poultry manure and rubber wood sawdust was performed with the ratio of 2:1(V/V) for a period of 60 days. An investigation was carried out to study the extracellular enzymatic activities and structural degradation utilizing Fourier transform infrared spectroscopy(FT-IR), thermogravimetry and differential thermal analysis(TG/DTA)and scanning electron microscopy(SEM). The microbial succession was also determined by using denaturing gel gradient electrophoresis(DGGE). The compost was able to reach its highest temperature of 71°C at day 3 and stabilized between 30 and 40°C for 8 weeks.CMCase, FPase and β-glucosidase acted synergistically in order to degrade the cellulosic substrate. The xylanase activities increased gradually during the composting and reached the peak value of 11.637 U/g on day 35, followed by a sharp decline. Both Li P and Mn P activities reached their peak values on day 35 with 0.431 and 0.132 U/g respectively. The FT-IR spectra revealed an increase in aromaticity and a decrease in aliphatic compounds such as carbohydrates as decomposition proceeded. TGA/DTG data exhibited significant changes in weight loss in compost samples, indicating degradation of organic matter. SEM micrographs showed higher amounts of parenchyma exposed on the surface of rubber wood sawdust at day 60, showing significant degradation. DGGE and 16 S r DNA analyses showed that Burkholderia sp., Pandoraea sp., and Pseudomonas sp. were present throughout the composting process. Ornithinibacillus sp. and Castellaniella ginsengisoli were only found in the initial stage of the composting, while different strains of Burkholderia sp. also occurred in the later stage of composting.     

热处理对猪粪高固厌氧消化产甲烷能力的影响

畜禽粪便属于有机物含量高、卫生风险大的污染物.本研究探寻不同热处理时间下,猪粪(含固率27.6%)不稀释直接进行70℃热处理的情况及热处理对中温高固厌氧消化的影响.结果表明,热处理能够去除猪粪的部分有机物,并能明显提高高固厌氧消化的产甲烷能力和产甲烷速率.热处理时间为1、2、3和4 d时,热处理对猪粪的VS去除率分别为15.1%、15.5%、17.8%、20.0%,甲烷产率(以CH4/VSadd计)分别为284.4、296.3、309.2、264.4 m L·g-1,相比原粪的甲烷产率分别提高49.7%、55.9%、62.7%、39.2%.热处理时间为3 d时,猪粪的甲烷产率最高.热处理对猪粪产甲烷的促进效果显著,能耗适中,并能够起到巴氏消毒的作用,具有较好的工程价值.     

微生物调控对牛粪堆肥的生物特性影响

研究了微生物调控对牛粪堆肥生物特性的影响.结果表明:(1)与对照相比,接菌(添加HM菌剂)处理可使牛粪堆肥提前2d进入高温期,高温持续时间延长2d.即接菌处理的堆肥温度在第4天达到50.5℃,并保持50℃以上的温度14 d;而对照在第6天达到50.0℃,并保持50℃以上的温度12 d.(2)2种处理堆肥的pH总体呈先升高后降低的趋势,接菌处理的堆肥pH上升幅度不大,比对照低0.1～0.5个pH单位.(3)接菌处理有利于提高牛粪堆肥的纤维素酶、蔗糖酶、脲酶活性水平和峰值.(4)脲酶活性与其他因素之间呈显著负相关(p＜0.01),而温度、pH、蔗糖酶活性和纤维素酶活性之间呈显著正相关(p＜0.01).     

Textural and chemical properties of swine-manure-derived biochar pertinent to its potential use as a soil amendment

Biochars have received increasing attention in recent years because of their properties pertaining to soil fertility and contaminant immobilization as well as serving as carbon sinks. In this work, a series of biochars were produced from dried swine manure waste by slow pyrolysis at different temperatures (i.e., 673-1073 K). The characterization of the resulting biochars was examined for its relevance to its potential use as soil amendment. It was found that the pore properties, ash contents and pH values of all swine-manure-derived biochars basically increased as temperature increased, while the yield and nitrogen/oxygen contents decreased with increasing temperature as a result of pyrolytic volatilization during pyrolysis. From the organic and inorganic elements analyses, the manure-derived biochar was rich in soil nutrients such as N, P, Ca, Mg, and K. Furthermore, the pore, surface and chemical properties were also consistent with the observations of the SEM-EDS, XRD and FTIR. This result suggested that the mesoporous manure-derived biochar could be used as an excellent medium to soil environment.     

微生物生理群在猪粪秸秆高温堆肥碳氮转化中的作用

在自制的强制通风静态堆肥反应箱中,猪粪与秸秆以鲜重7∶1的比例进行了堆肥化实验,在堆制的23 d里根据堆温变化分阶段采集堆肥样品,利用MPN法测定了堆料中纤维素分解菌和氮素微生物生理群的数量变化,同时测定了相应的碳、氮含量。结果表明,纤维素分解菌在稳定腐熟阶段较多,对于后期有机碳的降解和腐殖质含量的增大起了很大的作用,在堆制的23 d里,腐殖质增加了2.4%。整个堆制过程中,氨化细菌的数量最大且与氨气释放浓度和铵态氮含量呈显著正相关,都在高温期增加,降温期后减少,氨化细菌的数量在高温期的增加率远高于降温期后的减少率,而铵态氮在高温期的增加率远低于在降温后期的减少率,铵态氮总体上减少了74.1%;亚硝化细菌数量与硝态氮呈正相关;反硝化细菌数量在降温期上升幅度较大,堆制结束时为堆制初期的13倍,且与堆肥中硝态氮含量呈正相关;硝态氮含量增加了87.5%;堆肥后期硝态氮的增加可能与堆肥中存在能进行硝化作用的反硝化细菌有关。固氮菌数量在堆制结束时达堆制初期的2.61倍,主要在降温期增加较多,对堆肥中有机氮的形成起很大作用。